NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
46 reportsClear category filterMileage unknown · Jul 12, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED THE VEHICLE HAS A FAULTY ELECTRICAL BRAKE LIGHT SWITCH CAUSING THE VEHICLE TO MALFUNCTION AND THE BRAKE LIGHT TO ILLUMINATE. THE DEALERS DETERMINED THAT THE VEHICLE WAS NOT PART OF A RECALL ALTHOUGH THE VEHICLE EXPERIENCES SIMILAR SYMPTOMS. THE CONTACT RESEARCHED ONLINE TO CHECK ON RECALLS PERTAINING TO…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE HAS A FAULTY ELECTRICAL BRAKE LIGHT SWITCH CAUSING THE VEHICLE TO MALFUNCTION AND THE BRAKE LIGHT TO ILLUMINATE. THE DEALERS DETERMINED THAT THE VEHICLE WAS NOT PART OF A RECALL ALTHOUGH THE VEHICLE EXPERIENCES SIMILAR SYMPTOMS. THE CONTACT RESEARCHED ONLINE TO CHECK ON RECALLS PERTAINING TO THE VEHICLE'S SYMPTOMS, RECALL #04V096000 IDENTIFIED SIMILARITIES. THE DEALERS OFFERED TO REPLACE THE PART FOR A COST.
NHTSA ODI #10162254
20,000 miles · Oct 9, 2005
Service Brakes, Hydraulic
WE HAVE A 2002 VOLKSWAGEN JETTA TDI GLS. SINCE THE VEHICLE WAS NEW WE HAVE HAD AN INTERMITTENT SERIOUS PROBLEM WITH THE BRAKING SYSTEM. WE LIVE NEAR FORT COLLINS, CO; WHEN WE TRAVEL TO OTHER PARTS OF THE COUNTRY WITH LOWER ELEVATION, OUR BRAKES BEGIN TO MALFUNCTION. INITIALLY, THEY BEGIN TO DRAG; YOU USUALLY HAVE TO TURN OFF …
Read full complaint
WE HAVE A 2002 VOLKSWAGEN JETTA TDI GLS. SINCE THE VEHICLE WAS NEW WE HAVE HAD AN INTERMITTENT SERIOUS PROBLEM WITH THE BRAKING SYSTEM. WE LIVE NEAR FORT COLLINS, CO; WHEN WE TRAVEL TO OTHER PARTS OF THE COUNTRY WITH LOWER ELEVATION, OUR BRAKES BEGIN TO MALFUNCTION. INITIALLY, THEY BEGIN TO DRAG; YOU USUALLY HAVE TO TURN OFF THE IGNITION TO GET THEM TO RELEASE. SOMETIMES YOU CAN PUMP THEM HARD AND GET THEM TO RELEASE. DURING THIS PHASE THE BRAKES WEAR QUICKLY AND BECOME VERY HOT. WITHIN A DAY THE PROBLEM PROGRESSES TO A MUCH WORSE CONDITION. AS YOU PRESS THE BRAKE PEDAL, THE PEDAL FEELS AS THOUGH IT IS PULLING AWAY FROM YOUR FOOT. AS YOU PRESS A LITTLE MORE, THE PEDAL SUDDENLY PULLS VIOLENTLY FROM YOUR FOOT AND THE VEHICLE BRAKES SLAM ON. AT THIS TIME THE ABS DOES NOT WORK AS FAR AS I CAN TELL. WHEN THE BRAKES PULL FROM YOUR FOOT THERE IS A NOISE LIKE AIR BEING SUCKED INTO SOMETHING. WHEN THE BRAKES SLAM ON IN THIS FASHION, ONE OF SEVERAL THINGS HAPPEN. THE BRAKES MAY STAY LOCKED ON, LEAVING YOU TO TRY TO GET THEM TO RELEASE, OFTEN IN AN INTERSECTION OR TRAFFIC. THEY MAY RELEASE ENTIRELY, AND BE OKAY UNTIL THE NEXT BRAKING INCIDENT. MANY TIMES THEY DRAG SOMEWHERE BETWEEN LIGHT ENOUGH THAT YOU MIGHT JUST THINK THE CAR IS RUNNING POORLY TO SO HEAVILY THAT YOU CAN BARELY MOVE THE CAR WITHOUT KILLING THE ENGINE. WE WERE MOST RECENTLY IN THE PORTLAND, OREGON AREA WHEN THIS HAPPENED. IT BEGAN TO HAPPEN THE FIRST NIGHT WE WERE IN TOWN, WITH THE DRAGGING. THE NEXT MORNING WE DROVE TO THE COAST, AND THE MORE SERIOUS MALFUNCTION BEGAN. WE TRIED TO DRIVE AROUND A SMALL COASTAL TOWN, ONLY TO HAVE TO PARK AND WALK EVERYWHERE WE NEEDED TO GO. ON THE WAY BACK WE WERE UNFORTUNATE TO FIND OURSELVES IN BUMPER TO BUMPER, STOP AND GO TRAFFIC. WITH NEARLY EVERY SINGLE USE OF THE BRAKES, THEY WOULD SLAM TO THE FLOOR. WE HAVE TO TRY TO STAY FAR ENOUGH AWAY FROM OTHER VEHICLES TO AVOID BEING HIT FROM BEHIND OR SKIDDING INTO THE VEHICLE IN FRONT OF US. *NM
NHTSA ODI #10139134
54,000 miles · Sep 26, 2005
Service Brakes, Hydraulic
I OWN A 2002 VW JETTA TDI. THREE TIMES NOW I HAVE HAD A SERIOUS INCIDENT WITH MY BRAKES. WHILE DRIVING AT LOW SPEEDS, UNDER 25 MPH, THE BRAKE PEDAL HAS PULLED ITSELF TO THE FLOOR AND SHARPLY APPLIED THE BRAKES WHILE I WAS DRIVING. MY FOOT WAS ON THE ACCELERATOR WHILE THIS OCCURRED. THERE IS ALSO A LOUD PRESSURE RELEASE SOUND…
Read full complaint
I OWN A 2002 VW JETTA TDI. THREE TIMES NOW I HAVE HAD A SERIOUS INCIDENT WITH MY BRAKES. WHILE DRIVING AT LOW SPEEDS, UNDER 25 MPH, THE BRAKE PEDAL HAS PULLED ITSELF TO THE FLOOR AND SHARPLY APPLIED THE BRAKES WHILE I WAS DRIVING. MY FOOT WAS ON THE ACCELERATOR WHILE THIS OCCURRED. THERE IS ALSO A LOUD PRESSURE RELEASE SOUND COMING FROM THE BRAKE PEDAL AFTER IT APPLIED ITSELF. THIS HAPPENS INTERMITTENTLY AND THE DEALER HAS NOT BEEN ABLE TO CORRECT IT YET. *JB
NHTSA ODI #10137579
42,995 miles · Sep 19, 2005
Air BagsService Brakes, HydraulicVehicle Speed ControlCrash
ON 9/17/2005 I WAS PULLING INTO MY ASSIGNED PARKING SPOT AT MY CONDO. I WAS APPROXIMATELY TRAVELING ABOUT 3 MPH AND HAD MY BRAKES APPLIED TO MANEUVER INTO MY PARKING SPOT. UPON REACHING THE CURB, I APPLIED PRESSURE TO THE BRAKES AND EXPECTED TO COME TO A COMPLETE STOP. HOWEVER, MY CAR LUNGED FORWARD AND ENDED UP IN MY NEIGHB…
Read full complaint
ON 9/17/2005 I WAS PULLING INTO MY ASSIGNED PARKING SPOT AT MY CONDO. I WAS APPROXIMATELY TRAVELING ABOUT 3 MPH AND HAD MY BRAKES APPLIED TO MANEUVER INTO MY PARKING SPOT. UPON REACHING THE CURB, I APPLIED PRESSURE TO THE BRAKES AND EXPECTED TO COME TO A COMPLETE STOP. HOWEVER, MY CAR LUNGED FORWARD AND ENDED UP IN MY NEIGHBOR'S LIVING ROOM. MY CAR ONLY STOPPED AFTER TAKING OUT THE BRICK STRUCTURE AND FRONT WINDOW OF HER CONDO. BEFORE MAKING IMPACT WITH THE OUTSIDE STRUCTURE I ATTEMPTED TO BRAKE TWICE WITH NO RESPONSE. THE IMPACT WAS SUBSTANTIAL AND YET THE AIRBAGS NEVER DEPLOYED. MY CAR WAS TOWED TO A GARAGE THAT MY INSURANCE APPROVED AND NOT TO THE DEALERSHIP WHO HAS SERVICED MY CAR FOR ALL THE CURRENT RECALLS AND VARIOUS PROBLEMS. THE RECALLS AND PROBLEMS INCLUDE THE BRAKE LIGHT SWITCH, REPLACEMENT OF THE COIL IGNITION, ARMREST BREAK, ALARM SOUNDING FOR NO REASON, AND THE WINDOW FALLING INTO THE DOOR FRAME. THIS ACCIDENT CAUSED SERIOUS PROPERTY DAMAGE AND THE POLICE WERE CALLED TO THE SCENE. THE POLICE ACKNOWLEDGED MY SKID MARKS AND MY ATTEMPT AT APPLYING THE BRAKES. THE SITUATION WAS TREATED/CITED AS A CAR ACCIDENT SO THAT MY NEIGHBOR AND I COULD GO THROUGH THE PROPER PROCEDURES OF HER DAMAGES BEING REIMBURSED. I PLAN TO PROVE MY CAR IS DEFECTIVE AND A LEMON. I WOULD APPRECIATE ANY FEEDBACK, ADVICE OR SUGGESTIONS REGARDING MY SITUATION. *NM *GEM
NHTSA ODI #10136890
88,000 miles · Jul 17, 2005
Service Brakes, Hydraulic
OVER THE PAST FEW MONTHS I HAVE BEEN EXPERIENCING DIFFICULTY WITH AN INTERMITENT PROBLEM WITH MY CAR. PERIODICALLY THE CAR WOULD NOT ACCELERATE PAST 10-15 MILES AN HOUR RESULTING IN THE CAR GOING INTO OVERDRIVE. THE CAR WAS TOWED TWICE IN TWO WEEKS. AFTER THE FIRST TOW, THE DEALERSHIP COULD NOT DETECT THE PROBLEM AND RETURNED TH…
Read full complaint
OVER THE PAST FEW MONTHS I HAVE BEEN EXPERIENCING DIFFICULTY WITH AN INTERMITENT PROBLEM WITH MY CAR. PERIODICALLY THE CAR WOULD NOT ACCELERATE PAST 10-15 MILES AN HOUR RESULTING IN THE CAR GOING INTO OVERDRIVE. THE CAR WAS TOWED TWICE IN TWO WEEKS. AFTER THE FIRST TOW, THE DEALERSHIP COULD NOT DETECT THE PROBLEM AND RETURNED THE CAR TO ME EVEN THOUGH I FELT UNSAFE DRIVING THE VEHICLE. THE SECOND TIME, THE CAR WAS MOVING AT 40MPH AND THEN DROPPED TO 5 MPH ON A BUSY HIGHWAY, WHERE I WAS CLOSE TO CAUSING A SERIOUS ACCIDENT. I DEMANDED THAT THE DEALERSHIP KEEP THE CAR AND CONTINUE TO TEST DRIVE THE CAR UNTIL THEY DETECTED THE PROBLEM, WHICH THEY FINALLY FOUND. THEY FOUND A DEFECT IN THE BRAKE SYSTEM WHERE THE BRAKES WOULD CEASE WHILE DRIVING RESULTING IN THE COMPLETE REPLACEMENT OF THE BRAKE BOOSTER SYSTEM AND BRAKE PEDDLE, WHICH THE DEALERSHIP CLAIMED WAS DEFECT FROM THE MANUFACTURER AS IT IS A RARE OCCURANCE. APPROX. $700., THE CAR IS RETURNED ALTHOUGH I CONTINUE TO FEEL UNSAFE DRIVING THE CAR. ALSO, BECAUSE OF THIS DEFECT, IT REQUIRED ME TO REPLACE BRAKE PADS X2 IN A TWO WEEK PERIOD. I AM CONCERNED THAT THIS DEFECT HAS NOT BEEN A RECALL OF SOME KIND. PLEASE ADVISE.
NHTSA ODI #10129043
36,095 miles · Jun 10, 2005
Service Brakes, Hydraulic
DT: CONSUMER STATES THAT VEHICLE IS HAVING EXCESSIVE VIBRATION WHILE BRAKING AT MEDIUM SPEEDS. OWNER DID TAKE THE VEHICLE IN TO BE SERVICED, AND HAD THE REAR BRAKE DISCS REPLACED. IT HAS CAUSED THE FRONT END TO VIBRATE WORSE.*AK
NHTSA ODI #10124957
Mileage unknown · Feb 3, 2005
Service Brakes, Hydraulic
WHILE DRIVING IN INCLEMENT WEATHER, THE CONSUMER APPLIED THE BRAKE, BUT THEY FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INSPECTED THE VEHICLE AND DETERMINED THAT THE BRAKES WERE FROZEN AND THAT THE ROTORS WERE BENT. THE POWER BOOSTER AND ROTORS NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER …
Read full complaint
WHILE DRIVING IN INCLEMENT WEATHER, THE CONSUMER APPLIED THE BRAKE, BUT THEY FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INSPECTED THE VEHICLE AND DETERMINED THAT THE BRAKES WERE FROZEN AND THAT THE ROTORS WERE BENT. THE POWER BOOSTER AND ROTORS NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *JB
NHTSA ODI #10109756
Mileage unknown · Jan 24, 2005
Service Brakes, Hydraulic
WHEN THE CONSUMER APPLIED THE BRAKES THE PEDAL WENT TO THE FLOOR.. THE CONSUMER WAS ABLE TO PUMP THE BRAKES AND THE VEHICLE CAME TO A COMPLETE STOP. THE CONSUMER TOOK THE VEHICLE TO THE DEALER TO BE INSPECTED, HOWEVER THEY WERE UNABLE DUPLICATE THE PROBLEM. *JB
NHTSA ODI #10108771
80,000 miles · Dec 6, 2004
Service Brakes, Hydraulic
THE BOOSTER AND MASTER CYLINDER WERE DEFECTIVE. WHEN TOUCHING THE BRAKES THEY LOCKED UP.*AK. BOOSTER AND MASTER CYLINDER ARE GOOD, BUT SHAFT BETWEEN THE TWO MISALIGNED AND HANGS UP. CANNOT REALIGNED. *AK....MANUFACTURER INSISTED THAT BOOSTER AND MASTER CYLINDER WERE GOOD, BUT SHAFT BETWEEN THE TWO WAS MISALIGNED, COULD NO…
Read full complaint
THE BOOSTER AND MASTER CYLINDER WERE DEFECTIVE. WHEN TOUCHING THE BRAKES THEY LOCKED UP.*AK. BOOSTER AND MASTER CYLINDER ARE GOOD, BUT SHAFT BETWEEN THE TWO MISALIGNED AND HANGS UP. CANNOT REALIGNED. *AK....MANUFACTURER INSISTED THAT BOOSTER AND MASTER CYLINDER WERE GOOD, BUT SHAFT BETWEEN THE TWO WAS MISALIGNED, COULD NOT REALIGN IT. HAS TO REPLACE IT AT $640.00. *AK
NHTSA ODI #10103196
Mileage unknown · Nov 26, 2004
Service Brakes, Hydraulic
A FEW WEEKS AGO I WAS DRIVING MY 02 JETTA TDI AND WAS SITTING AT A LIGHT WITH THE BRAKES APPLIED. ONCE THE LIGHT TURNED GREEN I RELEASE THE PEDAL AND IT HAD A HYDRAULIC RELEASE SOUND, LIKE A SWISHING NOISE. THE BRAKES WERE STILL ON BUT THE PEDAL HAD RELEASED. I TAPPED THE PEDAL AND THEY RELEASED. OVER THE COURSE OF MY DRIVE …
Read full complaint
A FEW WEEKS AGO I WAS DRIVING MY 02 JETTA TDI AND WAS SITTING AT A LIGHT WITH THE BRAKES APPLIED. ONCE THE LIGHT TURNED GREEN I RELEASE THE PEDAL AND IT HAD A HYDRAULIC RELEASE SOUND, LIKE A SWISHING NOISE. THE BRAKES WERE STILL ON BUT THE PEDAL HAD RELEASED. I TAPPED THE PEDAL AND THEY RELEASED. OVER THE COURSE OF MY DRIVE HOME EVERY TIME I APPLIED THE BRAKES THE PEDAL WOULD SUCK ALL THE WAY TO THE FLOOR AND MAKE THAT SWISHING SOUND. THE CAR WOULD JOLT AS THE BRAKES APPLIED FULL FORCE. OTHER TIMES THEY WOULD STAY APPLIED AND I WOULD HAVE TO TAP THE PEDAL AND THEN THEY WOULD RELEASE. I GOT HOME AND LATER DECIDED TO TEST THE CAR OUT AGAIN. AND IT DID NOTHING! THE CAR DROVE FINE FOR A COUPLE WEEKS. TODAY THE PROBLEM STARTED AGAIN SUDDENLY. ADVICE. HELP. THANKS. *AK
NHTSA ODI #10100576
Official recalls
5Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration