NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
46 reportsClear category filter102,000 miles · Dec 3, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TURNING THE VEHICLE, SHE HEARD A LOUD NOISE THEN SUDDENLY ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE THEN STALLED. THE VEHICLE WAS INSPECTED BY A INDEPENDENT MECHANIC WHO INFORMED HER THAT THE FAILURE WAS THE ABS SENSOR. TH…
Read full complaint
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TURNING THE VEHICLE, SHE HEARD A LOUD NOISE THEN SUDDENLY ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE THEN STALLED. THE VEHICLE WAS INSPECTED BY A INDEPENDENT MECHANIC WHO INFORMED HER THAT THE FAILURE WAS THE ABS SENSOR. THE CONTACT REFERENCED NHTSA CAMPAIGN ID (02V031000) SERVICE BRAKES: HYDRAULIC: ANTI-LOCK. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 102,000.
NHTSA ODI #10369064
134,221 miles · Mar 30, 2010
Exterior LightingService Brakes, Hydraulic
I HAVE A 2002 VOLKSWAGEN JETTA AND I HAVE A BRAKE LIGHT SWITCH ISSUE (BRAKE LIGHT STAYS ON AND A DCT(P0571) IS SET) THAT WAS DESCRIBED IN THE RECALL/REPLACEMENT, BUT THE VIN GROUP THAT THIS APPLIES TO IS 3VW---9M-YM000089 TO 3VW---9M-2M053565, AS YOU CAN SEE, MINE IS JUST OUT SIDE THE HIGH VIN. THE VIN RANGE SHOULD BE READDRESS…
Read full complaint
I HAVE A 2002 VOLKSWAGEN JETTA AND I HAVE A BRAKE LIGHT SWITCH ISSUE (BRAKE LIGHT STAYS ON AND A DCT(P0571) IS SET) THAT WAS DESCRIBED IN THE RECALL/REPLACEMENT, BUT THE VIN GROUP THAT THIS APPLIES TO IS 3VW---9M-YM000089 TO 3VW---9M-2M053565, AS YOU CAN SEE, MINE IS JUST OUT SIDE THE HIGH VIN. THE VIN RANGE SHOULD BE READDRESSED TO INCLUDE ALL 2002 MODEL JETTAS WITH CRUISE CONTROL. THANK YOU FOR YOUR PROMPT ATTENTION TO THIS MATTER. *TR
NHTSA ODI #10322862
76,000 miles · Feb 17, 2010
Engine And Engine CoolingService Brakes, Hydraulic
ABS WARNING LIGHT AND CHECK ENGINE LIGHT LIT UP IN 2002 JETTA. *TR
NHTSA ODI #10311433
68,300 miles · Jun 24, 2008
Service Brakes, Hydraulic
WHEN GENTLY APPLYING PRESSURE TO THE BRAKE PEDAL THE BRAKES WOULD SUDDENLY FULLY ENGAGE FOR A MOMENT AND THEN RETURN TO NORMAL. THIS OCCURRED EVERY TIME THE BRAKES WERE APPLIED. THERE WERE NO CONSEQUENCES IN MY CASE, BUT IT IS NOT HARD TO IMAGINE THIS CAUSING A CAR TO BE HIT FROM THE REAR OR CAUSING A LOSS OF CONTROL IN SLIP…
Read full complaint
WHEN GENTLY APPLYING PRESSURE TO THE BRAKE PEDAL THE BRAKES WOULD SUDDENLY FULLY ENGAGE FOR A MOMENT AND THEN RETURN TO NORMAL. THIS OCCURRED EVERY TIME THE BRAKES WERE APPLIED. THERE WERE NO CONSEQUENCES IN MY CASE, BUT IT IS NOT HARD TO IMAGINE THIS CAUSING A CAR TO BE HIT FROM THE REAR OR CAUSING A LOSS OF CONTROL IN SLIPPERY CONDITIONS. TO CORRECT THE SITUATION THE BRAKE BOOSTER NEEDED TO BE REPLACED. *TR
NHTSA ODI #10232182
72,501 miles · May 19, 2008
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
I PURCHASED THE 2002 VOLKSWAGEN JETTA IN AUGUST OF 2006. THE FIRST SET OF REPAIRS WAS ON 3/2007 AT 64,332 MI CHECK ENGINE LIGHT MULITPLE MISFIRES: P0300, P0301, P0302, P0303, P0304 REPLACED IGNITION COILS COST: $200.11 SECOND REPAIR TOOK PLACE IN APRIL OF 2007 TOOK CAR IN FOR RECALL - REPLACEMENT OF BRAKE LIGHT SWITCH…
Read full complaint
I PURCHASED THE 2002 VOLKSWAGEN JETTA IN AUGUST OF 2006. THE FIRST SET OF REPAIRS WAS ON 3/2007 AT 64,332 MI CHECK ENGINE LIGHT MULITPLE MISFIRES: P0300, P0301, P0302, P0303, P0304 REPLACED IGNITION COILS COST: $200.11 SECOND REPAIR TOOK PLACE IN APRIL OF 2007 TOOK CAR IN FOR RECALL - REPLACEMENT OF BRAKE LIGHT SWITCH CHECK ENGLINE LIGHT WAS BACK ON - REPLACED TEMP. SENSOR COST: $199.33 CAR WAS JERKING INTO GEAR, DOWNSHIFTING HARD AND SLUGGISH. BROUGHT CAR INTO DEALSERHSIP IN APRIL 2008 WORN STRUT BRUSHINGS NEEDS REAR PADS NEEDS ROTORS CHECK ENGLINE LIGHT ON AGAIN NEEDS NEW COILS AGAIN SPARK PLUGS TEMP SENSOR AGAIN NEW T-STAT FANS NOT WORKING HOSES UNDER INTAKE BROKEN NEEDS NEW TRANSMISSION DIAGNOSIS COST: $149.21 ESTIMATED COST OF REPAIR: $6,500.00. *TR
NHTSA ODI #10228140
96,000 miles · May 1, 2008
Service Brakes, Hydraulic
I OWN A 2002 VW JETTA 1.8T. OVER THE WINTER MY ABS SYSTEM DID NOT FUNCTION PROPERLY AT ALL! SOMETIMES IT WOULD WORK AND SOMETIMES IT WOULDN'T. NOW THAT IT IS WARMER OUT IT DOES NOT WORK AT ALL! ABS LIGHT, TRACTION LIGHT, AND BLINKING BRAKE LIGHT NOW ILLUMINATE MY DASHBOARD. I HAVE READ THAT THIS IS A FAULTY ABS CONTROL UNIT WHIC…
Read full complaint
I OWN A 2002 VW JETTA 1.8T. OVER THE WINTER MY ABS SYSTEM DID NOT FUNCTION PROPERLY AT ALL! SOMETIMES IT WOULD WORK AND SOMETIMES IT WOULDN'T. NOW THAT IT IS WARMER OUT IT DOES NOT WORK AT ALL! ABS LIGHT, TRACTION LIGHT, AND BLINKING BRAKE LIGHT NOW ILLUMINATE MY DASHBOARD. I HAVE READ THAT THIS IS A FAULTY ABS CONTROL UNIT WHICH MANY PEOPLE HAVE HAD PROBLEMS WITH. I SIMPLY DON'T HAVE 1,500 DOLLARS TO FIX SOMETHING LIKE THIS BUT IT WOULD BE NICE TO BE IN CONTROL OF MY CAR ON SNOWY WISCONSIN ROADS. *TR
NHTSA ODI #10226350
120,039 miles · Oct 6, 2007
Service Brakes, Hydraulic
BRAKE BOOSTER IS FAILING AFTER USE IN TRAFFIC. THE BRAKE PEDAL SLOWLY SINKS AND WHEN LIGHTLY TAPPED, IT SLAMS TO THE FLOOR. WHEN THIS HAPPENS, A LOUD SUCTION CAN BE HEARD INSIDE THE CAR, AND THE BRAKES ARE APPLIED FULLY. THIS USUALLY HAPPENS AFTER BRAKES ARE USED SOME TIME, SAY IN A TRAFFIC JAM. THERE IS A SITE, TDICLUB.COM, …
Read full complaint
BRAKE BOOSTER IS FAILING AFTER USE IN TRAFFIC. THE BRAKE PEDAL SLOWLY SINKS AND WHEN LIGHTLY TAPPED, IT SLAMS TO THE FLOOR. WHEN THIS HAPPENS, A LOUD SUCTION CAN BE HEARD INSIDE THE CAR, AND THE BRAKES ARE APPLIED FULLY. THIS USUALLY HAPPENS AFTER BRAKES ARE USED SOME TIME, SAY IN A TRAFFIC JAM. THERE IS A SITE, TDICLUB.COM, WHICH HAS FORUMS WHERE MANY PEOPLE TALK ABOUT THIS PROBLEM ON THEIR 2002 MODEL YEAR VW JETTA. THE DANGER IS THAT THE BRAKES COME ON FULLY, WHICH STARTLES NOT ONLY THE DRIVER AND PASSENGER(S), BUT THE VEHICLES THAT ARE FOLLOWING. THIS IS AN INTERMITTENT PROBLEM (BRAKE BOOSTER FAILURE) BUT CAN BE REPLICATED IF THE BRAKES ARE USED HEAVILY. WHEN THE PROBLEM STARTS TO HAPPEN, IT WILL CONTINUE UNTIL THE BRAKES ARE NOT USED FOR QUITE SOME TIME. ONCE THIS STARTED HAPPENING TODAY, VIRTUALLY EVERY OTHER APPLICATION OF THE BRAKES CAUSED THE SYMPTOMS ABOVE. THIS OCCURRED ABOUT SEVEN TIMES THIS DAY. THIS HAS BEEN HAPPENING INTERMITTENTLY FOR A FEW YEARS. *TR
NHTSA ODI #10205146
79,000 miles · Aug 3, 2007
Service Brakes, Hydraulic
BRAKE POWER BOOSTER SUDDENLY FAILS IN STOP AND GO TRAFFIC AND VEHICLE BRAKES REALLY HARD AND THE BRAKE PEDAL FLOORS ON ITS OWN. THIS CAN CAUSE SERIOUS ACCIDENTS. *JB
NHTSA ODI #10198426
38,631 miles · Dec 9, 2006
Service Brakes, Hydraulic
ON OCTOBER 19, 2006, WHILE DRIVING MY 2002 VOLKSWAGEN JETTA, THE ABS WARNING LIGHTS CAME ON THE DASH. ACCORDING TO THE OWNER'S MANUAL THIS INDICATED A SERIOUS PROBLEM THAT COULD EFFECT THE BRAKES ON THE CAR. ON OCTOBER 26, 2006 I TOOK THE CAR TO FISCHER'S FOREIGN CARS, INC. FOR REPAIR. THEY TOLD ME THE ABS CONTROL MODULE WAS DEF…
Read full complaint
ON OCTOBER 19, 2006, WHILE DRIVING MY 2002 VOLKSWAGEN JETTA, THE ABS WARNING LIGHTS CAME ON THE DASH. ACCORDING TO THE OWNER'S MANUAL THIS INDICATED A SERIOUS PROBLEM THAT COULD EFFECT THE BRAKES ON THE CAR. ON OCTOBER 26, 2006 I TOOK THE CAR TO FISCHER'S FOREIGN CARS, INC. FOR REPAIR. THEY TOLD ME THE ABS CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE COST OF THE REPAIR WAS $702.93 AND THEY SAID THERE WAS A RECALL FOR THIS PROBLEM (THEY GAVE ME A COPY OF THE RECALL LETTER FROM VOLKSWAGEN OF AMERICA INC(VOA) DATED MARCH 12, 2002) AND THAT I SHOULD FILE A CLAIM WITH VOA FOR REIMBURSEMENT. I PURCHASED THE CAR NEW ON FEBRUARY 16, 2002, AND NEVER RECEIVED A RECALL NOTICE FOR THIS PROBLEM. ON NOVEMBER 4, 2006, I SENT A REGISTERED LETTER TO VOA REQUESTING REIMBURSEMENT FOR THE REPAIR COSTS. I ALSO ENCLOSED COPIES OF THE RECALL LETTER AND THE REPAIR BILL. ABOUT NOVEMBER 11, 2006, I RECEIVED A TELEPHONE CALL FROM A WOMAN AT VOA AND SHE SAID THAT THE RECALL LETTER DID NOT COVER MY CAR AND THAT BECAUSE THE FACTORY WARRANTY HAD EXPIRED IN FEBRUARY 2006, THAT VOA WOULD NOT HONOR MY REQUEST FOR REIMBURSEMENT. SHE SAID THE DECISION WAS FINAL. I CAN'T UNDERSTAND WHY THE RECALL WOULD NOT COVER MY CAR WHEN THE PROBLEM INDICATED IN THE RECALL LETTER IS THE SAME AS MINE. IT SEEMS THAT THE RECALL SHOULD HAVE INCLUDED MORE CARS WHEN IT IS OBVIOUS FROM MY DEFECTIVE ABS MODULE THAT THE PROBLEM WAS NOT CORRECTED. AT THE TIME OF THE FAILURE, MY CAR HAD 38,631 MILES ON IT. I AM CONCERNED THAT THERE ARE OTHER CARS, LIKE MINE, THAT SHOULD HAVE WHEN COVERED BY THE RECALL OR A SUBSEQUENT RECALL TO CORRECT THE DEFECTIVE ABS MODULE. I BELIEVE SOMEONE SHOULD REVISIT THIS ISSUE TO DETERMINE IF THE RECALL SHOULD BE EXPANDED TO INCLUDE MORE CARS. *JB
NHTSA ODI #10175666
75,221 miles · Nov 13, 2006
Service Brakes, Hydraulic
THIS IS A REPORT OF THE FAILURE OF THE BOOSTER BRAKE ON A 2002 VW TDI JETTA. THE SYMPTOMS ARE THAT WHILE APPLYING THE BRAKES, THE PEDAL WILL SUDDENLY BE SUCKED TO THE FLOOR RESULTING IN A SUDDEN STOP. THE DANGER CREATED IS OF BEING REAR-ENDED AND IS A POTENTIAL LIFE THREATENING ISSUE. THE PROBLEM IS DIFFICULT TO TROUBLE SHOOT…
Read full complaint
THIS IS A REPORT OF THE FAILURE OF THE BOOSTER BRAKE ON A 2002 VW TDI JETTA. THE SYMPTOMS ARE THAT WHILE APPLYING THE BRAKES, THE PEDAL WILL SUDDENLY BE SUCKED TO THE FLOOR RESULTING IN A SUDDEN STOP. THE DANGER CREATED IS OF BEING REAR-ENDED AND IS A POTENTIAL LIFE THREATENING ISSUE. THE PROBLEM IS DIFFICULT TO TROUBLE SHOOT BECAUSE IT IS INTERMITTENT. ONCE THE PEDAL IS SUCKED TO THE FLOOR IT COULD BE DAYS BEFORE IT HAPPENS AGAIN. I SEE THAT AT LEAST ELEVEN OTHER 2002 JETTA OWNERS HAVE REPORTED THE SUDDEN BRAKING PROBLEM TO NHTS, I.E. ODI ID #10103196, 10129643, 10137579, 10100576, 10058106, 10027194, 8011122, 10139134, 10086927, 8023749, 769651. IN EACH CASE, WHERE A SOLUTION IS MENTIONED, THE SOLUTION INVOLVED THE BOOSTER BRAKE. IN MY CASE THE VW DEALER, AFTER TRYING TWICE, DID NOT FIND THE SOLUTION. IT WAS AFTER INTERACTING WITH THE FOLKS AT THE VW TDI CLUB WHO EXPERIENCED THE SAME PROBLEM THAT I LEARNED THEIR SOLUTION WHICH WAS TO REPLACE THE BOOSTER BRAKE. THE VW DEALER AGREED TO REPLACE MY BOOSTER BRAKE ONLY IF I AGREED TO HOLD NO ONE OTHER THAN MYSELF RESPONSIBLE SHOULD THE REPLACEMENT NOT SOLVE THE PROBLEM AND IF THEY COULD REPLACE THE MASTER CYLINDER IN ADDITION TO THE BOOSTER BRAKE. THE REPAIR MADE OVER A YEAR AGO ON 25 OCTOBER 2005, SOLVED MY SUDDEN BRAKING PROBLEM. I SEE THAT OTHERS ON THE TDI WEB SITE ARE STILL HAVING BOOSTER BRAKE PROBLEMS AND THAT THEY HAVE BEEN UNSUCCESSFUL IN GETTING VOLKSWAGONS ATTENTION. THE HELP OF THE NHTS IS NEEDED TO RAISE THE CORPORATE CONSCIOUSNESS OF THE RIGHT FOLKS IN VW ABOUT THE BOOSTER BRAKE PROBLEM. AT A MINIMUM VW SHOULD ALERT ITS SERVICE REPAIR FOLKS TO THE SYMPTOMS AND THE SOLUTION. A RECALL TO CORRECT THE FAILED BOOSTER BRAKES IS THE DESIRED REDRESS. I STILL HAVE THE FAILED BOOSTER BRAKE AND MASTER CYLINDER AND WILL BE GLAD TO PROVIDE ALL THE PARTS TO THE NHTS FOLKS. *NM
NHTSA ODI #10173410
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration