NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
101 reportsClear category filter160,000 miles · Dec 19, 2016
SeatsFireInjury
TL* THE CONTACT OWNS A 2002 VOLKWAGEN JETTA. WHILE OPERATING THE VEHICLE WITH THE FRONT SEAT WARMERS ACTIVATED, THE FRONT PASSENGER WAS BURNED WHEN THE SEAT WARMER MALFUNCTIONED. MEDICAL ATTENTION WAS NOT NEEDED. THE FAILURE BURNED A HOLE THROUGH THE FRONT PASSENGER SEAT. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. T…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKWAGEN JETTA. WHILE OPERATING THE VEHICLE WITH THE FRONT SEAT WARMERS ACTIVATED, THE FRONT PASSENGER WAS BURNED WHEN THE SEAT WARMER MALFUNCTIONED. MEDICAL ATTENTION WAS NOT NEEDED. THE FAILURE BURNED A HOLE THROUGH THE FRONT PASSENGER SEAT. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10936295
230,000 miles · Oct 7, 2015
Air BagsSeats
WHILE DRIVING OUR JETTA AT APPROXIMATELY 30 MPH THE DRIVERS SIDE CURTAIN AIRBAG AND SIDE SEAT AIRBAG SPONTANEOUSLY DEPLOYED. THERE WAS NO IMPACT. THERE WAS NO POTHOLE. IT WAS THE ONLY CAR ON THE ROAD. GOING STRAIGHT.
NHTSA ODI #10780504
217,000 miles · Mar 16, 2015
SeatsFire
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 60 MPH, SMOKE STARTED TO EMIT FROM THE FRONT PASSENGER SEAT. THE FRONT PASSENGER WAS NOT INJURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 217,000.
NHTSA ODI #10694574
110,000 miles · Apr 1, 2014
Seats
BOTH FRONT SEAT HEATERS ON ANY SETTING ARC AND HAVE BURNED MULTIPLE HOLES ON THE OUTER LOWER SEAT UPHOLSTERY. *TR
NHTSA ODI #10576291
120,000 miles · Nov 11, 2013
SeatsInjury
WHILE DRIVING WITH SEAT HEATER ON SEAT BURNED THRU FOAM AND SEAT COVER ALSO BURNED PANTS LEG AND WIFE'S FINGER TRYING TO PUT OUT THE EMBERS. *TR
NHTSA ODI #10551770
Mileage unknown · Jan 22, 2013
Seats
TURNED THE DRIVERS SIDE HEATED SEAT WARMER ON TO 2. RANGE BEING 0-5. I SMELLED SMOKE AND TURNED IT OFF AFTER ONLY 10-15MIN OF BEING ON. I NOTICED WHEN I GOT OUT OF THE CAR, THAT I HAD A HUGE QUARTER SIZE HOLE IN MY SEAT AND MY DOWN COAT WAS BURNED THROUGH IN 2 LARGE SPOTS. THIS IS UNSAFE. IT COULD HAVE BEEN A HUGE FIRE IF I HAD …
Read full complaint
TURNED THE DRIVERS SIDE HEATED SEAT WARMER ON TO 2. RANGE BEING 0-5. I SMELLED SMOKE AND TURNED IT OFF AFTER ONLY 10-15MIN OF BEING ON. I NOTICED WHEN I GOT OUT OF THE CAR, THAT I HAD A HUGE QUARTER SIZE HOLE IN MY SEAT AND MY DOWN COAT WAS BURNED THROUGH IN 2 LARGE SPOTS. THIS IS UNSAFE. IT COULD HAVE BEEN A HUGE FIRE IF I HAD NOT TURNED OFF THE WARMER AS SOON AS I SMELLED SOMETHING BURNING. *TR
NHTSA ODI #10493823
70,000 miles · Dec 19, 2012
SeatsFireInjury
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE DRIVER'S SIDE HEATED SEAT OVERHEATED AND BURNED THROUGH THE SEAT, CAUSING BURNS TO THE CONTACT'S LEGS. THE CONTACT STATED THAT THE FAILURE HAD BEEN EXPERIENCED BEFORE, BUT WAS NEVER SO SEVER THAT IT CAUSED INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER.…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE DRIVER'S SIDE HEATED SEAT OVERHEATED AND BURNED THROUGH THE SEAT, CAUSING BURNS TO THE CONTACT'S LEGS. THE CONTACT STATED THAT THE FAILURE HAD BEEN EXPERIENCED BEFORE, BUT WAS NEVER SO SEVER THAT IT CAUSED INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 70,000.
NHTSA ODI #10489223
110,000 miles · Mar 29, 2012
SeatsFire
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HEATED SEATS BEGAN TO SPARK AND BURNED A WHOLE IN THE SEAT. THE SEATS WERE REPAIRED UNDER A PREVIOUS MANUFACTURER'S RECALL, BUT THE FAILURE RECURRED. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT THE CONTACT WAS DENIED ANY ASSISTANCE…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HEATED SEATS BEGAN TO SPARK AND BURNED A WHOLE IN THE SEAT. THE SEATS WERE REPAIRED UNDER A PREVIOUS MANUFACTURER'S RECALL, BUT THE FAILURE RECURRED. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT THE CONTACT WAS DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 145,000.
NHTSA ODI #10453451
125,000 miles · Feb 21, 2012
SeatsFire
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE HEATED SEAT WARMER BURNED THROUGH THE SEAT AND THE PANTS OF THE CONTACT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE HEATED SEAT WARMER BURNED THROUGH THE SEAT AND THE PANTS OF THE CONTACT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000.
NHTSA ODI #10448848
143,050 miles · Dec 17, 2011
Electrical SystemSeatsFire
WHILE DRIVING HOME AT NIGHT, MY SON AND I SMELLED SMOKE. WE EXITED THE VEHICLE, CHECKED UNDER THE HOOD, BUT FOUND NOTHING. WE CONTINUED HOME AND PARKED IN THE GARAGE. STILL SMELLING SMOKE, WE RE-INSPECTED THE VEHICLE, BUT WERE UNABLE TO DETERMINE AN ORIGIN OR ANY VISIBLE EVIDENCE. BOTH SEAT HEATERS WERE ON DURING THE DRIVE H…
Read full complaint
WHILE DRIVING HOME AT NIGHT, MY SON AND I SMELLED SMOKE. WE EXITED THE VEHICLE, CHECKED UNDER THE HOOD, BUT FOUND NOTHING. WE CONTINUED HOME AND PARKED IN THE GARAGE. STILL SMELLING SMOKE, WE RE-INSPECTED THE VEHICLE, BUT WERE UNABLE TO DETERMINE AN ORIGIN OR ANY VISIBLE EVIDENCE. BOTH SEAT HEATERS WERE ON DURING THE DRIVE HOME, BUT THE SEATS SHOWED NO VISUAL SIGNS OF DAMAGE AFTER PARKING. NEXT MORNING WE OPENED THE VEHICLE TO DISCOVER THE CABIN WAS FILLED WITH SMOKE WITH AN APPROXIMATE 1?HOLE BURNED UP THRU THE PASSENGER SEAT ON THE LOWER RIGHT BOLSTER. APPARENTLY THE SEAT HEATER INITIATED A THERMAL EVENT WHICH ERUPTED IN A SEAT FIRE AFTER WE TURNED OFF THE IGNITION AND PARKED THE CAR IN THE GARAGE. FORTUNATELY, THE FIRE DID NOT ENGULF THE VEHICLE OR IT COULD HAVE CAUGHT OUR HOME ON FIRE, RESULTING IN POSSIBLE INJURY OR DEATH TO MY FAMILY. I BELIEVE WE DODGED A BULLET BECAUSE THE SEAT FIRE DID NOT SUSTAIN ITSELF AND ENGULF THE VEHICLE. VW HAS AGREED TO REPAIR THE BURNED SEAT AT THEIR EXPENSE AND MAKE A MITIGATION REPAIR. HOWEVER, VW HAS DECLINED MY REQUEST TO COVER ANY SIMILAR MITIGATION REPAIR TO THE OTHER SEAT. IN OCTOBER 2004, THE NHTSA ODI CONCLUDED THAT ?DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE? BUT ?SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.? THE ODI STATED THE INVESTIGATION DID NOT CONCLUDE THAT A SAFETY-RELATED DEFECT DOES NOT EXIST AND THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (EA04010) EVIDENCE AND REPORTS INDICATE THAT SEAT HEATER CAUSED THERMAL EVENTS IN BOTH DRIVER AND PASSENGER SEATS IN THE VW JETTA HAVE BEEN AN ISSUE FOR NEARLY 10 YEARS NOW. NEAR MISSES CONTINUE TO OCCUR. I BELIEVE THAT A SEAT FIRE IS A SIGNIFICANT SAFETY CONCERN. I WOULD ENCOURAGE THE NHTSA TO RE-EXAMINE THE CIRCUMSTANCES TO DETERMINE IF FURTHER ACTION IS WARRANTED. *TR
NHTSA ODI #10440242
Official recalls
5Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration