NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
148 reportsClear category filterMileage unknown · Nov 6, 2006
Electrical System
ON 30 OCTOBER 2006, I HAD TO HAVE MY 2002 VOLKSWAGEN THAT WAS PURCHASED BRAND NEW TOWED INTO THE DEALERSHIP. MY CAR WOULDN'T START. THOUGHT IT WAS THE BATTERY, REPLACED THE BATTERY AND IT STILL WOULDN'T START. I HAD TO HAVE THE POWER WIRE TO THE STARTER REPLACED. I'M BEING TOLD BY THE DEALERSHIP THAT IT IS VERY UNCOMMON FOR …
Read full complaint
ON 30 OCTOBER 2006, I HAD TO HAVE MY 2002 VOLKSWAGEN THAT WAS PURCHASED BRAND NEW TOWED INTO THE DEALERSHIP. MY CAR WOULDN'T START. THOUGHT IT WAS THE BATTERY, REPLACED THE BATTERY AND IT STILL WOULDN'T START. I HAD TO HAVE THE POWER WIRE TO THE STARTER REPLACED. I'M BEING TOLD BY THE DEALERSHIP THAT IT IS VERY UNCOMMON FOR THIS WIRE TO BE REPLACED. I JUST WOULD LIKE TO KNOW FROM VOLKSWAGEN HAVE THEY RECEIVED IN OTHER COMPLAINTS. I THINK THIS IS SOMETHING OF A MANUFACTURE DEFECT. *JB
NHTSA ODI #10172684
15,000 miles · Oct 30, 2006
Electrical System
MY GLOWPLUG RELAY FAILED AND MELTED CONNECTOR AND KILLED BATTERY. HTTP://WWW.PUTFILE.COM/PIC.PHP?IMG=3822124 HTTP://WWW.PUTFILE.COM/PIC.PHP?IMG=3822125 HTTP://WWW.PUTFILE.COM/PIC.PHP?IMG=3822126 ABOVE PICS OF FAILED REALY. *JB
NHTSA ODI #10172118
84,000 miles · Oct 12, 2006
Electrical SystemExterior LightingVehicle Speed Control
DT*: THE CONTACT STATED WHILE DRIVING 65 MPH, THE VEHICLE WAS PULLED OVER BY POLICE AND INFORMED THE TAIL LIGHTS WERE NOT ILLUMINATED. THE 3 BRAKE LIGHTS FAILED TO ILLUMINATE IN RAPID SUCCESSION AND REQUIRED THAT THE BULBS NEEDED TO BE REPLACED IN AUGUST. THE CRUISE CONTROL FAILED INTERMITTENTLY, AS WELL AS, THE LIGHTING IN TH…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 65 MPH, THE VEHICLE WAS PULLED OVER BY POLICE AND INFORMED THE TAIL LIGHTS WERE NOT ILLUMINATED. THE 3 BRAKE LIGHTS FAILED TO ILLUMINATE IN RAPID SUCCESSION AND REQUIRED THAT THE BULBS NEEDED TO BE REPLACED IN AUGUST. THE CRUISE CONTROL FAILED INTERMITTENTLY, AS WELL AS, THE LIGHTING IN THE INSTRUMENT PANEL BY THE HEAT SWITCH. THE MANUFACTURER WAS NOTIFIED, BUT INFORMED THE CONTACT THE VEHICLE WAS NOT INCLUDED IN RECALL # 06V183000 FOR THE EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH DUE TO THE VIN, ALTHOUGH THE PROBLEMS WERE SIMILAR.
NHTSA ODI #10170672
92,000 miles · Oct 5, 2006
Electrical SystemEngine And Engine CoolingExterior Lighting
WAY TO MANY TO LIST HERE. I HAVE HAD PROBLEMS FROM THE START. MORE THAN $7000 WORTH OF REPAIR (PLUS MORE THAT WAS COVERED BY WARR) THE FINAL ITEM THAT CAUSED ME TO SAY I WOULD NEVER CONSIDER ANOTHER VW PRODUCT WAS THE ENGINE DAMAGE CAUSED BY A TIMING BELT FAILURE. ALL SERVICES WERE PERFORMED AT THE DEALERSHIP. THE USERS MANUAL …
Read full complaint
WAY TO MANY TO LIST HERE. I HAVE HAD PROBLEMS FROM THE START. MORE THAN $7000 WORTH OF REPAIR (PLUS MORE THAT WAS COVERED BY WARR) THE FINAL ITEM THAT CAUSED ME TO SAY I WOULD NEVER CONSIDER ANOTHER VW PRODUCT WAS THE ENGINE DAMAGE CAUSED BY A TIMING BELT FAILURE. ALL SERVICES WERE PERFORMED AT THE DEALERSHIP. THE USERS MANUAL STATES INSPECTION OF THE BELT AT SERVICES (THAT I PAID FOR) AND REPLACEMENT AT 120,000 MILES. I ONLY HAD 92,000 MILES. IT WILL COST $5,000 TO REPAIR THE ENGINE. IT IS NOT COST EFFECTIVE TO REPAIR THIS CAR. IT WAS A GREAT CAR TO DRIVE BUT QUALITY CONTROL IS POOR AT BEST. *NM
NHTSA ODI #10170044
Mileage unknown · Sep 8, 2006
Electrical SystemEngine And Engine Cooling
I HAVE HAD SEVERAL PROBLEMS WITH MY MIL LIGHT SINCE MY 5 YR/50,000 MILE WARRANTY EXPIRED-IN FACT, I HAVE LOST COUNT AS TO HOW MANY TIMES I'VE HAD TO TAKE MY CAR IN (THE NUMBER OF FAILURES LISTED BELOW IS JUST AN ESTIMATE). THE FIRST TIME THIS LIGHT CAME ON, THE CAR HAD 52 OR 54 MILES ON IT. IT WAS ONLY A FEW DAYS OLD. APPAREN…
Read full complaint
I HAVE HAD SEVERAL PROBLEMS WITH MY MIL LIGHT SINCE MY 5 YR/50,000 MILE WARRANTY EXPIRED-IN FACT, I HAVE LOST COUNT AS TO HOW MANY TIMES I'VE HAD TO TAKE MY CAR IN (THE NUMBER OF FAILURES LISTED BELOW IS JUST AN ESTIMATE). THE FIRST TIME THIS LIGHT CAME ON, THE CAR HAD 52 OR 54 MILES ON IT. IT WAS ONLY A FEW DAYS OLD. APPARENTLY SOMETHING HAD CRACKED. IN MARCH OF THIS YEAR, THREE OF THE CABLES BROKE, THEN NOT TWO WEEKS LATER THE OTHER THREE BROKE. THE PROBLEMS JUST KEPT ADDING UP. I HAVE TRIED TO BE PATIENT WITH THIS DEALERSHIP, BUT SIMPLY CANNOT UNDERSTAND WHY ON AVERAGE, I END UP BACK AT THE DEALERSHIP, GETTING MY CAR SERVICED ON AVERAGE, TWO WEEKS AFTER THE CAR'S INITIAL APPOINTMENT. THE LAST TIME I WENT IN, I SPOKE WITH THE MANAGER. FIRST, HE DISPARAGINGLY ASKED ME IF I WAS MAKING SURE TO FILL THE GAS TANK WITH PREMIUM GAS, AS IS WRITTEN ON THE GAS FLAP. HE THEN PROCEEDED TO ASK IF I WAS TIGHTENING THE GAS CAP. HE REASSURED ME THAT I SHOULD NOT HAVE FURTHER PROBLEMS WITH THIS SPECIFIC PART, BECAUSE ALL THE PARTS PERTAINING TO THIS SPECIFIC LIGHT HAVE BEEN REPLACED. LO AND BEHOLD, TWO DAYS AGO, MY MIL LIGHT WENT ON. ON AVERAGE, EACH TIME I VISIT THIS PARTICULAR DEALERSHIP SERVICE DEPARTMENT, I END UP PAYING $350-600 DOLLARS. SOMEHOW, THAT DOES NOT SEEM RIGHT. I HAVE BEEN FOLLOWING THE SERVICE DEPARTMENT'S INSTRUCTIONS, AND TO MY DISMAY, THIS LONG-STANDING, EXTREMELY EXPENSIVE PROBLEM HAS NOT BEEN RESOLVED. *JB
NHTSA ODI #10167716
58,975 miles · Sep 8, 2006
Electrical SystemExterior Lighting
THE EPC LIGHT CAME ON WHILE I WAS DRIVING MY VEHICLE. I TURNED OFF MY CAR WHEN I ARRIVED AT MY DESTINATION. I READ THE MANUAL, AND IT WAS NOT HELPFUL. IT JUST STATED THAT I SHOULD TAKE THE CAR TO A DEALER OR QUALIFIED SPECIALIST AS SOON AS POSSIBLE (NOTE: THIS IS WHAT THE BOOKLET SAYS FOR THE MAJORITY OF ITEMS IN THE OWNERS' …
Read full complaint
THE EPC LIGHT CAME ON WHILE I WAS DRIVING MY VEHICLE. I TURNED OFF MY CAR WHEN I ARRIVED AT MY DESTINATION. I READ THE MANUAL, AND IT WAS NOT HELPFUL. IT JUST STATED THAT I SHOULD TAKE THE CAR TO A DEALER OR QUALIFIED SPECIALIST AS SOON AS POSSIBLE (NOTE: THIS IS WHAT THE BOOKLET SAYS FOR THE MAJORITY OF ITEMS IN THE OWNERS' MANUAL). UPON RETURNING TO MY VEHICLE, I STARTED MY CAR ONCE MORE. MY ENGINE TURNED OVER, BUT THE CAR WAS UNABLE TO SHIFT FROM PARK INTO ANY OTHER GEAR. THE VEHICLE HAD TO BE TOWED TO AN AUTO SHOP. UPON FURTHER INSPECTION, THE AUTO SHOP INFORMED ME THAT MY CAR HAD A "FEATURE" THAT DISABLED THE CAR FROM SHIFTING GEARS DUE TO A TAIL-LIGHT FUSE THAT BLEW OUT. IT IS BELIEVED THAT DISABLING THE VEHICLE SERVES THE PURPOSE OF MAINTAINING SAFETY ON THE STREETS- A VEHICLE IN MOTION WITHOUT TAILLIGHTS IS APPARENTLY MORE DANGEROUS THAN A DRIVER STRANDED ON THE ROAD BECAUSE THEIR CAR HAS STRANDED THEM. LUCKILY, I WAS FORTUNATE ENOUGH NOT TO BE IN A BAD SITUATION. SO FINALLY, THE CAR WAS FIXED, OF COURSE AFTER I PAID YET ANOTHER HEFTY BILL FOR MY CAR. *JB
NHTSA ODI #10167711
69,900 miles · Jul 18, 2006
Electrical SystemEngine And Engine CoolingVehicle Speed Control
WHILE DRIVING IN THE AFTERNOON, MY VEHICLE SUDDENLY LOST POWER AND ACCELERATION CAPABILITY WITH THE "CHECK ENGINE" LIGHT COMING ON AND BLINKING. I TOOK IT TO THE DEALER IMMEDIATELY. I AM INFORMED MY 2002 VW JETTA 1.8T HAS "3 FAULTY COILS." THE FAILURE WAS SUDDEN AND WITHOUT WARNING. I MAINTAIN MY CAR ACCORDING TO VW SPECS…
Read full complaint
WHILE DRIVING IN THE AFTERNOON, MY VEHICLE SUDDENLY LOST POWER AND ACCELERATION CAPABILITY WITH THE "CHECK ENGINE" LIGHT COMING ON AND BLINKING. I TOOK IT TO THE DEALER IMMEDIATELY. I AM INFORMED MY 2002 VW JETTA 1.8T HAS "3 FAULTY COILS." THE FAILURE WAS SUDDEN AND WITHOUT WARNING. I MAINTAIN MY CAR ACCORDING TO VW SPECS. IN 02/2003 VW ACKNOWLEDGED A PROBLEM WITH THIS IN OVER 530,000 2001 TO EARLY 2003 VEHICLES. I FEEL THE FAILURE WAS PREMATURE (AS TO WHAT COULD BE TYPICALLY EXPECTED OF AN ENGINE/VEHICLE FOR RELIABILITY), AND A DANGER. OBVIOUSLY THE FACT THAT IT HAS REMANIFESTED IN SUCH A SHORT PERIOD OF TIME SHOWS THAT IT WAS NOT PROPERLY ADDRESSED WITH THE ORIGINAL FIX ONLY 2 YEARS AGO. MY VEHICLE WAS UNABLE TO ADEQUATELY MAINTAIN ITSELF WITHIN THE FLOW OF TRAFFIC. I WAS LUCKY TO GET TO THE 'SLOW LANE' WITHOUT INCIDENT. VW DISCLAIMS ANY RESPONSIBILITY FOR DEFECT OR OTHERWISE AND SAYS THAT BECAUSE THE VEHICLE IS OUT OF ITS WARRANTY PERIOD I AM RESPONSIBLE ($454.00). I WILL PAY THIS, BUT HOW CAN I DRIVE KNOWING THAT THESE COILS COULD STOP ALL OR ANY ONE CYLINDER FROM CORRECTLY FIRING? THIS COULD KILL ME AND THE MANUFACTURER DOES NOT CARE.. AS THEY QUITE BLUNTLY STATED. *NM
NHTSA ODI #10162795
61,000 miles · Jun 29, 2006
Electrical SystemExterior Lighting
7TH TIME THIS HAS HAPPENED. CAR IS IMMOBILIZED BY A FAULTY BRAKE LIGHT SWITCH - HAS HAPPENED EVERY SIX MONTHS SINCE WE PURCHASED THE CAR. *JB
NHTSA ODI #10161081
Mileage unknown · May 24, 2006
Electrical System
TURN SIGNAL STALK IS DEFECTIVE AND CAUSING A FULL ELECTRICAL LOOP CAUSING A FAST CLICKS AS IF THE TURN SIGNAL FLASHER WAS ON, BUT IT'S NOT. AT TIMES IT HAS CAUSED THE FLASHER LIGHTS TO COME ON WHEN I HAD NOT EVEN TOUCHED THE TURN SIGNAL STALK. *JB
NHTSA ODI #10158235
44,000 miles · Apr 24, 2006
Electrical System
THE CAR WOULD NOT START, MADE A CLICKING SOUND WITH EACH ATTEMPT, AND THE RADIO AND AUTOMATIC WINDOWS WOULD NOT TURN ON/RESPOND TO CONTROL. THE CAR HAD TO BE TOWED AND THE STARTER WAS FOUND TO BE THE PROBLEM ON A RELATIVELY NEW CAR (3YRS. OLD), 40000K. HAVE SUBSEQUENTLY READ ANECDOTAL COMPLAINTS THAT VW'S HAVE STARTER PROBLEMS…
Read full complaint
THE CAR WOULD NOT START, MADE A CLICKING SOUND WITH EACH ATTEMPT, AND THE RADIO AND AUTOMATIC WINDOWS WOULD NOT TURN ON/RESPOND TO CONTROL. THE CAR HAD TO BE TOWED AND THE STARTER WAS FOUND TO BE THE PROBLEM ON A RELATIVELY NEW CAR (3YRS. OLD), 40000K. HAVE SUBSEQUENTLY READ ANECDOTAL COMPLAINTS THAT VW'S HAVE STARTER PROBLEMS. *JB
NHTSA ODI #10155952
Official recalls
5Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration