NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
148 reportsClear category filter150,000 miles · Jun 1, 2011
Electrical System
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHEN TRYING TO USE THE TURN SIGNAL THEY WOULD NOT TURN ON; NOR DOES THE HAZARD WARNING LIGHTS FUNCTION PROPERLY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED HER THAT THERE WAS AN ELECTRICAL FAILURE BECAUSE NO FUSES HAD BLOWN OUT. THE VEHICL…
Read full complaint
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHEN TRYING TO USE THE TURN SIGNAL THEY WOULD NOT TURN ON; NOR DOES THE HAZARD WARNING LIGHTS FUNCTION PROPERLY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED HER THAT THERE WAS AN ELECTRICAL FAILURE BECAUSE NO FUSES HAD BLOWN OUT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILES WERE APPROXIMATELY 150,000.
NHTSA ODI #10403965
79,399 miles · Feb 11, 2010
Electrical System
VEHICLE SHUT DOWN WHILE DRIVING TWICE, COULD RESULT IN CAR BEING DISABLED WHILE DRIVING AT ANY SPEED ANY WHERE BECOMING A VERY DANGEROUS SITUATION FOR THE DRIVER AND AN OBSTACLE ON THE ROAD FOR OTHER DRIVERS TO TRY TO AVOID. VOLKSWAGEN DEALERSHIP ISOLATED THIS TO A FAULTY HARNESS CONNECTING THE ALTERNATOR TOTHE FUSE LOCATED O…
Read full complaint
VEHICLE SHUT DOWN WHILE DRIVING TWICE, COULD RESULT IN CAR BEING DISABLED WHILE DRIVING AT ANY SPEED ANY WHERE BECOMING A VERY DANGEROUS SITUATION FOR THE DRIVER AND AN OBSTACLE ON THE ROAD FOR OTHER DRIVERS TO TRY TO AVOID. VOLKSWAGEN DEALERSHIP ISOLATED THIS TO A FAULTY HARNESS CONNECTING THE ALTERNATOR TOTHE FUSE LOCATED ON TOP OF THE BATTERY. THE HARNESS AND THE FUSE BOX HAD TO BE REPLACED. THE DEALERSHIP SAID THIS PROBLEM IS ONLY COMMON TO VW BEATLES AND VW JETTA, BECAUSE THEY SAID THE CAR WAS 2002 IT WAS OUT OF WARRANTY NOT COVERED. I WAS MORE CONCERNED OF THE SAFETY OF LIFE AND PROPERTY THIS PROBLEM WOULD CAUSE. I FILED A COMPLAINT WITH THE ATTORNEY GENERAL JOHN KROGERS OFFICE IN OREGON, THEY SENT ME A LETTER STATING THEY HAD FORWARDED THIS COMPLAINT TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMIN IN WASHINGTON DC . I TRIED TO CONTACT THEM BY PHONE, THEY ASKED IF I HAD A CONFIRMATION # . I HAVEN'T AS OF YET RECEIVED A LETTER OR PHONE CALL. *TR
NHTSA ODI #10308823
52,000 miles · Nov 18, 2009
Electrical SystemInjury
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 55 MPH THE VEHICLE LOST POWER AND DECREASED SPEED TO 10 MPH. HE WAS ABLE TO AVOID A CRASH AND DRIVE ONTO THE EMERGENCY LANE. HE WAS ALSO ABLE TO DRIVE THE VEHICLE TO HIS RESIDENCE. THE DEALER STATED THAT THE IGNITION COIL CAUSED THE VEHICLE TO LOSE POWER. THE MANUFACTURE…
Read full complaint
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 55 MPH THE VEHICLE LOST POWER AND DECREASED SPEED TO 10 MPH. HE WAS ABLE TO AVOID A CRASH AND DRIVE ONTO THE EMERGENCY LANE. HE WAS ALSO ABLE TO DRIVE THE VEHICLE TO HIS RESIDENCE. THE DEALER STATED THAT THE IGNITION COIL CAUSED THE VEHICLE TO LOSE POWER. THE MANUFACTURER STATED THERE WERE NO RELATED RECALLS. THE FAILURE AND THE CURRENT MILEAGES WERE 52,000. UPDATED 03/01/10 *BF THE CONSUMERS DAUGHTER HIT THE FRONT SEAT AND SUSTAINED A BLODDY NOSE. UPDATED 09/16/10
NHTSA ODI #10292699
Mileage unknown · Nov 14, 2009
Electrical System
BATTERY CONTINUES TO DRAIN OVER NIGHT. CHANGING BATTERIES DID NOT SOLVE THE PROBLEM. ONLINE FORUM POINTS TO RADIO DRAINING THE BATTERY. PULLING FUSE AND RESETTING RADIO TENDS TO STOP THE PROCESS, BUT THEN IT RETURNS AFTER A COUPLE OF DAYS. *TR
NHTSA ODI #10292133
82,928 miles · Sep 9, 2009
Electrical System
1. 2002 VW JETTA WAGON ELECTRICAL SYSTEM FAILURE ON EXPRESSWAY CAUSED VEHICLE TO STOP & UNABLE TO START 9/6/09. VEHICLE TOWED TO DEALER. 2. VW DEALER FAILURE DESCRIPTION, WIRE HARNESS CORROSION CAUSED RESTRICTION IN POWER FLOW IN LINE WHICH CAUSED ALTERNATOR TO OVERWORK AND OVERHEAT WIRE HARNESS AND FUSE PANEL. THIS EXTENSIVE …
Read full complaint
1. 2002 VW JETTA WAGON ELECTRICAL SYSTEM FAILURE ON EXPRESSWAY CAUSED VEHICLE TO STOP & UNABLE TO START 9/6/09. VEHICLE TOWED TO DEALER. 2. VW DEALER FAILURE DESCRIPTION, WIRE HARNESS CORROSION CAUSED RESTRICTION IN POWER FLOW IN LINE WHICH CAUSED ALTERNATOR TO OVERWORK AND OVERHEAT WIRE HARNESS AND FUSE PANEL. THIS EXTENSIVE ENOUGH TO CAUSE MELTING OF BOTH WIRE HARNESS AND FUSE PANEL OVER TOP OF BATTERY. 3. VW DEALER REPAIR AND REPLACE WIRE HARNESS AND FUSE BODY. 4. VW CUSTOMER CARE TOOK INFORMATION ON MY COMPLAINT ABOUT DEFECT AND POTENTIAL SAFETY ISSUE BUT WOULD DO NOTHING REFERRING ME BACK TO THE DEALER. MY QUESTION WAS WHY DID VW HAVE SUCH A DEFECT WHERE THERE WAS NO FUSIBLE LINK THAT WOULD FAIL FIRST PREVENTING THE EXTENSIVE DAMAGE THAT OCCURRED. *TR
NHTSA ODI #10283460
70,000 miles · Apr 18, 2009
Electrical SystemFire
THE BOTTOM SEAT HEATER ON MY 2002 VW JETTA EITHER DOESN'T WORK AT ALL OR IF IT TURNS ON, IT OVERHEATS THE EXTREME RIGHT SIDE OF THE SEAT. A SMALL HOLE IS BURNED IN THE UPHOLSTERY, AND THE FOAM UNDERNEATH IS MELTED, DEFORMING THE APPEARANCE OF FABRIC ABOVE. THIS COULD RESULT IN A BURN TO THE SKIN ON THE RIGHT SIDE OF THE LEG I…
Read full complaint
THE BOTTOM SEAT HEATER ON MY 2002 VW JETTA EITHER DOESN'T WORK AT ALL OR IF IT TURNS ON, IT OVERHEATS THE EXTREME RIGHT SIDE OF THE SEAT. A SMALL HOLE IS BURNED IN THE UPHOLSTERY, AND THE FOAM UNDERNEATH IS MELTED, DEFORMING THE APPEARANCE OF FABRIC ABOVE. THIS COULD RESULT IN A BURN TO THE SKIN ON THE RIGHT SIDE OF THE LEG IF IT GOES UNDETECTED. I SEE THIS AS A HUGE SAFETY ISSUE. *TR
NHTSA ODI #10265959
128,345 miles · Jan 2, 2009
Electrical System
WHILE DRIVING THE VEHICLE, SMOKE AND A BURNING SMELL STARTED TO EMERGE FROM THE CABIN INSTRUMENT CLUSTER. I PULLED TO THE SIDE OF THE ROAD AND NOW NOTICED THAT THE FUEL LEVEL DISPLAY AND THE COOLANT TEMPERATURE DISPLAY ARE NOT WORKING EVEN THOUGH ENGINE WAS A NORMAL OPERATING TEMP AND THE FUEL TANK WAS JUST FILLED UP. *TR
NHTSA ODI #10253622
50,000 miles · Dec 29, 2008
Electrical System
CAR WILL SUDDENLY STOP WORKING. VW CORPORATE WILL NOT ADDRESS AS THE CAR HAS HAND MANY ISSUES AND IS NO LONGER IN WARRANTY. SPENT $2K WITH VW DEALER TO DIAGNOSE. APPEARS TO BE ELECTRICAL IN NATURE. WHILE DRIVING THE CAR SUDDENLY STOP RUNNING AND ALL ELECTRICAL STOPS BRING CAR TO A HALT. ISSUE BEGAN 9/07 AND DEALER HAS HAD CAR…
Read full complaint
CAR WILL SUDDENLY STOP WORKING. VW CORPORATE WILL NOT ADDRESS AS THE CAR HAS HAND MANY ISSUES AND IS NO LONGER IN WARRANTY. SPENT $2K WITH VW DEALER TO DIAGNOSE. APPEARS TO BE ELECTRICAL IN NATURE. WHILE DRIVING THE CAR SUDDENLY STOP RUNNING AND ALL ELECTRICAL STOPS BRING CAR TO A HALT. ISSUE BEGAN 9/07 AND DEALER HAS HAD CAR IN SHOP ABOUT 2 MONTHS IN TOTAL. *TR
NHTSA ODI #10253017
Mileage unknown · Dec 20, 2008
Electrical System
I HAVE 2002 JETTA HAVING THE SAME ELECTRICAL PROBLEM. THE DOOR / LATCH SWITCH HAS A MALFUNCTION AND WON'T COME ON WHEN THE DOOR IS OPEN. THE DOME LIGHT DOES NOT COME ON AND THE LIGHT ON THE DOOR DOES NOT COME ON. WHICH CAN CAUSE AN ACCIDENT IF THE VEHICLE COMING FROM THE REAR OF THE VEHICLE AND CAN'T SEE THE DOOR IS OPEN AT N…
Read full complaint
I HAVE 2002 JETTA HAVING THE SAME ELECTRICAL PROBLEM. THE DOOR / LATCH SWITCH HAS A MALFUNCTION AND WON'T COME ON WHEN THE DOOR IS OPEN. THE DOME LIGHT DOES NOT COME ON AND THE LIGHT ON THE DOOR DOES NOT COME ON. WHICH CAN CAUSE AN ACCIDENT IF THE VEHICLE COMING FROM THE REAR OF THE VEHICLE AND CAN'T SEE THE DOOR IS OPEN AT NIGHT. THE DEALERSHIP WON'T REPLACE IT EVEN THOUGH IT WAS STILL UNDER WARRANTY AT THE TIME. THERE ARE PLENTY OF PEOPLE HAVING THE SAME PROBLEMS AND PAYS THE DEALERSHIP A LOT OF MONEY TO HAVE IT FIXED. OBVIOUSLY IT IS A PROBLEM WITH ALL JETTA THAT YEAR. THE DEALERSHIP SHOULD HAVE A RECALL THE DEFECTIVE SWITCH BE REPLACE. COULD POTENTIALLY CAUSE A FIRE. *TR
NHTSA ODI #10252330
85,000 miles · Dec 17, 2008
Electrical System
IGNITION COIL!!! WAS ENTERING INTERSTATE AND ACCELERATED AND ENGINE LOST A LOT OF POWER AND STARTED RUNNING ROUGHLY. WAS LUCKY ENOUGH TO BE ONLY A FEW MILES AWAY FROM A VW DEALERSHIP (NOT MY OWN, WE WERE OUT OF TOWN). THEY SAID #1 COIL FAILED, BE CAREFUL BECAUSE THE REST WILL PROBABLY FOLLOW SHORTLY, BUT RECOMMENDED I WAIT FOR…
Read full complaint
IGNITION COIL!!! WAS ENTERING INTERSTATE AND ACCELERATED AND ENGINE LOST A LOT OF POWER AND STARTED RUNNING ROUGHLY. WAS LUCKY ENOUGH TO BE ONLY A FEW MILES AWAY FROM A VW DEALERSHIP (NOT MY OWN, WE WERE OUT OF TOWN). THEY SAID #1 COIL FAILED, BE CAREFUL BECAUSE THE REST WILL PROBABLY FOLLOW SHORTLY, BUT RECOMMENDED I WAIT FOR ANOTHER ONE TO FAIL AND THEN REPLACE THE REST. $230 AND 16 DAYS LATER, ANOTHER FAILED. WAS NOT ACCELERATING HARD, JUST NORMAL HWY DRIVING. STARTED DOING SOME RESEARCH, FOUND OUT THIS IS A MAJOR PROBLEM AND HAS BEEN KNOWN FOR 5 YRS!!! WILL COMPLAIN TO HIGH HEAVEN TO GET THESE REPLACED FREE OF CHARGE. I UNDERSTAND NORMAL WEAR AND TEAR AND A RANDOM PART HERE AND THERE FAILING, BUT A 5YR OLD PROBLEM IS A LITTLE BIT HARDER TO UNDERSTAND. DEALERSHIP AND VW NEED TO PRACTICE BETTER BUSINESS PRACTICES AND I DON'T KNOW WHY THIS HASN'T BEEN AN OFFICIAL RECALL YET. LOSING POWER AT 65MPH ON AN INTERSTATE IS VERY DANGEROUS, NO MATTER WHAT VW OR NHTSA SAYS. WHAT IS IT GOING TO TAKE? DEATHS? I HOPE I CAN GET THIS RESOLVED TO MY SATISFACTION BY THE DEALERS AND VW. *TR
NHTSA ODI #10252078
Official recalls
5Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration