IllustrationWHILE DRIVING SMOKE FILLED IN CAR, FLAMES APPEARED BETWEEN DRIVER SEAT & COUNSEL. MY 17 Y/O GOT 2ND DEGREE BURNS PUTTING OUT FLAME. AIRBAG, DRIVER SIDE DEPLOYED WHILE CAR WAS SHUT OFF AND SEAT WAS BEING MOVED BACK. THIS CAUSED PAIN TO MY HUSBAND'S ARM.*AK
2001 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2001 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
11525–50K
7150–75K
5075–100K
46100–150K
18150K+
359 reports with mileage · 309 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 117 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports12 fire reports35 injury reports
What owners actually said
668 reportsCLUTCH MECHANISM SUDDENLY BEGAN ENGAGING ONLY AT THE UPPER END OF THE CLUTCH PEDAL TRAVEL WHILE DRIVING IN STOP AND GO TRAFFIC. THE VEHICLE HAD APPROX. 39,000 MILES ON IT AT THE TIME. THE RESULT WAS THAT THE VEHICLE WAS DIFFICULT TO CONTROL WHILE STARTING FROM A DEAD STOP, EITHER ROLLING BACKWARDS ON AN INCLINE, LURCHING AHEAD…
Read full complaint
CLUTCH MECHANISM SUDDENLY BEGAN ENGAGING ONLY AT THE UPPER END OF THE CLUTCH PEDAL TRAVEL WHILE DRIVING IN STOP AND GO TRAFFIC. THE VEHICLE HAD APPROX. 39,000 MILES ON IT AT THE TIME. THE RESULT WAS THAT THE VEHICLE WAS DIFFICULT TO CONTROL WHILE STARTING FROM A DEAD STOP, EITHER ROLLING BACKWARDS ON AN INCLINE, LURCHING AHEAD OR STALLING. ALL OF THESE CONDITIONS COULD CONTRIBUTE TO AN ACCIDENT, PARTICULARLY IN AN INTERSECTION OR IN CROWDED STOP AND GO CONDITIONS. INCLEMENT WEATHER WOULD COMPOUND THE SAFETY RISKS. THE CAR WAS TAKEN TO AN AUTHORIZED DEALER AND THE DEALER REPORTED A CLUTCH FAILURE, THAT THE CLUTCH IS A WEAR ITEM AND THAT NO WARRANTY IS OFFERED. AS I HAVE NEVER HAD A CLUTCH WEAR OUT IN 30 YEARS OF DRIVING , I RESEARCHED VIA THE INTERNET AND FOUND THE PROBLEM WAS COMMON AMONGST SIMILAR VW VEHICLES WITH THE 1.8T ENGINE AND THAT MANY SIMILAR FAILURES HAVE OCCURRED AT EVEN MUCH LOWER MILEAGE. I CONTACTED VW OF AMERICA CUSTOMER CARE AND VW DENIES THERE ARE ANY INHERENT DESIGN PROBLEMS, CITE DRIVER ERROR AND CONFIRMED WITH A RETURN CALL THAT NO FINANCIAL ASSISTANCE IS AVAILABLE. OTHER SOURCES, INCLUDING A VW MECHANIC HAVE INDEPENDENTLY ACKNOWLEDGED THAT VW HAVE SELECTED THE SAME FLYWHEEL, PRESSURE PLATE AND CLUTCH COMPONENTS AS ARE USED ON THE BASE NON-TURBOCHARGED ENGINE, AND THIS ARRANGEMENT IS UNDER DESIGNED FOR THE MORE POWERFUL 1.8T. I WAS ALSO ADVISED THE REPORTED FAILURE IS MORE CONSISTENT WITH A PRESSURE PLATE FAILURE THAN CLUTCH WEAR. ONE DEALERSHIP INFORMED ME THEY ARE REPLACING AT LEAST ONE OF THESE CLUTCH ASSEMBLIES PER WEEK, OFTEN ON LOW MILEAGE VEHICLES. SO FAR I HAVE NOT REPAIRED THE VEHICLE AND IT SITS IDLE WHILE I INVESTIGATE THE APPLICABILITY OF AFTERMARKET, HEAVIER DUTY COMPONENTS. *NM
THE CONSUMER WAS INVOLVED IN A FRONTAL COLLISION. BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. THIS CAUSED THE PASSENGER TO SUSTAIN MAJOR INJURIES AND WAS TAKEN TO THE HOSPITAL. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION. PLEASE PROVIDE ADDITIONAL DETAILS.
2001 JETTA ORIGINAL OWNER THE OIL PAN NEEDS TO BE REPLACED BECAUSE IT IS MADE OUT OF ALUMINUM AND THE PLUG IS MADE OUT OF STEEL .SINCE THE PLUG IS MADE OUT OF A HARDER MATERIAL IT STRIPPED THE PAN. THE CAR IS OUT OF WARRANTY SO KNOW I WILL HAVE TO PAY 600 DOLLARS. *NM
VW JETTA 2001 1.8T 5-SPD HAD A CLUTCH FAILURE WHILE DRIVING. THE ENGINE STARTED REVVING UP TO 6000 RPM BUT THE CAR SLOWED DOWN DRAMATICALLY. LUCKILY THERE WERE NO OTHER CARS IN THE LANE. THE MECHANIC DIAGNOSED THE CAR WITH A CLUTCH PLATE FAILURE AND HAD TO REPLACE THE CLUTCH ASSEMBLY ($1200). INSPITE OF THE EXTENDED WARRANTY PUR…
Read full complaint
VW JETTA 2001 1.8T 5-SPD HAD A CLUTCH FAILURE WHILE DRIVING. THE ENGINE STARTED REVVING UP TO 6000 RPM BUT THE CAR SLOWED DOWN DRAMATICALLY. LUCKILY THERE WERE NO OTHER CARS IN THE LANE. THE MECHANIC DIAGNOSED THE CAR WITH A CLUTCH PLATE FAILURE AND HAD TO REPLACE THE CLUTCH ASSEMBLY ($1200). INSPITE OF THE EXTENDED WARRANTY PURCHASE, VW DOES NOT COVER THIS AS IT RELATES IT TO "WEAR AND TEAR". THE CAR ONLY HAS 68K MILES ON IT, AND MOST OF IT IS HIGHWAY DRIVING (80%). AFTER SOME RESEARCH, IT LOOKS LIKE VW USES INFERIOR PARTS THAT CAUSE CLUTCH FAILURE IN MOST OF THEIR JETTAS. THIS IS A BIG CONCERN. VW PUTS THE BLAME ON THE DRIVER, BUT REFUSES TO ACKNOWLEDGE FAULTY PARTS. CHECK OUT WWW.MYVWLEMON.COM. *JB
NHTSA CAMPAIGN 04V096000; VOLKSWAGEN ISSUED A BRAKE LIGHT SWITCH RECALL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL, BUT THE BRAKE LIGHTS WERE NOT OPERATING. THE VIN WAS OUTSIDE THE REMEDY SCOPE. *JB
I OWN A 2001 VW JETTA WITH THE 1.9L TDI DIESEL ENGINE. THIS VEHICLE IS MAINTAINED BY MY LOCAL VW DEALERSHIP. DURING COLD WEATHER CONDITIONS BELOW 30 DEGREES F MY VEHICLE WOULD STOP RUNNING STRANDING ME AT NIGHT IN LOCATIONS WITH LITTLE ROAD TRAFFIC OR CELL PHONE SERVICE. THIS OCCURRED APPROXIMATELY 6 TIMES REQUIRING THE VEHIC…
Read full complaint
I OWN A 2001 VW JETTA WITH THE 1.9L TDI DIESEL ENGINE. THIS VEHICLE IS MAINTAINED BY MY LOCAL VW DEALERSHIP. DURING COLD WEATHER CONDITIONS BELOW 30 DEGREES F MY VEHICLE WOULD STOP RUNNING STRANDING ME AT NIGHT IN LOCATIONS WITH LITTLE ROAD TRAFFIC OR CELL PHONE SERVICE. THIS OCCURRED APPROXIMATELY 6 TIMES REQUIRING THE VEHICLE TO BE TOWED TO A DEALERSHIP. EACH TIME THAT THE VEHICLE WAS THAWED IN THEIR SHOP AND WAS DIAGNOSED WITH "IMPROPERLY TREATED DIESEL FUEL". I METICULOUSLY PUT IN THE RECOMMENDED AMOUNT OF VW ANTI-GEL ADDITIVE TO ALL TANK FULLS OF FUEL. I ALSO CONSISTENTLY PURCHASE MY DIESEL FUEL FROM THE SAME HIGH VOLUME SUPPLIER WHO HAS NUMEROUS FLEET ACCOUNTS. I HAD BEGUN TO TRIPLE DOSE THE DIESEL FUEL ADDITIVE IN ATTEMPTS TO AVOID THIS SITUATION. AFTER NUMEROUS TIMES OF BEING STRANDED IN SINGLE DIGIT CONDITIONS AND HAVING THE SAME SITUATION OCCUR I CHECKED A TDI OWNERS WEBSITE TDICLU.COM IT SEEMS THAT THE PROBLEM LIES IN THE FUEL TANK PICK UP WHICH HAS A RESTRICTION THAT ONLY SURFACES WHEN THE FUEL THICKENS DURING THE WINTER MONTHS. THE FUEL PICKUP/SENDING UNIT COMES IN A C, D, AND AN H MODEL. MY VEHICLE HAD THE C MODEL. APPARENTLY VW OF CANADA IS AWARE OF THIS SITUATION AND WITHOUT QUESTION OR CHARGE WOULD REPLACE THEIR CUSTOMERS CARS WITH THE H MODEL. I PURCHASED THE H MODEL PICKUP/SENDER AND REPLACED IT MYSELF AND THE PROBLEM HAS DISAPPEARED. TO DATE I HAVE INCURRED MORE THAN ONE THOUSAND DOLLARS IN TOWING AND REPAIR CHARGES FOR THIS PROBLEM THAT IS CLEARLY A VW DESIGN FLAW AND ONE THAT IS ACKNOWLEDGED BY VW OF CANADA. *NM
ON OUR 2001 VOLKSWAGEN JETTA MODEL, THE DRIVER DOOR LATCH FAILED WHICH IS TIED INTO THE ALARM, THE CABIN INTERIOR LIGHTS, OPEN DOOR WARNING CHIME, ETC. ON MOST AUTOMOBILES, THIS IS A SIMPLE SWITCH BUILT INTO THE DOOR JAMB. BUT ON THIS POORLY ENGINEERED VEHICLE, IT'S BUILT INTO THE DOOR LATCH IN THE DOOR, RESULTING IN THE ENTIRE…
Read full complaint
ON OUR 2001 VOLKSWAGEN JETTA MODEL, THE DRIVER DOOR LATCH FAILED WHICH IS TIED INTO THE ALARM, THE CABIN INTERIOR LIGHTS, OPEN DOOR WARNING CHIME, ETC. ON MOST AUTOMOBILES, THIS IS A SIMPLE SWITCH BUILT INTO THE DOOR JAMB. BUT ON THIS POORLY ENGINEERED VEHICLE, IT'S BUILT INTO THE DOOR LATCH IN THE DOOR, RESULTING IN THE ENTIRE DOOR HAVING TO BE TAKEN APART TO GET TO THIS PART, A $250-350 REPAIR BILL. I CALLED 3 VW DEALERSHIPS TO GET ESTIMATES, AND ALL THREE SERVICE DEPARTMENTS TOLD ME WITHIN THE FIRST MINUTE ON THE PHONE WHAT THE PROBLEM WAS AND THAT IT WAS FAIRLY COMMON. THREE YEAR OLD VEHICLES SHOULD NOT HAVE THESE KINDS OF PROBLEMS, NOR SHOULD THIS MECHANISM HAVE EVER BEEN ENGINEERED INTO A PART THAT GETS SLAMMED SHUT REPEATEDLY DAY IN AND DAY OUT. AMAZING! WE ARE UNSURE IF THE LATCH ITSELF IS SAFE OR NOT AND HAVE DECIDED TO PARK THE VEHICLE. AS I FEEL THIS IS A SERIOUS SAFETY ISSUE, I CALLED VW SERVICE REPS ABOUT THE PROBLEM BUT TO NO AVAIL. ANY HELP YOUR AGENCY CAN BE IN THIS MATTER WOULD BE HELPFUL. THIS ISN'T MY FIRST UNUSUAL PROBLEM WITH THIS VEHICLE. SINCERELY, TODD & GWEN WHATLEY TRI-CITIES, WA. *NM
ONE WEEK AFTER PURCHASING MY 2001 JETTA, MY FRONT BUMPER WAS ALMOST ENTIRELY RIPPED OFF AFTER BACKING OUT OF A PARKING SPACE. IT CAUGHT ON THE PARKING CURB AND SUBSEQUENTLY RIPPED OFF. UPON CONTACTING VW I WAS TOLD IT WAS MY DRIVING AND IT WOULD COST OVER $300 TO REPAIR. IT TURNS OUT THAT THIS HAS HAPPENED TO THOUSANDS AND TH…
Read full complaint
ONE WEEK AFTER PURCHASING MY 2001 JETTA, MY FRONT BUMPER WAS ALMOST ENTIRELY RIPPED OFF AFTER BACKING OUT OF A PARKING SPACE. IT CAUGHT ON THE PARKING CURB AND SUBSEQUENTLY RIPPED OFF. UPON CONTACTING VW I WAS TOLD IT WAS MY DRIVING AND IT WOULD COST OVER $300 TO REPAIR. IT TURNS OUT THAT THIS HAS HAPPENED TO THOUSANDS AND THOUSANDS OF VEHICLES. TWO YEARS LATER, NOW MY CAR IS PAID OFF AND I WAS TOLD BY ANOTHER VW DEALERSHIP TO BRING IT IN AND THEY WOULD FIX THE BUMPER. I DID AND TO MY SURPRISE THEY WANTED $237.00 TO FIX IT. THEN THEY ASKED WHAT I DID TO IT. I EXPLAINED THIS IS A PROBLEM WITH THESE PARTICULAR VEHICLES. THEY STATED THEY WERE NOT AWARE OF THIS PROBLEM. UPON PICKING UP MY CAR I BROUGHT AN ARTICLE REGARDING THE BUMPERS, THEY DIDN'T EVEN LOOK AT IT, THEY STATED, "WE KNOW, WE HAVE SEEN ALL THE ARTICLES, BUT WE HAVE NO CLOUT WITH VW, ONLY THE CONSUMER". SO, I NEED TO FILE A COMPLAINT. THERE ARE NUMEROUS OTHER DEFECTS, BUT THIS IS A MAJOR ONE THAT VW IS NOT WILLING TO REPAIR. THE OTHERS THEY HAVE AT LEAST ATTEMPTED TO FIX. *NM
UPON EXITING THE HIGHWAY MY CAR SUDDENLY TURNED OFF. I HAD TO COAST AND VEER OFF TO THE SIDE OF THE ROAD, JUST NARROWLY AVOIDING BEING HIT BY TWO CARS. I WAS ABLE TO START MY CAR AGAIN, BUT WAS ONLY ABLE TO KEEP THE ENGINE RUNNING BY REVVING IT SO THAT IT HAD A HIGH RPM. THE ONLY WAY THAT I WAS ABLE TO KEEP THE ENGINE RUNNING…
Read full complaint
UPON EXITING THE HIGHWAY MY CAR SUDDENLY TURNED OFF. I HAD TO COAST AND VEER OFF TO THE SIDE OF THE ROAD, JUST NARROWLY AVOIDING BEING HIT BY TWO CARS. I WAS ABLE TO START MY CAR AGAIN, BUT WAS ONLY ABLE TO KEEP THE ENGINE RUNNING BY REVVING IT SO THAT IT HAD A HIGH RPM. THE ONLY WAY THAT I WAS ABLE TO KEEP THE ENGINE RUNNING WHENEVER I REACHED TRAFFIC, A STOP SIGN, OR A STOP LIGHT WAS TO SHIFT FROM DRIVE TO NEUTRAL AND REVVING MY ENGINE. I HAD MY CAR TOWED TO VOLKSWAGEN, AND THE PROBLEM WAS AN IGNITION COIL FAILURE. THIS IS THE SAME PART THAT THE SIX CYLINDER JETTAS WERE RECALLED BY VOLKSWAGEN FOR, BUT WAS ONLY GIVEN A 10,000 MILE EXTENSION ON THE FOUR CYLINDER JETTAS. THIS IS PARTICULARLY TROUBLING BECAUSE THE PART "GOES" WITHOUT ANY WARNING. I NARROWLY AVOIDED AN ACCIDENT WITH MY 18 MONTH OLD SON SEATED IN THE BACK OF THE CAR. VW CHARGED ME A LITTLE OVER $1,000 FOR PARTS AND LABOR. I WAS, AND REMAIN, EXTREMELY DISSATISFIED, AND HAVE REPORTED THE INCIDENT TO VW'S 1-800 NUMBER. THE REPRESENTATIVE AGREED THAT THE FOUR CYLINDER JETTAS SHOULD BE RECALLED AS THE SIX CYLINDERS HAVE, BUT THAT VW ONLY OFFERS THE 10,000 MILE IGNITION COIL EXTENSION FOR THE FOUR CYLINDER JETTAS IN THE MEAN TIME.*AK
Official recalls
607V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
06V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V584000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
04V096000 · Exterior Lighting:brake Lights:switch
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V244000 · Equipment:other:owners/service/other Manual
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
02V031000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.