STARTER PROBLEM. WHEN STARTING THE CAR MOST TIMES WILL SCREECH REALLY LOUD. LED TO THE CONCLUSION IT IS THE STARTER FROM ONLINE FORUMS OF OWNERS OF SAME GENERATION JETTAS. SEEMS TO BE A PREMATURE WEAR ITEM. CAR HAS UNDER 130,000 MILES AND OTHER CARS OF SAME AGE AND MILEAGE DO NOT HAVE THIS ISSUE. FELL LIKE THERE IS A FAULT WITH …
Read full complaint
STARTER PROBLEM. WHEN STARTING THE CAR MOST TIMES WILL SCREECH REALLY LOUD. LED TO THE CONCLUSION IT IS THE STARTER FROM ONLINE FORUMS OF OWNERS OF SAME GENERATION JETTAS. SEEMS TO BE A PREMATURE WEAR ITEM. CAR HAS UNDER 130,000 MILES AND OTHER CARS OF SAME AGE AND MILEAGE DO NOT HAVE THIS ISSUE. FELL LIKE THERE IS A FAULT WITH THE STARTER.
NHTSA ODI #10945588
195,000 miles · Oct 6, 2016
Unknown Or Other
CAR WILL STALL AT A 1/4 TANK OF GAS WHEN IN MOTION. IT WILL DO THIS AT ANY SPEED OR ON ANY ROAD GOING UPHILL OR DOWN HILL. HAVE PUT 3 NEW FUEL PUMPS IN CHANGED THE FUEL PUMP SOLENOID AND STILL HAVE THE PROBLEM. THIS HAS BEEN GOING ON FOR A YEAR NOW.
NHTSA ODI #10914295
Mileage unknown · Oct 23, 2007
Unknown Or Other
BOUGHT A 2001 VW JETTA 1.8T GLS WOLFSBURG THREE WEEKS AGO. RAINS HIT ME FOR THE FIRST TIME TODAY AND ALTHOUGH ALL DOOR SEALS ARE 100% PROPER, WATER LEAKS INTO DRIVER'S SIDE FOOTWELLS VIA HOOD LATCH RELEASE AS BEST I CAN TELL. FOUND THE CAR FLOODED WITH 1-2 INCHES OF WATER, SOAKED INTO CARPET AND CARPET PADDING. REPLACING THE …
Read full complaint
BOUGHT A 2001 VW JETTA 1.8T GLS WOLFSBURG THREE WEEKS AGO. RAINS HIT ME FOR THE FIRST TIME TODAY AND ALTHOUGH ALL DOOR SEALS ARE 100% PROPER, WATER LEAKS INTO DRIVER'S SIDE FOOTWELLS VIA HOOD LATCH RELEASE AS BEST I CAN TELL. FOUND THE CAR FLOODED WITH 1-2 INCHES OF WATER, SOAKED INTO CARPET AND CARPET PADDING. REPLACING THE CARPET AND PADDING WOULD COST AROUND 1500 DOLLARS. FIXING THE OBVIOUS DEFECT IN DRAINAGE WILL PROBABLY COST ABOUT 300 FROM READING UP ON THIS ISSUE. THIS IS A DOCUMENTED ISSUE WITH VWS. CHECK OUT HTTP://WWW.CARSURVEY.ORG/VIEWCOMMENTS_REVIEW_43960.HTML ALSO SEE HTTP://WWW.THEAUTOBAHN.COM/FORUM/SHOWTHREAD.PHP?T=12789&PAGE=1&START=&PP=10 MY ONLY ABLE COURSE OF ACTION IS TO ASCERTAIN THE CAUSE OF THE LEAK AND FIX THAT MYSELF WITH ANY LUCK. THEN IT LOOKS LIKE A GAME OF CUTTING AND PEELING THE CARPET BACK TO DRY THE PADS TO AVOID MOLD AND ODOR, NEITHER OF WHICH WILL I BE ABLE TO ACTUALLY PREVENT FULLY. OF COURSE THE PREVIOUS OWNER HAS NO MEMORY OF THE ISSUE. BUT IT'S NOT JUST ME, CHECK OUT THE FORUMS I PROVIDED WEB ADDRESSES TO. *JB
NHTSA ODI #10206700
Mileage unknown · Oct 12, 2007
Unknown Or Other
APPROXIMATELY 3 MONTHS AFTER PURCHASING MY 2001 JETTA, I NOTICED A CRAYON/WAX SMELL THROUGHOUT THE INTERIOR OF THE CAR. EVERY ONE OF MY PASSENGERS HAS COMMENTED ON THE PUNGENCY OF THE CRAYON SMELL. A COUPLE MONTHS LATER, I BROUGHT MY CAR IN TO BE SERVICED AND NOTIFIED THE DEALER OF THIS SMELL, AND HE RESPONDED THAT THIS WAS TH…
Read full complaint
APPROXIMATELY 3 MONTHS AFTER PURCHASING MY 2001 JETTA, I NOTICED A CRAYON/WAX SMELL THROUGHOUT THE INTERIOR OF THE CAR. EVERY ONE OF MY PASSENGERS HAS COMMENTED ON THE PUNGENCY OF THE CRAYON SMELL. A COUPLE MONTHS LATER, I BROUGHT MY CAR IN TO BE SERVICED AND NOTIFIED THE DEALER OF THIS SMELL, AND HE RESPONDED THAT THIS WAS THE "STANDARD VOLKSWAGEN SMELL". OTHER SUBSEQUENT DEALERSHIPS HAVE CLAIMED THAT THEY HAVE NEVER EVEN HEARD OF THIS SMELL BEFORE. ON HOT DAYS, THE SMELL BECOMES GROSSLY PUNGENT AND HAS CAUSED ME AND MY PASSENGERS HEADACHES AND NAUSEA. THE SMELL EVEN STAYS IN MY CLOTHES FOR DAYS. I AM AFRAID WHETHER THIS SMELL IS TOXIC. *JB
NHTSA ODI #10205537
95,000 miles · Aug 23, 2006
StructureSuspensionUnknown Or Other
I HAVE HAD NOTHING BUT ISSUES WITH MY 2001 JETTA. I HAVE REPLACED ALL THE WHEEL BEARINGS AND THE FRONT BEARING TWICE. I HAVE ALSO HAD TO REPLACE THE ENGINE COILS TWICE ON THIS CAR. NOW IN THE LAST 2-3 WEEKS THE CLEAR COAT HAS STARTED TO PEEL OFF THE CAR. THE PAINT IS NOT COMING OFF JUST THE CLEAR COAT. I CALLED THE VW CARE …
Read full complaint
I HAVE HAD NOTHING BUT ISSUES WITH MY 2001 JETTA. I HAVE REPLACED ALL THE WHEEL BEARINGS AND THE FRONT BEARING TWICE. I HAVE ALSO HAD TO REPLACE THE ENGINE COILS TWICE ON THIS CAR. NOW IN THE LAST 2-3 WEEKS THE CLEAR COAT HAS STARTED TO PEEL OFF THE CAR. THE PAINT IS NOT COMING OFF JUST THE CLEAR COAT. I CALLED THE VW CARE CENTER AND THEY RAN ME AROUND HAVING ME TAKE THE CAR TO A VW BODY SHOP, AND HAVING THE SERVICE MANAGER LOOK AT IT AND NEITHER ONE OF THEM COULD TELL ME WHY THE CLEAR COAT WAS PEELING. THEY BOTH DID RESPOND BY SAYING THE COULD BE SURE BUT IN MAY HAVE BEEN OVER BAKED AT THE FACTORY AFTER IT WAS PAINTED BUT OF COURSE NOBODY WANT TO ADMIT THAT BECAUSE THEN VW WOULD BE LIABLE TO FIX IT. SO IN CALLING THE VW CARE CENTER BACK THE PRETTY MUCH TOLD ME THE CAR WAS 5 YEAR OLD AND IT WASN'T THEIR PROBLEM ANY MORE BUT MINE. GREAT CUSTOMER SERVICE. I'VE OWNED OTHER CARS AND NEVER HAD A PROBLEM WITH THE CLEAR COAT. GRANTED THEY WERE NOT VW CARS. I RECOMMEND NOT TO BUY A VW OF ANY KIND BECAUSE THIS COMPANY WILL NOT STAND BY THEIR FAULT. I MEAN 5 YEARS OLD THAT THE CLEAR COAT IS PEELING OFF. THAT ISN'T RIGHT. THANKS FOR NOTHING VW. DON'T BUY A VW. *JB
NHTSA ODI #10166363
48,080 miles · Oct 20, 2005
SeatsUnknown Or Other
2001 JETTA VR6 DRIVER SEAT ROCKS BECAUSE OF BROKEN GEARS. *TS THE DEALER WOULD NOT REPAIR THE SEAT FREE OF CHARGE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. THE DEALER DETERMINED THAT THERE IS A BAD GEAR AND IT WILL COST OVER $700. TO REPAIR. THE CONSUMER CONSIDERS THIS A SAFETY ISSUE AND BELIEVES THIS MAY AFFECT THE PROPER OP…
Read full complaint
2001 JETTA VR6 DRIVER SEAT ROCKS BECAUSE OF BROKEN GEARS. *TS THE DEALER WOULD NOT REPAIR THE SEAT FREE OF CHARGE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. THE DEALER DETERMINED THAT THERE IS A BAD GEAR AND IT WILL COST OVER $700. TO REPAIR. THE CONSUMER CONSIDERS THIS A SAFETY ISSUE AND BELIEVES THIS MAY AFFECT THE PROPER OPERATION OF THE SIDE MOUNTED AIR BAGS. THE GLOVE COMPARTMENT ALSO BROKE. *NM
NHTSA ODI #10141029
100,500 miles · May 1, 2003
Unknown Or Other
I PURCHASED A NEW 2001 TDI JETTA. I HAVE HAD THREE MASS AIR SENSORS REPLACED, TWO OF WHICH WERE COVERED UNDER MY EXTENDED WARRENTY AT APPROXIMATELY 37,000 MILES, THIS LAST ONE WAS NOT. VW REFUSED TO ASSIST WITH THE REPAIR. ALSO, A DEALER PREVIOUSLY TOLD ME BACK IN AUGUST 2002 THAT I NEEDED $700.00 WORTH OF GLOW PLUG SENSORS …
Read full complaint
I PURCHASED A NEW 2001 TDI JETTA. I HAVE HAD THREE MASS AIR SENSORS REPLACED, TWO OF WHICH WERE COVERED UNDER MY EXTENDED WARRENTY AT APPROXIMATELY 37,000 MILES, THIS LAST ONE WAS NOT. VW REFUSED TO ASSIST WITH THE REPAIR. ALSO, A DEALER PREVIOUSLY TOLD ME BACK IN AUGUST 2002 THAT I NEEDED $700.00 WORTH OF GLOW PLUG SENSORS AND GLOW PLUGS. I HAD THEM REPLACE THE SENSOR FOR $400.00. THEY DID NOT HAVE THE GLOW PLUGS IN STOCK. INCIDENTLY MY CAR STARTED EVERY TIME THIS WINTER IN THE FREEZING COLD. IT TURNS OUT THAT THEY WERE NOT BAD AFTER ALL AND THAT I NEEDED A GLOW PLUG HARNESS FOR $118.00., WHICH I FOUND OUT LAST WEEK WHEN IT BROKE DOWN ON ME AGAIN. IF I HAD REPLACED THE PLUGS I WOULD HAVE WASTED ANOTHER $300.00. LAST WEEK MY CAR DISPLAYED THE SAME SYMPTOMS AS IT DID WHEN MY MASS AIR SENSOR FAILED THE FIRST TWO TIMES. I TOOK IT TO THE FIRST DEALER THAT I COULD GET IN TO AND THEY TOLD ME NEEDED TO CLEAN MY INTAKE MAINFOLD, REPLACE THE FUEL FILTER, AIR FILTER, GLOW PLUG HARNESS AND MASS AIR SENSOR FOR $1200.00. I UNDERSTAND THAT THEY HAVE TO VW HAS TO REPLACE GREATER THAN 50% OF THEIR MASS AIR SENSORS. WHY ARE THEY NOT RECALLED. I DRIVE 100 MILES TO WORK EACH WAY AND THIS CAR HAS BEEN AN EXPENSIVE LET DOWN. I HAVE NO FAITH IN THE VW COMPANY AND ONCE THEY GET YOUR MONEY THEY DO NOT SEEM TO CARE AT ALL. THE CAR IS UNSAFE. I WILL CONTINUE TO PURSUE THEM UNTIL I GET SOME RESOLUTION.
NHTSA ODI #10016826
Mileage unknown · Aug 16, 2002
Unknown Or Other
VEHICLE HAS A BURNING RUBBER/WAX SMELL. WHEN ENGINE GETS HOT SMELL GETS REALLY TOXIC. VEHICLE CHECKED BY DEALER, WHO REPLACED CARPET BETWEEN FIREWALL AND DASHBOARD, SINCE THEN SMELL IS EVEN WORSE.*AK *YH
NHTSA ODI #8016574
Mileage unknown · May 6, 2002
Unknown Or Other
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #761606
Mileage unknown · Mar 15, 2002
SeatsSuspensionUnknown Or Other
L HAVE HAD NUMEROUS "FACTORY DEFECTS" WITH MY NEW VEHICLE AND NO ONE CAN HELP ME SOLVE MY DILEMA. THE VEHICLE IM SUBMITTING TO YOU IS NOT THE ORGINIALLY PURCHASED CAR. THEY HAD TO GIVE ME A 2ND VEHICLE. I HAVE HAD NUMEROUS PROBLEMS EVER SINCE WITH KEYLESS REMOTE UNI (REPLACED), AUTO WINDOW UNIT(BOTH DRIVER, PASSNEGER-BOTH UNITS …
Read full complaint
L HAVE HAD NUMEROUS "FACTORY DEFECTS" WITH MY NEW VEHICLE AND NO ONE CAN HELP ME SOLVE MY DILEMA. THE VEHICLE IM SUBMITTING TO YOU IS NOT THE ORGINIALLY PURCHASED CAR. THEY HAD TO GIVE ME A 2ND VEHICLE. I HAVE HAD NUMEROUS PROBLEMS EVER SINCE WITH KEYLESS REMOTE UNI (REPLACED), AUTO WINDOW UNIT(BOTH DRIVER, PASSNEGER-BOTH UNITS REPLACED),DRIVER SEAT NOT BOLTED TO FLOOR. HAD TO GET A NEW SEAT. NEW SHOCKS, NEW PACKING BETWEEN REAR PASS. DOOR PANELS. ALL CLAIMED TO BE FACTORY DEFECTS PER THE DEALER. I HAVE ESTABLISHED A CLAIM THROUGH VW OF AMERICA BUT THEY CANNOT ASSIST. THEY WILL ONLY TAKE MY COMPLAINTS. *AK
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
2001 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration