IllustrationPROBLEMS WITH 2001 JETTA BRAKE SYSTEM.*MR REAR BRAKE FAILURE CALLED FOR REPLACEMENT OF ROTORS, CALIPERS AND REQUIRED A COMPLETE BRAKE SYSTEM FLUSH. THE CONSUMER WAS CONCERNED AS TO WHY THE ABS WARNING LIGHT DID NOT ACTIVATE. *PH *JB
2001 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2001 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
11525–50K
7150–75K
5075–100K
46100–150K
18150K+
359 reports with mileage · 309 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 117 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports12 fire reports35 injury reports
Service Brakes, Hydraulic complaints
67 reportsAT APPR 30,000 MY D/S REAR BRAKES LOCKED UNTIL THE PAD WAS GONE. THE VEHICLE OPERATION DID NOT CHANGE. UPON HEARING A METAL TO METAL NOISE I DROVE IMMEDIATELY TO MY DEALER. I REPLACED THE REARPAD AND DECLINED REPLACING THE ROTOR AS IT DID NOT HAVE ANY GROOVING. I HAVE NAD AN AN OCCASION WERE MY ABS DID NOT KICK IN AND ONE WERE T…
Read full complaint
AT APPR 30,000 MY D/S REAR BRAKES LOCKED UNTIL THE PAD WAS GONE. THE VEHICLE OPERATION DID NOT CHANGE. UPON HEARING A METAL TO METAL NOISE I DROVE IMMEDIATELY TO MY DEALER. I REPLACED THE REARPAD AND DECLINED REPLACING THE ROTOR AS IT DID NOT HAVE ANY GROOVING. I HAVE NAD AN AN OCCASION WERE MY ABS DID NOT KICK IN AND ONE WERE THE ABS WAS ACTIVATED UPON REGULAR BRAKING. THIS IS VW #3 AND LAST VW FOR ME. THIS ALONG W/ HAVING AN ELECTRICAL PROBLEM THAT RESULTED IN A NEW COMPUTER, NEW WIREING HARNESS AND 2 NEW SETS OF GLOW PLUGS IS UNACCEPTABLE. *AK
SEE SIMILAR COMPLAINT #8000894 REAR BRAKES WORE TO BARE METAL WITH NO WARNING AT 2500 MILES. NO AUDIBLE WARNING, AND THE PRIOR SERVICE AT 2000 MILES REVEALED NO IMMINENT WEAR PROBLEM. SEEMS TO BE COMMON PROBLEM BASED ON WEB SEARCHES ON THIS PROBLEM. VEHICLE WAS MADE UNSAFE BY THIS AGGRESSIVE BRAKE WEAR AND REDUCED STOPPING ABILI…
Read full complaint
SEE SIMILAR COMPLAINT #8000894 REAR BRAKES WORE TO BARE METAL WITH NO WARNING AT 2500 MILES. NO AUDIBLE WARNING, AND THE PRIOR SERVICE AT 2000 MILES REVEALED NO IMMINENT WEAR PROBLEM. SEEMS TO BE COMMON PROBLEM BASED ON WEB SEARCHES ON THIS PROBLEM. VEHICLE WAS MADE UNSAFE BY THIS AGGRESSIVE BRAKE WEAR AND REDUCED STOPPING ABILITY. WOULD LIKE TO SEE VW ADD SOME SORT OF WARNING DEVICE. LACK OF WARNING LEAD TO ROTOR DAMAGE AND REPLACEMENT (UNNECESSARY EXPENSE).*AK
THE GEAR WAS HARD TO SHIFT OUT OF PARK AND THE BRAKE SENSOR NEEDED TO BE REPLACED. *JB
MY 2001 VW JETTA JUST ROLLED 30000 ON THE ODOMETER. I HAVE HEARD THAT THERE ARE PROBLEMS WITH THE BRAKE PADS ON THE REAR OF THE CAR. I HAD TO PAY $350 TO GET THE PADS REPLACED AND GET THE ROTORS REFINISHED. I DON'T DRIVE THE CAR UNUSUALLY HARD AND DID NOT EXPECT THE BRAKES TO GO SO QUICKLY. ALSO, THIS PAST WINTER, ALL OF THE…
Read full complaint
MY 2001 VW JETTA JUST ROLLED 30000 ON THE ODOMETER. I HAVE HEARD THAT THERE ARE PROBLEMS WITH THE BRAKE PADS ON THE REAR OF THE CAR. I HAD TO PAY $350 TO GET THE PADS REPLACED AND GET THE ROTORS REFINISHED. I DON'T DRIVE THE CAR UNUSUALLY HARD AND DID NOT EXPECT THE BRAKES TO GO SO QUICKLY. ALSO, THIS PAST WINTER, ALL OF THE SPARK PLUGS WERE SHOT. THIS NOT SURPRISINGLY OCCURRED RIGHT AFTER THE WARRANTY EXPIRED. I HAVE HAD NUMEROUS LITTLE PROBLEMS WITH THE CAR SINCE I BOUGHT IT. I AM LEANING TOWARD NEVER LOOKING TO PURCHASE A VOLKSWAGEN AGAIN. *JB
BACK BRAKES AND ROTORS HAD TO BE REPLACED ON MY 2001 JETTA GLX V6 WHICH WAS PURCHASED 08/01. I ONLY HAD 23,000 MILES ON THE CAR! AT MY 20,000 MILE SERVICE NO PROBLEMS WERE MENTIONED. MY CHECK ENGINE LIGHT CAME ON TOO. I HAD TO HAVE MY O2 SENSOR REPLACED UNDER WARRANTY. THE WARRANTY DID NOT COVER THE BRAKES. I DO NOT RIDE …
Read full complaint
BACK BRAKES AND ROTORS HAD TO BE REPLACED ON MY 2001 JETTA GLX V6 WHICH WAS PURCHASED 08/01. I ONLY HAD 23,000 MILES ON THE CAR! AT MY 20,000 MILE SERVICE NO PROBLEMS WERE MENTIONED. MY CHECK ENGINE LIGHT CAME ON TOO. I HAD TO HAVE MY O2 SENSOR REPLACED UNDER WARRANTY. THE WARRANTY DID NOT COVER THE BRAKES. I DO NOT RIDE THE BRAKES. 1 MONTH AFTER I BOUGHT THE CAR I NOTICED THAT WHEN I START IT IN THE MORNING IT MAKES A SOUND LIKE AND OLD JUNKY CAR WOULD. I HAD IT TO THE DEALER TWICE FOR THIS AND THEY SAID ITS NOTHING AND THAT'S THE WAY A V6 SOUNDS! IT ONLY DOES IT ON THE FIRST START OF THE DAY. I AM AFRAID IT WILL END UP BEING SOME VERY EXPENSIVE PROBLEM IN THE FUTURE. 9 MONTHS AFTER I HAD THE CAR THE ARM REST CAME APART AND HAD TO BE FIXED UNDER WARRANTY. I WILL NEVER BUY ANOTHER VOLKSWAGEN AGAIN AND I WOULD NOT RECOMMEND THEM TO MY FRIENDS WHO ARE MD'S AND RN'S AND CAN AFFORD NICE CARS. *JB
VOLKSWAGEN OF AMERICA KNOWS ABOUT A BRAKE PROBLEM WITH 2001 JETTA'S. THEY ARE SOFT BRAKE PADS, WEARING OUT BEFORE IT'S TIME WITH NO INDICATION WHAT SO EVER. THE BRAKES GRIND INTO THE ROTORS, WHICH NEED TO BE REPLACED. VW HAS REPLACED BOTH PADS AND BRAKES WITH SOME CUSTOMERS (OUTSIDE OF THE WARRANTY PROBLEM) BUT CONTINUES TO DENY…
Read full complaint
VOLKSWAGEN OF AMERICA KNOWS ABOUT A BRAKE PROBLEM WITH 2001 JETTA'S. THEY ARE SOFT BRAKE PADS, WEARING OUT BEFORE IT'S TIME WITH NO INDICATION WHAT SO EVER. THE BRAKES GRIND INTO THE ROTORS, WHICH NEED TO BE REPLACED. VW HAS REPLACED BOTH PADS AND BRAKES WITH SOME CUSTOMERS (OUTSIDE OF THE WARRANTY PROBLEM) BUT CONTINUES TO DENY IT IN OTHERS - SUCH AS MYSELF. *JB
@ 20000 MILES DESERT VW PERFORMED WARRENTY SERVICE (5 WEEKS AGO) WHICH INCLUDED A COMPLETE BREAK INSPECTION. AT THE TIME NO PROBLEM WAS SEEN. @ 22000 MILES BOTH PADS ON THE BACK WERE TOTALLY GONE. I UNDERSTAND VW USED A THINNER PAD ON THE 2001 JETTA'S. THIS WAS TO CUT DOWN ON NOISE NOTED ON THE 2000 MODELS IN 2002 VW WENT BACK …
Read full complaint
@ 20000 MILES DESERT VW PERFORMED WARRENTY SERVICE (5 WEEKS AGO) WHICH INCLUDED A COMPLETE BREAK INSPECTION. AT THE TIME NO PROBLEM WAS SEEN. @ 22000 MILES BOTH PADS ON THE BACK WERE TOTALLY GONE. I UNDERSTAND VW USED A THINNER PAD ON THE 2001 JETTA'S. THIS WAS TO CUT DOWN ON NOISE NOTED ON THE 2000 MODELS IN 2002 VW WENT BACK TO THE OLD PADS. I CONTACTED VW OF AMERICA, AND DESERT VW. BOTH TOLD ME CHANGING THE BACK BRAKES @ 22000 MILES WAS NORMAL. HOW WAS MY PADS BEING WORN DOWN TO NOTHING MISSED AT 20000? @ 22000 I'M DOING A BRAKE JOB ON THE BACK BRAKES ONLY? IT WOULD SEEM THAT BRAKES, (ON THE BACK), SHOULD LAST 2 TO 1 FROM THE FRONT. THE SHOP THAT DID THE REPAIR SAID HE HAS NEVER ENCOUNTED THIS BEFORE AND THIS SHOP HANDLES IMPORTS ONLY. PLEASE CONTACT ME AND I WILL FORWARD ALL INFORMATION TO YOUR OFFICE. I FEEL THIS IS UNSAFE, COSTLY AND CAN BE CORRECTED. DT
HAD PROBLEMS PRIOR WITH BRAKE PEDAL VIBRATING WHEN DEPRESSED SLIGHTLY AND ALSO DURING TURNS WITH LOSS OF BRAKE POWER. ABS SYSTEM REPLACED BY LOCAL DEALER. HAD AN INCIDENT AFTER REPLACEMENT. GOING DOWN A HILL AT 45 MPH WITH A RIGHT BEND, APPLIED BRAKES. SAME VIBRATION IN BRAKE PEDAL, NO BRAKING POWER AND STEERING KICKED CAR SHARP…
Read full complaint
HAD PROBLEMS PRIOR WITH BRAKE PEDAL VIBRATING WHEN DEPRESSED SLIGHTLY AND ALSO DURING TURNS WITH LOSS OF BRAKE POWER. ABS SYSTEM REPLACED BY LOCAL DEALER. HAD AN INCIDENT AFTER REPLACEMENT. GOING DOWN A HILL AT 45 MPH WITH A RIGHT BEND, APPLIED BRAKES. SAME VIBRATION IN BRAKE PEDAL, NO BRAKING POWER AND STEERING KICKED CAR SHARPLY TO LEFT AND ENDED UP OFF THE ROAD. THEN EVERYTHING SEEMED TO WORK AGAIN BUT STILL EXPERIENCING PROBLEMS CAR GOING IN FOR MORE SERVICE YET AGAIN. DT
CONSUMER STATES THAT WHILE DRIVING THE VEHICLE INTO HER DRIVE WAY SHE PROCEED TO STOP AND BRAKES FAIL.CONSUMER SAYS THAT THERE IS A RECALL OUT BUT DOES NOT INCLUDE HER VIN NUMBER.
Official recalls
607V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
06V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V584000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
04V096000 · Exterior Lighting:brake Lights:switch
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V244000 · Equipment:other:owners/service/other Manual
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
02V031000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.