NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
62 reportsClear category filter50,000 miles · May 10, 2005
Power Train
2001 VW JETTA VR6 TRANSMISSION FAILS TO SHIFT SMOOTHLY FROM 1ST TO 2ND AND 2ND TO 3RD GEAR. ENGINE RPMS SPIKE/SURGE BEFORE ENGAGING NEXT HIGHEST GEAR, AT WHICH POINT THE GEAR IS SLAMMED INTO AS THE RPMS ARE TOO HIGH TO ENGAGE THE GEAR PROPERLY. HAVE TAKEN THE VEHICLE TO TWO DIFFERENT VW DEALERS TWO DIFFERENT TIMES (FOUR VISITS…
Read full complaint
2001 VW JETTA VR6 TRANSMISSION FAILS TO SHIFT SMOOTHLY FROM 1ST TO 2ND AND 2ND TO 3RD GEAR. ENGINE RPMS SPIKE/SURGE BEFORE ENGAGING NEXT HIGHEST GEAR, AT WHICH POINT THE GEAR IS SLAMMED INTO AS THE RPMS ARE TOO HIGH TO ENGAGE THE GEAR PROPERLY. HAVE TAKEN THE VEHICLE TO TWO DIFFERENT VW DEALERS TWO DIFFERENT TIMES (FOUR VISITS TOTAL) AND DEALERS SAY THEY CANNOT DUPLICATE THE PROBLEM OR THAT THEY RESET THE SHIFTING POINTS IN THE FUZZY LOGIC. INDEPENDENT TRANSMISSION SHOP CALLS FOR REPLACEMENT OF THE VALVE BODY, ALL ELECTRONICS AND HARD COMPONENTS IN VALVE BODY FOR A COST OF $3425. VW OF AMERICA REFUSES TO ACKNOWLEDGE A PROBLEM EXITS UNLESS DIAGNOSED BY A VW DEALER AND WILL NOT PAY FOR DIAGNOSIS BY A THIRD PARTY MECHANIC. THIS PROBLEM HAS PERSISTED FOR OVER 15 MONTHS AND 30,000 MILES.
NHTSA ODI #10120578
Mileage unknown · Mar 21, 2005
Exterior LightingPower Train
UPON STARTING THE VEHICLE AND PUTTING FOOT ON THE BRAKE TO MOVE INTO ANOTHER GEAR THE BRAKE LIGHT ILLUMINATED. THE BRAKE APPEARED TO LOCK THE GEAR SHIFT, AND YOU COULD NOT GET IT TO GO INTO ANOTHER GEAR. THE SHIFT WILL NOT COME OUT OF PARK. CONSUMER TOOK THE VEHICLE TO DEALER TO BE REPAIRED. *AK
NHTSA ODI #10115442
29,220 miles · Mar 8, 2005
Power Train
WHILE DRIVING 20 MPH TRANSMISSION JERKED BEFORE SHIFTING GEARS. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10113650
Mileage unknown · Feb 24, 2005
Engine And Engine CoolingPower TrainStructure
2001 JETTA- MAKES WINDING NOISE AT 40 MPH, EAR PIERCING, TECHNICIANS CLAIM THIS IS NORMAL BUT OVERPOWERS RADIO? UNACCEPTABLE. TRANSMISSION SHIFTS ERRATICALLY ALL THE TIME, CAR WILL LUNGE FORWARD WHEN AT A STOP WHEN FOOT TAKEN OFF BRAKE PEDAL. CAR MAKES A KNOCKING NOISE WHEN AT A COMPLETE STOP. *NM
NHTSA ODI #10112085
Mileage unknown · Feb 10, 2005
Power Train
2001 VW JETTA TDI - TOTAL TRANSMISSION FAILURE @ 68,000 MILES. WARRANTY WAS UP AT 50K. VW STATED THEY COULD NOT DO ANYTHING ABOUT IT, EXCEPT CHARGE ME $3800 FOR A FACTORY REFERBED TRANSMITION (PART ONLY). 68,000 MILES ON THIS CAR WOULD BE CONSIDERED A GOOD BREAK IN MILAGE NOT AN OOPS YOU GOT TO REPLACE THE TRANSMITION. I A…
Read full complaint
2001 VW JETTA TDI - TOTAL TRANSMISSION FAILURE @ 68,000 MILES. WARRANTY WAS UP AT 50K. VW STATED THEY COULD NOT DO ANYTHING ABOUT IT, EXCEPT CHARGE ME $3800 FOR A FACTORY REFERBED TRANSMITION (PART ONLY). 68,000 MILES ON THIS CAR WOULD BE CONSIDERED A GOOD BREAK IN MILAGE NOT AN OOPS YOU GOT TO REPLACE THE TRANSMITION. I AM VERY UNSATISFIED THAT VW WILL NOT STAND BEHIND THERE PRODUCT EVEN THOUGH IT IS OUT OF WARRANTY. 68,000 MILES ON A TOTALLY SEALED TRANSMITION. NOT EVEN A DIP STICK TO CHECK FLUIDS. NO LEAKS WERE PRESENT, NO WARRNING SIGNS, JUST INSTANT FAILURE. FIRST AND LAST VW FOR ME. CONSUMERS BE AZWARE!!!!! *AK
NHTSA ODI #10110236
39,000 miles · Jan 25, 2005
Power Train
CLUTCH MECHANISM SUDDENLY BEGAN ENGAGING ONLY AT THE UPPER END OF THE CLUTCH PEDAL TRAVEL WHILE DRIVING IN STOP AND GO TRAFFIC. THE VEHICLE HAD APPROX. 39,000 MILES ON IT AT THE TIME. THE RESULT WAS THAT THE VEHICLE WAS DIFFICULT TO CONTROL WHILE STARTING FROM A DEAD STOP, EITHER ROLLING BACKWARDS ON AN INCLINE, LURCHING AHEAD…
Read full complaint
CLUTCH MECHANISM SUDDENLY BEGAN ENGAGING ONLY AT THE UPPER END OF THE CLUTCH PEDAL TRAVEL WHILE DRIVING IN STOP AND GO TRAFFIC. THE VEHICLE HAD APPROX. 39,000 MILES ON IT AT THE TIME. THE RESULT WAS THAT THE VEHICLE WAS DIFFICULT TO CONTROL WHILE STARTING FROM A DEAD STOP, EITHER ROLLING BACKWARDS ON AN INCLINE, LURCHING AHEAD OR STALLING. ALL OF THESE CONDITIONS COULD CONTRIBUTE TO AN ACCIDENT, PARTICULARLY IN AN INTERSECTION OR IN CROWDED STOP AND GO CONDITIONS. INCLEMENT WEATHER WOULD COMPOUND THE SAFETY RISKS. THE CAR WAS TAKEN TO AN AUTHORIZED DEALER AND THE DEALER REPORTED A CLUTCH FAILURE, THAT THE CLUTCH IS A WEAR ITEM AND THAT NO WARRANTY IS OFFERED. AS I HAVE NEVER HAD A CLUTCH WEAR OUT IN 30 YEARS OF DRIVING , I RESEARCHED VIA THE INTERNET AND FOUND THE PROBLEM WAS COMMON AMONGST SIMILAR VW VEHICLES WITH THE 1.8T ENGINE AND THAT MANY SIMILAR FAILURES HAVE OCCURRED AT EVEN MUCH LOWER MILEAGE. I CONTACTED VW OF AMERICA CUSTOMER CARE AND VW DENIES THERE ARE ANY INHERENT DESIGN PROBLEMS, CITE DRIVER ERROR AND CONFIRMED WITH A RETURN CALL THAT NO FINANCIAL ASSISTANCE IS AVAILABLE. OTHER SOURCES, INCLUDING A VW MECHANIC HAVE INDEPENDENTLY ACKNOWLEDGED THAT VW HAVE SELECTED THE SAME FLYWHEEL, PRESSURE PLATE AND CLUTCH COMPONENTS AS ARE USED ON THE BASE NON-TURBOCHARGED ENGINE, AND THIS ARRANGEMENT IS UNDER DESIGNED FOR THE MORE POWERFUL 1.8T. I WAS ALSO ADVISED THE REPORTED FAILURE IS MORE CONSISTENT WITH A PRESSURE PLATE FAILURE THAN CLUTCH WEAR. ONE DEALERSHIP INFORMED ME THEY ARE REPLACING AT LEAST ONE OF THESE CLUTCH ASSEMBLIES PER WEEK, OFTEN ON LOW MILEAGE VEHICLES. SO FAR I HAVE NOT REPAIRED THE VEHICLE AND IT SITS IDLE WHILE I INVESTIGATE THE APPLICABILITY OF AFTERMARKET, HEAVIER DUTY COMPONENTS. *NM
NHTSA ODI #10107903
Mileage unknown · Jan 20, 2005
Power Train
VW JETTA 2001 1.8T 5-SPD HAD A CLUTCH FAILURE WHILE DRIVING. THE ENGINE STARTED REVVING UP TO 6000 RPM BUT THE CAR SLOWED DOWN DRAMATICALLY. LUCKILY THERE WERE NO OTHER CARS IN THE LANE. THE MECHANIC DIAGNOSED THE CAR WITH A CLUTCH PLATE FAILURE AND HAD TO REPLACE THE CLUTCH ASSEMBLY ($1200). INSPITE OF THE EXTENDED WARRANTY PUR…
Read full complaint
VW JETTA 2001 1.8T 5-SPD HAD A CLUTCH FAILURE WHILE DRIVING. THE ENGINE STARTED REVVING UP TO 6000 RPM BUT THE CAR SLOWED DOWN DRAMATICALLY. LUCKILY THERE WERE NO OTHER CARS IN THE LANE. THE MECHANIC DIAGNOSED THE CAR WITH A CLUTCH PLATE FAILURE AND HAD TO REPLACE THE CLUTCH ASSEMBLY ($1200). INSPITE OF THE EXTENDED WARRANTY PURCHASE, VW DOES NOT COVER THIS AS IT RELATES IT TO "WEAR AND TEAR". THE CAR ONLY HAS 68K MILES ON IT, AND MOST OF IT IS HIGHWAY DRIVING (80%). AFTER SOME RESEARCH, IT LOOKS LIKE VW USES INFERIOR PARTS THAT CAUSE CLUTCH FAILURE IN MOST OF THEIR JETTAS. THIS IS A BIG CONCERN. VW PUTS THE BLAME ON THE DRIVER, BUT REFUSES TO ACKNOWLEDGE FAULTY PARTS. CHECK OUT WWW.MYVWLEMON.COM. *JB
NHTSA ODI #10107618
34,600 miles · Aug 10, 2004
Power Train
2001 JETTA 1.8T CLUTCH BEGAN SLIPPING AT 34,600 MILES. THE DEALER SAID THAT THE FRICTION MATERIAL WAS ALMOST COMPLETELY WORN OFF OF THE CLUTCH DISC, MOST LIKELY DUE TO THE WAY THAT IT HAS BEEN DRIVEN. WE HAVE DRIVEN OVER 80K MILES IN ANOTHER MANUAL VEHICLE WITH NO PROBLEMS, SO I DO NOT BELIEVE THIS RATIONALE. THE CAR WENT IN …
Read full complaint
2001 JETTA 1.8T CLUTCH BEGAN SLIPPING AT 34,600 MILES. THE DEALER SAID THAT THE FRICTION MATERIAL WAS ALMOST COMPLETELY WORN OFF OF THE CLUTCH DISC, MOST LIKELY DUE TO THE WAY THAT IT HAS BEEN DRIVEN. WE HAVE DRIVEN OVER 80K MILES IN ANOTHER MANUAL VEHICLE WITH NO PROBLEMS, SO I DO NOT BELIEVE THIS RATIONALE. THE CAR WENT IN FOR SERVICE AT 16,000 MILES FOR A STICKING CLUTCH. THE DEALER DID NOT REPLACE ANY PARTS AT THAT TIME. THE CLUTCH MAY NOT HAVE FULLY ENGAGED EVEN WHEN THE PEDAL FINALLY RELEASED DUE TO FAULTY HYDRAULICS, SO THE CLUTCH PLATE WAS LIKELY WORN PREMATURELY BECAUSE IT WASN'T PROPERLY ENGAGING WITH THE FLYWHEEL. THE DEALER'S REPAIR ESTIMATE WAS $2100, INCLUDING $1200 FOR A REPLACEMENT CLUTCH KIT PLUS 10 HOURS OF LABOR. I THEN CALLED A SECOND LOCAL DEALER AND WAS QUOTED A PRICE OF $753.94 FOR THE SAME CLUTCH KIT. WHEN I DECLINED THE DEALER'S REPAIR, I WAS CHARGED AN $83 DIAGNOSTIC FEE JUST TO GET MY CAR BACK. I THEN SPOKE WITH THE DEALER SERVICE MANAGER AND A VW OF AMERICA REP ABOUT THE CYLINDER PROBLEM AND THE APPARENTLY HIGH RATE OF 1.8T CLUTCH FAILURES. BOTH CLAIMED THAT TOO MANY MILES HAD PASSED SINCE THAT FIRST REPAIR AND REITERATED THAT 1) THE CLUTCH IS A WEAR ITEM ONLY COVERED TO 12,000 MILES BY THE WARRANTY AND 2) I AM RESPONSIBLE FOR THE REPAIR COSTS. AN INDEPENDENT MECHANIC FIXED THE VEHICLE FOR $1038 WITH A NON-OEM CLUTCH KIT. THIS PRICE ALSO INCLUDED NEW MASTER AND SLAVE CYLINDERS, WHICH HE FELT WERE LIKELY THE CAUSE THE ORIGINAL CLUTCH FAILURE. INCIDENTALLY, HE SAID THAT VW'S OWN SERVICE DOCUMENTATION PROVIDED TO MECHANICS INDICATED THAT A CLUTCH OVERHAUL SHOULD TAKE 4-5 HOURS (AS OPPOSED TO THE 10 HOURS QUOTED BY MY DEALER).
NHTSA ODI #10086556
8,000 miles · Jul 12, 2004
Power Train
CONSUMER COMPLAINED ABOUT A TRANSMISSION PROBLEM. TRANSMISSION WAS REPLACED TWICE WITHIN THE PAST 4 YEARS. CHECK ENGINE LIGHT CAME ON EVERY OTHER WEEK. DEALER WAS NOT HELPING WITH THE EXISTING PROBLEM. VEHICLE WAS PURCHASED NEW. BUT, IT WAS ONE ISSUE AFTER ANOTHER, AND VOLKSWAGEN WAS VERY EVASIVE IN RESPONDING TO THE PROBLEM…
Read full complaint
CONSUMER COMPLAINED ABOUT A TRANSMISSION PROBLEM. TRANSMISSION WAS REPLACED TWICE WITHIN THE PAST 4 YEARS. CHECK ENGINE LIGHT CAME ON EVERY OTHER WEEK. DEALER WAS NOT HELPING WITH THE EXISTING PROBLEM. VEHICLE WAS PURCHASED NEW. BUT, IT WAS ONE ISSUE AFTER ANOTHER, AND VOLKSWAGEN WAS VERY EVASIVE IN RESPONDING TO THE PROBLEMS AT HAND. *AK
NHTSA ODI #10081754
32,890 miles · Jul 7, 2004
Power Train
THE CLUTCH ON MY 2001 VW JETTA 1.8T WENT OUT SLL OF A SUDDEN. THE CAR WAS DRIVING COMPLETELY FINE (GEARS WEREN'T STICKY OR CLUTCH LOOSE) AND THEN ALL OF A SUDDEN THE CAR WOULD NOT GO INTO GEAR. I HAD IT TOWED TO THE LOCAL DEALERSHIP WHERE THEY QUOTED $1600 FOR REPAIR (NEW CLUTCH KIT AND FLYWHEEL). I HAD IT TOWED AGAIN TO A VW …
Read full complaint
THE CLUTCH ON MY 2001 VW JETTA 1.8T WENT OUT SLL OF A SUDDEN. THE CAR WAS DRIVING COMPLETELY FINE (GEARS WEREN'T STICKY OR CLUTCH LOOSE) AND THEN ALL OF A SUDDEN THE CAR WOULD NOT GO INTO GEAR. I HAD IT TOWED TO THE LOCAL DEALERSHIP WHERE THEY QUOTED $1600 FOR REPAIR (NEW CLUTCH KIT AND FLYWHEEL). I HAD IT TOWED AGAIN TO A VW SPECIALIST AND HE SAID THE CLUTCHES ON THE NEW VW'S SHOULD LAST AT LEAST 100,000 (AND THAT IS FOR SOMEONE WHO EVEN RIDES THE CLUTCH, HE SAID IT SHOULD LAST EVEN LONGER). VW REFUSED TO PAY FOR THE REPAIRS (EVEN THOUGH I HAVE A WARRANTTY UNTIL 48,000 MILES) SAYING IT WAS DUE TO NORMAL WEAR AND TEAR. MY JETTA ONLY HAS 32,000 MILES. SO, WE HAD TO COVER THE REPAIRS OUT OF POCKET. *AK
NHTSA ODI #10080547
Official recalls
6Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
Illustration