NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
62 reportsClear category filter1,000 miles · Apr 4, 2007
Power TrainService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT REPORTED TRANSMISSION FAILURE ON THE VEHICLE. THE DEALER REMEDIED THE TRANSMISSION FAILURE AND ONE MONTH LATER, THE PROBLEM RECURRED. THE CONTACT STATED THAT THE EPC LIGHTS BEGAN TO MALFUNCTION. WHEN THE LIGHTS ILLUMINATED THE CURRENT SPEED IN WHICH THE CONTACT WAS D…
Read full complaint
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT REPORTED TRANSMISSION FAILURE ON THE VEHICLE. THE DEALER REMEDIED THE TRANSMISSION FAILURE AND ONE MONTH LATER, THE PROBLEM RECURRED. THE CONTACT STATED THAT THE EPC LIGHTS BEGAN TO MALFUNCTION. WHEN THE LIGHTS ILLUMINATED THE CURRENT SPEED IN WHICH THE CONTACT WAS DRIVING, REDUCED DRASTICALLY. THE INDICATOR ILLUMINATED INTERMITTENTLY WHILE DRIVING TO THE DEALER. THE DEALER DIAGNOSED THE FAILURE AS BAD WIRING AND PERFORMED THE REMEDY, BUT THE FAILURE CONTINUES TO PERSIST. THE CONTACT THEN STATED FAILURE WITH THE BRAKE PEDAL SWITCH, HOWEVER IT WAS UNABLE TO BE DUPLICATED BY THE DEALER. THE BRAKE PEDAL SWITCH FAILURE ALSO CONTINUED TO PERSIST. THE CURRENT MILEAGE IS 52,908 , AND FAILURE MILEAGE WAS 1,000.AK
NHTSA ODI #10187017
56,017 miles · Feb 17, 2007
Power Train
FAULTY TRANSMISSION CONTROL MODULE CAUSED TRANSMISSION TO FAIL. CONSEQUENCE: QUOTE OF $5135 FOR THE REPAIR. CAR WAS 6000 MILES OVER WARRANTY. *JB
NHTSA ODI #10182848
66,500 miles · Jun 21, 2006
Power Train
WHILE DRIVING IN SLOW ROAD REPAIR TRAFFIC ON I90 NEAR KIRTLAND/MENTOR OHIO, MY CLUTCH SYSTEM FAILED. WAS DRIVING JUST FINE KEEPING CAR IN 1ST GEAR AND AT A STOP IN STOP AND GO TRAFFIC WHEN SUDDENLY THE CAR WAS STAYING IN GEAR EVEN WHEN REMOVING FOOT FROM CLUTCH PEDAL. CLUTCH PEDAL WAS STUCK IN FULL DOWN POSITION. -- COULD NOT EA…
Read full complaint
WHILE DRIVING IN SLOW ROAD REPAIR TRAFFIC ON I90 NEAR KIRTLAND/MENTOR OHIO, MY CLUTCH SYSTEM FAILED. WAS DRIVING JUST FINE KEEPING CAR IN 1ST GEAR AND AT A STOP IN STOP AND GO TRAFFIC WHEN SUDDENLY THE CAR WAS STAYING IN GEAR EVEN WHEN REMOVING FOOT FROM CLUTCH PEDAL. CLUTCH PEDAL WAS STUCK IN FULL DOWN POSITION. -- COULD NOT EASILY SHIFT GEARS OR GET CAR OUT OF GEAR ONCE THIS PROBLEM OCCURRED, AND WAS FORCED TO KEEP STARTING AND SHUTTING OFF THE ENGINE FOR APPROX. 2 MILES UNTIL I COULD EXIT. MY CAR HAD TO BE TOWED TO CLASSIC VW ON TYLER BLVD IN MENTOR. HAVE BEEN TOLD IT IS THE CLUTCH MASTER AND SLAVE CYLINDERS MUST BE REPLACED AND THEN THE BRAKE LINES MUST BE BLED AND REFILLED. REPAIR COSTS WILL BE BETWEEN $700 AND $1000. *NM
NHTSA ODI #10160323
54,600 miles · Jan 27, 2006
Power Train
I HAVE A 2001 VOLKSWAGEN (VW) JETTA . THE VIN IS[XXX]. VEHICLE HAS 54,953 MILES ON IT AND YESTERDAY I HAD TO HAVE THE SHIFT LOCK SOLENOID REPLACED. SOMETIMES AFTER DRIVING IF YOU WOULD TAKE THE VEHICLE OUT OF DRIVE AND PUT IT IN PARK OR ANOTHER GEAR IT WOULD GET STUCK IN THAT GEAR. I JUST WANTED TO LET YOU KNOW SINCE I FEEL THI…
Read full complaint
I HAVE A 2001 VOLKSWAGEN (VW) JETTA . THE VIN IS[XXX]. VEHICLE HAS 54,953 MILES ON IT AND YESTERDAY I HAD TO HAVE THE SHIFT LOCK SOLENOID REPLACED. SOMETIMES AFTER DRIVING IF YOU WOULD TAKE THE VEHICLE OUT OF DRIVE AND PUT IT IN PARK OR ANOTHER GEAR IT WOULD GET STUCK IN THAT GEAR. I JUST WANTED TO LET YOU KNOW SINCE I FEEL THIS COULD POSSIBLY BE A MAJOR CONCERN.*AK UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10148844
30,000 miles · Dec 16, 2005
Power Train
THE CLUTCH OF MY 2001 JETTA (1.8 LITER TURBO MANUAL 5-SPEED) STARTED GOING OUT LAST JULY, WHEN THE CAR WAS NOT EVEN 4 YEARS OLD AND HAD ONLY 30K MILES. (I AM THE ORIGINAL OWNER.) IT IS GETTING WORSE. TWICE NOW I'VE TAKEN IT TO MY VW SERVICE DEALER ONLY TO BE MET BY BAFFLED STARES. THE VW MECHANICS THERE KEEP SAYING THAT THE CLUT…
Read full complaint
THE CLUTCH OF MY 2001 JETTA (1.8 LITER TURBO MANUAL 5-SPEED) STARTED GOING OUT LAST JULY, WHEN THE CAR WAS NOT EVEN 4 YEARS OLD AND HAD ONLY 30K MILES. (I AM THE ORIGINAL OWNER.) IT IS GETTING WORSE. TWICE NOW I'VE TAKEN IT TO MY VW SERVICE DEALER ONLY TO BE MET BY BAFFLED STARES. THE VW MECHANICS THERE KEEP SAYING THAT THE CLUTCHES ON THESE CARS ARE FINE, AND THAT NOTHING IS WRONG WITH THE CAR. BUT TONIGHT I DID AN INTERNET SEARCH AND FOUND THAT THERE IS A TERRIBLE PATTERN OF BAD CLUTCHES ON THE JETTAS, ESPECIALLY THE 2001 1.8 TURBOS, WITH EXACTLY THESE SAME SYMPTOMS! HOW ABOUT A RECALL? IN THE MEANTIME, CAN YOU PLEASE HELP ME GET THEM TO DO SOMETHING ABOUT MY CAR? MY CHILD AND I I COULD HAVE BEEN KILLED WHEN THE CLUTCH FAILED THIS MORNING ON A CROWDED, FAST-MOVING FREEWAY! THANK YOU, CELESTE WISER, M.D. *JB
NHTSA ODI #10145427
23,000 miles · Aug 24, 2005
Power Train
(1) NORMAL DRIVING, REGULAR SCHEDULED DEALER MAINTAINANCE BEFORE THE FAILURE OF THE CLUTCH. THE MANUAL TRANSMISSION BECAME DIFFICULT TO PUT INTO GEAR AND NOISE STARTED TO COME FROM THE ENGINE COMPARTMENT. (2) CLUTCH FAILED AND IT BECAME VERY DIFFICULT TO ENGAGE TRANSMISSION. DEALER SERVICE ADVISOR RECOMMENDED LOOKING AT TRANSMIS…
Read full complaint
(1) NORMAL DRIVING, REGULAR SCHEDULED DEALER MAINTAINANCE BEFORE THE FAILURE OF THE CLUTCH. THE MANUAL TRANSMISSION BECAME DIFFICULT TO PUT INTO GEAR AND NOISE STARTED TO COME FROM THE ENGINE COMPARTMENT. (2) CLUTCH FAILED AND IT BECAME VERY DIFFICULT TO ENGAGE TRANSMISSION. DEALER SERVICE ADVISOR RECOMMENDED LOOKING AT TRANSMISSION AND THEN DISCOVERED THAT THE CLUTCH HAD FAILED. IMMEDIATE DIAGNOSIS WAS THAT IT WAS DRIVER ERROR. LATER THAT DAY, AFTER EXAMINING THE PARTS THAT WERE REMOVED FROM THE CAR IT WAS REVEALED THAT THE SPRINGS OF THE CLUTCH PLATE HAD COME OUT OF THE METAL BRACKETS OF THE CLUTCH. DEALER CLAIMED THEY HAD ONLY SEEN THAT AS A RESULT OF MISUSE BUT DECIDED TO PARTIALLY WARRANTY THE PARTS AFTER DETERMINING THAT I HAD TAKEN EXCELLENT CARE OF THE CAR AND HAD EXHIBITED NO ABUSE OF THE VEHICLE. THIS FIRST INCIDENT TOOK PLACE WHEN THE CAR HAD 23K MILES ON THE ODOMETER AND I HAD OWNED THE VEHICLE SINCE IT WAS NEW. THE SECOND FAILURE WAS AT 73 K MILES IN MARCH OF 2005. THE SAME PARTS FAILED AND THE SAME DIAGNOSIS WAS MADE BY A DIFFERENT VW DEALERSHIP. THE CLUTCH FAILED IN THE SPRINGS BUT SHOWED NO OUTWARD SIGNS OF ABUSE OR EXCESSIVE WEAR. THE CLUTCH HAD APPROXIMATELY 50 K MILES OF USE BUT STILL HAD SIGNIFICANT MATERIAL LEFT ON THE CLUTCH PADS. THE FAILURE OF THE CLUTCH SPRINGS DAMAGED THE FLYWHEEL. AS RESULT I HAD TO PAY FOR A NEW FLYWHELEL, THROWOUT BEARING AND CLUTCH PLATE. AN APPEAL TO VW WAS REJECTED AND THEY SAID THAT THE DECISION WAS THE DEALERSHIP'S AND THAT THEY WOULD STAND BY THAT. I CONSIDER THIESE FAILURES TO BE CAUSED BY WEAK PARTS PROVIDED BY VW OF AMERICA. THIS SECOND FAILURE COST ME $1600.00 IN REPAIR COSTS.
NHTSA ODI #10134119
Mileage unknown · Aug 3, 2005
Electrical SystemExterior LightingPower Train
EARLIER THIS YEAR, THERE WAS A RECALL FOR THE BRAKE LIGHT SWITCH ON MY 2001 VW JETTA. THE DEALERSHIP REPLACED THIS. HOWEVER, WITHIN THE LAST MONTH, THE AUTOMATIC SHIFT LOCK (ASL) HAS NOT ALLOWED ME TO SHIFT OUT OF PARK ON NUMEROUS OCCASIONS. USUALLY, I AM ABLE TO WAIT A MINUTE AND THE ASL LIGHT WILL GO OFF, OR I TURN OFF THE …
Read full complaint
EARLIER THIS YEAR, THERE WAS A RECALL FOR THE BRAKE LIGHT SWITCH ON MY 2001 VW JETTA. THE DEALERSHIP REPLACED THIS. HOWEVER, WITHIN THE LAST MONTH, THE AUTOMATIC SHIFT LOCK (ASL) HAS NOT ALLOWED ME TO SHIFT OUT OF PARK ON NUMEROUS OCCASIONS. USUALLY, I AM ABLE TO WAIT A MINUTE AND THE ASL LIGHT WILL GO OFF, OR I TURN OFF THE CAR OR FIDDLE WITH THE STEERING WHEEL. HOWEVER, THREE TIMES THIS PAST WEEK I HAVE GOTTEN STUCK AND HAVE HAD TO ABANDON THE CAR TEMPORARILY. THE LAST TIME, I WAS FINALLY ABLE TO GET IT OUT OF PARK AND DRIVE IT TO MY LOCAL MECHANIC (I HAD AN APPOINTMENT WITH MY DEALERSHIP, BUT I COULDN'T GET IN FOR A WEEK). HE NOTICED THAT MY BRAKE LIGHTS WERE OUT AGAIN, AND BELIEVES THAT THE BRAKE LIGHT MALFUNCTION MAY BE RELATED TO THE ASL MALFUNCTION. THIS MAY EXPLAIN WHY THE ELECTRONIC POWER CONTROL (EPC) LIGHT TURNS ON WHENEVER THE ASL LIGHT TURNS ON, AS IT INDICATES A PROBLEM IN THE ELECTRONICS. THE LOCAL MECHANIC IS CURRENTLY EXAMINING THE PROBLEM. *JB
NHTSA ODI #10131230
78,965 miles · Aug 1, 2005
Power Train
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT *JB TRANSMISSION PROBLEM. TRANSMISSION WILL NOT GO INTO REVERSE. ALSO, CONSUMER WAS TOLD THAT THERE WAS A PROBLEM WITH THE BRAKE LIGHT.*AK WATER INTRUSION FROM THE DRIVER'S SIDE OF THE VEHICLE LEAVING 1/2" OF WATER ON FLOORBOARD. THIS CONDITION RESULTS IN S…
Read full complaint
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT *JB TRANSMISSION PROBLEM. TRANSMISSION WILL NOT GO INTO REVERSE. ALSO, CONSUMER WAS TOLD THAT THERE WAS A PROBLEM WITH THE BRAKE LIGHT.*AK WATER INTRUSION FROM THE DRIVER'S SIDE OF THE VEHICLE LEAVING 1/2" OF WATER ON FLOORBOARD. THIS CONDITION RESULTS IN SLIPPERY PEDALS AND WINDOWS FOGGING UP. NOTHING HAS BEEN DONE TO CORRECT THE PROBLEM..
NHTSA ODI #10130744
30,000 miles · Jul 15, 2005
Power Train
DT: WHEN THE CONSUMER WOULD START HER CAR AND TRY TO PUT IT IN GEAR, IT WOULD NOT COME OUT OF PARK. THIS HAPPENED WITHOUT WARNING. THE DEALER FIXED IT. THE CONSUMER WAS AT DEALER BECAUSE OF A RECALL AND HAD THEM LOOK AT THIS AT THE SAME TIME. *JB THE CONSUMER WITNESSED ANOTHER MAKE/MODEL VEHICLE WITH A SIMILAR PROBLEM WHI…
Read full complaint
DT: WHEN THE CONSUMER WOULD START HER CAR AND TRY TO PUT IT IN GEAR, IT WOULD NOT COME OUT OF PARK. THIS HAPPENED WITHOUT WARNING. THE DEALER FIXED IT. THE CONSUMER WAS AT DEALER BECAUSE OF A RECALL AND HAD THEM LOOK AT THIS AT THE SAME TIME. *JB THE CONSUMER WITNESSED ANOTHER MAKE/MODEL VEHICLE WITH A SIMILAR PROBLEM WHILE AT THE DEALER. *SC
NHTSA ODI #10126334
50,000 miles · Jul 13, 2005
Power Train
THE CLUTCH ON MY 2001 VW JETTA HAS TO BE REPLACED AFTER ONLY 50,000 MILES. AFTER DOIN G RESEARCH ON THE INTERNET I REALIZED THAT I AM NOT THE ONLY VICTIM OF THIS PROBLEM. THE COST FOR THIS REPAIR IS OVER $1000(FOR A CLUTCH).
NHTSA ODI #10128587
Official recalls
6Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
Illustration