NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
117 reportsClear category filter102,000 miles · Jul 22, 2009
Electrical SystemFire
SLIGHT SMELL OF SMOKE IN 2001 VW JETTA WHILE DRIVING. PARKED CAR AT HOME AND RETURNED TO CAR APROX. 30 MINUTES LATER TO FIND CABIN FULL OF SMOKE/SMOLDERING FROM AREA BEHIND RIGHT REAR SEAT. DISCONNECTED BATTERY POSITIVE TERMINAL AND PUT WATER ON SMOLDERING AREA TO EXTINGUISH FIRE. 8-10 INCH HOLE BURNED COMPLETELY THROUGH RIGHT S…
Read full complaint
SLIGHT SMELL OF SMOKE IN 2001 VW JETTA WHILE DRIVING. PARKED CAR AT HOME AND RETURNED TO CAR APROX. 30 MINUTES LATER TO FIND CABIN FULL OF SMOKE/SMOLDERING FROM AREA BEHIND RIGHT REAR SEAT. DISCONNECTED BATTERY POSITIVE TERMINAL AND PUT WATER ON SMOLDERING AREA TO EXTINGUISH FIRE. 8-10 INCH HOLE BURNED COMPLETELY THROUGH RIGHT SIDE OF REAR DECK. UPON MY INITIAL INSPECTION IT APPEARS TO HAVE INITIATED FROM THE CENTER BRAKE LIGHT WIRING. *TR
NHTSA ODI #10277892
Mileage unknown · Mar 10, 2009
Electrical System
THERE WERE NO EVENTS LEADING UP TO THE FAILURE. THE EPC LIGHT COMES ON SPORADICALLY, THUS MAKING YOU LOSE POWER IN THE MIDDLE OF TRAFFIC. IT IS VERY SCARY WHEN YOU HAVE NO POWER IN RUSH HOUR TRAFFIC AND YOU HAVE TO PULL THE CAR OVER AND RESTART HOPING THE LIGHT WILL GO OFF UNTIL YOU CAN GET TO YOUR DESTINATION. THE CHECK ENGI…
Read full complaint
THERE WERE NO EVENTS LEADING UP TO THE FAILURE. THE EPC LIGHT COMES ON SPORADICALLY, THUS MAKING YOU LOSE POWER IN THE MIDDLE OF TRAFFIC. IT IS VERY SCARY WHEN YOU HAVE NO POWER IN RUSH HOUR TRAFFIC AND YOU HAVE TO PULL THE CAR OVER AND RESTART HOPING THE LIGHT WILL GO OFF UNTIL YOU CAN GET TO YOUR DESTINATION. THE CHECK ENGINE LIGHT STAYS ON ALL THE TIME FOR APPARENTLY NO REASON. WE HAVE HAD IT DIAGNOSED BUT WITH NO RESULTS. HELP!! *TR
NHTSA ODI #10261398
40,000 miles · Nov 3, 2008
Electrical SystemEngine And Engine Cooling
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT STARTED THE IGNITION AND THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATOR REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TEN TIMES AND THEY STATED THAT THE FAILURE WAS RELATED TO THE …
Read full complaint
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT STARTED THE IGNITION AND THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATOR REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TEN TIMES AND THEY STATED THAT THE FAILURE WAS RELATED TO THE AIR FILTER SENSOR. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 42,000.
NHTSA ODI #10247580
87,000 miles · Jul 30, 2008
Electrical System
2001 VW JETTA EPC LIGHT COMES ON ALOT. THIS SHOULD BE RECALLED BY THE MANUFACTURER. CAR SLOWS DOWN TO 20 MPH OR LESS. HAVE SEEN COMPLAINTS THAT THE CAR COMPLETELY SHUTS DOWN. THIS IS UNSAFE OR MYSELF AND MY 2 SMALL CHILDREN. *TR
NHTSA ODI #10236458
Mileage unknown · Jun 18, 2008
Electrical SystemEngine And Engine CoolingEquipment
I OWN A 2001 VW JETTA GLS VR6. SINCE I HAVE OWNED THIS CAR I HAVE HAD PROBLEMS WITH IT. I AM A YOUNG WOMAN IN THE MILITARY AND AM IN FULL TIME SCHOOL, SO I DON'T HAVE THE MONEY TO RUN AROUND AND FIX IT AS MUCH AS I HAVE BEEN FORCED TO DO. FIRST MY GAS GAUGE WENT OUT THREE MONTHS AFTER BUYING IT $600(UNDER WARRANTY) THEN A MONTH …
Read full complaint
I OWN A 2001 VW JETTA GLS VR6. SINCE I HAVE OWNED THIS CAR I HAVE HAD PROBLEMS WITH IT. I AM A YOUNG WOMAN IN THE MILITARY AND AM IN FULL TIME SCHOOL, SO I DON'T HAVE THE MONEY TO RUN AROUND AND FIX IT AS MUCH AS I HAVE BEEN FORCED TO DO. FIRST MY GAS GAUGE WENT OUT THREE MONTHS AFTER BUYING IT $600(UNDER WARRANTY) THEN A MONTH LATER O2 SENSOR $300(NON WARRANTY). THEN IT WAS THE CATALYTIC CONVERTER$1500(NON WARRANTY) WIRING SYSTEM$1000(OF COURSE NON WARRANTY) WINDOWS WONT ROLL UP WITHOUT ROLLING DOWN AGAIN AND SOMETIMES GET STUCK$700(NON WARRANTY) CRUISE CONTROL WENT OUT$845 (NON WARRANTY), WINDSHIELD WIPER MOTOR... STATIONED IN ALASKA AND COULDN'T GO WITHOUT THAT $750(NON WARRANTY) NOW MY SECONDARY AIR PUMP IS OUT AND I WAS QUOTED $1294 FROM PRIVATE MECHANIC AND $1400 FROM VW. ALSO THE CRUISE IS STILL OUT AND THE WINDOWS ARE DOING THE SAME AGAIN. I HAVE TALKED TO MANY PEOPLE IN THE SAME BOAT I HAVE BEEN IN WITH SO MANY REPAIRS. IS THERE ANYTHING THAT CAN BE DONE TO STOP VW FROM MAKING FAULTY PARTS AND CHARGING AN ARM AND A LEG? I FEEL THOUGH THAT IF IT IS BROUGHT UP TO YOU THAT MY VOICE WILL BE HEARD, BECAUSE WHEN I CALL THE VOLKWAGEN CUSTOMER SERVICE AND COMPLAINTS I GET NOWHERE. *TR
NHTSA ODI #10231433
Mileage unknown · Mar 9, 2008
Electrical SystemExterior LightingLatches/locks/linkages
NUMEROUS PROBLEMS WITH 2001 VW JETTA, PURCHASED NEW IN JUNE, 2001.INCLUDING : WINDOWS SPORADICALLY MALFUNCTIONING (WHEN I CALLED VW CORPORATE AS WELL AS MY LOCAL DEALER, I WAS TOLD THAT AFTER THE DEALER EVALUATED PROBLEM I COULD BE RESPONSIBLE FOR THE LABOR CHARGE DEPENDING ON THE OUTCOME OF THEIR DIAGNOSIS!!); TRUNK LATCH HAS B…
Read full complaint
NUMEROUS PROBLEMS WITH 2001 VW JETTA, PURCHASED NEW IN JUNE, 2001.INCLUDING : WINDOWS SPORADICALLY MALFUNCTIONING (WHEN I CALLED VW CORPORATE AS WELL AS MY LOCAL DEALER, I WAS TOLD THAT AFTER THE DEALER EVALUATED PROBLEM I COULD BE RESPONSIBLE FOR THE LABOR CHARGE DEPENDING ON THE OUTCOME OF THEIR DIAGNOSIS!!); TRUNK LATCH HAS BEEN REPLACED ONCE (OUT OF WARRANTY) AND NOW LATCH DOES NOT RESPOND TO REMOTES NOR TO THE INSIDE RELEASE ON DRIVER DOOR; DRIVER DOOR LOCK DOES NOT RESPOND TO REMOTES NOR TO CONTROL ON DRIVER DOOR (THE OTHER THREE DOOR LOCKS ARE PRESENTLY FUNCTIONING); INTERIOR COATING ON PLASTIC DOOR HANDLES AND CENTER CONSOLE BEGAN TO PEEL WITHIN SIX MONTHS OF DELIVERY; CENTER CONSOLE LATCH BROKE LONG AGO; CHECK ENGINE LIGHT COMES ON/OFF SPORADICALLY (BROUGHT CAR TO CERTIFIED MECHANIC BUT PROBLEM UNDIAGNOSED); A WAX SUBSTANCE WAS CONSTANTLY RUNNING INTO DOORWELLS; VW DEALER REPLACED COIL, CABLES AND BUFFER IN RESPONSE TO ROUGH ENGINE IDLE COMPLAINT AND I INCURRED ALL COSTS AND INCONVENIENCE OF CAR IN SHOP , THIS AT 72,000 MILES,HAZARD LIGHTS MALFUNCTIONED; TURN SIGNALS MALFUNCTIONED; NOW I HEAR OF A BRAKE LIGHT RECALL AND AN EMERGENCY LIGHT SWITCH PROBLEM. I AM JUST REALIZING RECENTLY THAT I AM NOT ALONE WITH MY JETTA PROBLEMS, THAT NUMEROUS JJETTA OWNERS ARE HAVING THE SAME PROBLEMS ( I RESEARCHED ON INTERNET) . VW CUSTOMER SERVICE NOT HELPFUL AT ALL IN RESOLVING THESE PROBLEMS. *TR
NHTSA ODI #10220476
Mileage unknown · Mar 2, 2008
Electrical SystemExterior Lighting
MY BRAKE LIGHTS ARE CONSTANTLY GOING OUT. I WILL REPLACE THE LEFT AND THEN A MONTH OR SO LATER I HAVE TO REPLACE THE RIGHT, OR THE CENTER BRAKE LIGHT OR THE LICENSE PLATE LIGHT. I AM REPLACING ABOUT 4-5 LIGHTS PER YEAR ON THE REAR OF THE VEHICLE. *TR ALSO NUMEROUS ELECTRICAL PROBLEMS. 1/2 OF THE INTERIOR LIGHTS ARE NO LONGER W…
Read full complaint
MY BRAKE LIGHTS ARE CONSTANTLY GOING OUT. I WILL REPLACE THE LEFT AND THEN A MONTH OR SO LATER I HAVE TO REPLACE THE RIGHT, OR THE CENTER BRAKE LIGHT OR THE LICENSE PLATE LIGHT. I AM REPLACING ABOUT 4-5 LIGHTS PER YEAR ON THE REAR OF THE VEHICLE. *TR ALSO NUMEROUS ELECTRICAL PROBLEMS. 1/2 OF THE INTERIOR LIGHTS ARE NO LONGER WORKING, AND WHEN I UNLOCK THE CAR IT WILL AUTOMATICALLY LOCK ON ME WITHIN 15 SECONDS UNLESS I START THE ENGINE.
NHTSA ODI #10219834
40,130 miles · Feb 6, 2008
Electrical System
UPON STARTING THE CAR, IT IDLED LOUDLY AND ROUGHLY. AFTER DRIVING FOR 2 MINUTES THE CAR BEGAN TO BUCK (AS IF THERE WERE MULTIPLE MINI STALLS WHILE DRIVING). WHEN THIS BUCKING/BUMPING BEGAN THE CHECK ENGINE LIGHT BEGAN TO FLASH. THE CAR WAS THEN DRIVEN TO A CAR DEALERSHIP SERVICE REPAIR SHOP WHERE IT WAS DETERMINED THAT THE IGN…
Read full complaint
UPON STARTING THE CAR, IT IDLED LOUDLY AND ROUGHLY. AFTER DRIVING FOR 2 MINUTES THE CAR BEGAN TO BUCK (AS IF THERE WERE MULTIPLE MINI STALLS WHILE DRIVING). WHEN THIS BUCKING/BUMPING BEGAN THE CHECK ENGINE LIGHT BEGAN TO FLASH. THE CAR WAS THEN DRIVEN TO A CAR DEALERSHIP SERVICE REPAIR SHOP WHERE IT WAS DETERMINED THAT THE IGNITION COIL HAD FAILED. THE OWNER, DESPITE TAKING VERY GOOD CARE OF THE CAR, WILL HAVE TO PAY TO GET THIS PART REPLACED. *TR
NHTSA ODI #10217134
97,000 miles · Jan 10, 2008
Electrical SystemFire
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT NOTICED SMOKE RISING FROM THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER IN NOVEMBER OF 2007, WHERE IT PRESENTLY REMAINS. THE CLOCK SPRING WAS REPLACED. THE MOST RECENT DIAGNOSTIC INDICATED THAT THE PRIMARY FAILURE WAS THE WIRING HARNESS AND WOULD COST $2,300 TO RE…
Read full complaint
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT NOTICED SMOKE RISING FROM THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER IN NOVEMBER OF 2007, WHERE IT PRESENTLY REMAINS. THE CLOCK SPRING WAS REPLACED. THE MOST RECENT DIAGNOSTIC INDICATED THAT THE PRIMARY FAILURE WAS THE WIRING HARNESS AND WOULD COST $2,300 TO REPLACE. THE MANUFACTURER WAS UNABLE TO ASSIST. THE CURRENT AND FAILURE MILEAGES WERE 97,000. THE CONSUMER STATED TOOK THE VEHICLE TO A PRIVATE MECHANIC GERMAN AUTO REPAIR AND THE VEHICLE WAS REPAIRED AT THE TUNE OF $1896 + $300 DEDUCTIBLE. UPDATED 03/07/08 *TR
NHTSA ODI #10214441
46,391 miles · Oct 17, 2007
Electrical System
MY COMPLAINT INVOLVES TWO SEPARATE INCIDENTS WHERE I EXPERIENCED JERKING AND SPUTTERING FROM MY 2001 VW JETTA GLX VR6. IN BOTH INCIDENTS, FOLLOWING THE REDUCED LEVEL OF ENGINE POWER I SMELLED A BURNING AND WAS FORCED TO STOP THE CAR. BOTH TIMES, MY CAR WAS BROUGHT IN FOR INSPECTION AND REPAIR TO TWO DIFFERENT VW DEALERSHIPS. …
Read full complaint
MY COMPLAINT INVOLVES TWO SEPARATE INCIDENTS WHERE I EXPERIENCED JERKING AND SPUTTERING FROM MY 2001 VW JETTA GLX VR6. IN BOTH INCIDENTS, FOLLOWING THE REDUCED LEVEL OF ENGINE POWER I SMELLED A BURNING AND WAS FORCED TO STOP THE CAR. BOTH TIMES, MY CAR WAS BROUGHT IN FOR INSPECTION AND REPAIR TO TWO DIFFERENT VW DEALERSHIPS. EACH TIME, I WAS ADVISED THAT THE VW IGNITION COIL PACK HAD MALFUNCTIONED AND HAD TO BE REPLACED. APPARENTLY, THE MALFUNCTION OF THIS PART CAUSED OTHER SENSORS TO MALFUNCTION AS WELL. ALSO, THESE PARTS APPEAR TO DAMAGE ENVIRONMENTAL PROTECTION EQUIPMENT. IN ONE INCIDENT DESCRIBED ABOVE, MY CATALYTIC CONVERTER HAD TO EVENTUALLY BE REPLACED. NOTE THAT THE FIRST INCIDENT, WHICH IS DOCUMENTED, OCCURRED AT 34,560 MILES. THE SECOND INCIDENT, WHICH WAS VERY SIMILAR TO THE FIRST, OCCURRED AT 46,391 MILES AND IS ALSO FULLY DOCUMENTED. THE MATTER WAS REPORTED TO VWOA AND I WAS INFORMED THAT ANY PORTION OF THE NEARLY $2,000 I INCURRED OUT-OF-POCKET WOULD NOT BE REIMBURSED AND THERE SEEMED TO BE NO CONCERN BY VWOA REPRESENTATIVES REGARDING ANY DAMAGE TO EMISSIONS DEVICES AND/OR POTENTIAL FIRE HAZARDS, I BELIEVE EXIST DUE TO THE MALFUNCTIONING OF THE IGNITION COIL PACK. VWOA, IN MY OPINION, IS WELL AWARE OF THE MANY (POSSIBLY THOUSANDS) OF SIMILAR INCIDENTS ACROSS THE US AND STILL SEEK TO MARGINALIZE IT. *JB
NHTSA ODI #10206128
Official recalls
6Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
Illustration