AIRBAG CONTROL MODULE FAILURE WITHOUT WARNING. I NOTICED THE RED LIGHT FOR THE AIRBAG DID NOT GO OFF (NOT NOTICEABLE IN DAYLIGHT) THIS COULD BE A SIGNIFICANT PUBLIC SAFETY ISSUE. THE CAR ONLY HAS 92K MILES. THE WARNING LIGHT IS VIRTUALLY IMPOSSIBLE TO SEE IN BRIGHT DAYLIGHT. IF IT FAILS IN THE MIDDLE OF A JOURNEY THERE IS NO…
Read full complaint
AIRBAG CONTROL MODULE FAILURE WITHOUT WARNING. I NOTICED THE RED LIGHT FOR THE AIRBAG DID NOT GO OFF (NOT NOTICEABLE IN DAYLIGHT) THIS COULD BE A SIGNIFICANT PUBLIC SAFETY ISSUE. THE CAR ONLY HAS 92K MILES. THE WARNING LIGHT IS VIRTUALLY IMPOSSIBLE TO SEE IN BRIGHT DAYLIGHT. IF IT FAILS IN THE MIDDLE OF A JOURNEY THERE IS NO WARNING SOUND.... CONSUMERS CAN BE KILLED OR MAIMED IF AN ACCIDENT OCCURS WITHOUT REALIZING THIS PART HAS STOPPED FUNCTIONING, DRIVERS MAY GET A FALSE SENSE OF SECURITY. I TOOK THE CAR TO A VW DEALER WAS TOLD THAT THE CONTROL MODULE FOR THE AIRBAG HAD STOPPED WORKING. WE, (MY HUSBAND AND I), CALLED VW OF AMERICA, BUT WAS TOLD THAT BECAUSE THE CAR WAS 1. OUT OF WARRANTY, 2. 'OLD' (13 YRS) AND 3. 92, 000 MILES THAT THERE WAS NOTHING THAT WOULD BE DONE TO RECTIFY THE ISSUE. WE DISAGREED; THIS IS NOT A PART THAT SHOULD WEAR OUT, ESPECIALLY IF THE CAR HAS NEVER BEEN IN AN ACCIDENT. IT'S NOT THE SAME AS ENGINE PARTS, TIRES, BODY, ETC. THAT SHOULD BE EXPECTED TO WEAR AFTER TIME AND MILEAGE. THEIR CUSTOMER SERVICE REPRESENTATIVE SEEMED ONLY CONCERNED ABOUT IT IF THE CAR IS WITHIN THE WARRANTY PERIOD. I AM SUPPOSED TO GET BACK TO DEALER WITH A DECISION TO REPLACE THE MODULE. *JB
NHTSA ODI #10184488
Mileage unknown · Mar 15, 2002
Air BagsInjury
AIR BAGS INFLATED LEAVING A POWDERY RESIDUE ON EVERYTHING INSIDE VEHICLE. CONSUMERS MOTHER HAD A SEVERE ALLERGIC REACTION TO THE RESIDUE. CONSUMER WOULD LIKE TO SEE WARNINGS FOR PEOPLE WHO ARE ALLERGIC TO THE AIR BAG RESIDUE. *JG
NHTSA ODI #564720
Mileage unknown · Feb 28, 1996
Air BagsParking BrakeCrash
BRAKES LOCKED UP DUE TO PARKING BRAKE MALFUNCTION, CAUSING ACCIDENT/INJURIES. *DSH
NHTSA ODI #502066
Mileage unknown · Jan 9, 1995
Air BagsCrashInjury
DRIVER'S AIRBAG DEPLOYMENT WAS VIOLENT DURING ACCIDENT, CAUSING BURNS. *SKD
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR BRAKE LINE ON THE PASSENGER SIDE WAS ROUTED TOO CLOSE TO THE CORNER OF THE FUEL TANK. THE LINE COULD BE DAMAGED BY CHAFING AGAINST THE FUEL TANK.
Consequence & remedy
Consequence: REPEATED CHAFING COULD EVENTUALLY RESULT IN A LEAKING BRAKE LINE CAUSING DIMINISHED BRAKING IN ONE BRAKE CIRCUIT INCREASING THE VEHICLE'S STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE ANY DAMAGED LINES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BOLTS SECURING THE FRONT HOOD LATCH CAN LOOSEN OVER TIME. THE LATCH WOULD MOVE CAUSING DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH.
Consequence & remedy
Consequence: UNEXPECTED OPENING OF THE HOOD COULD OCCUR OBSTRUCTING THE DRIVER'S VIEW OF THE ROAD WHILE DRIVING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE HOOD LATCH AND SECURING BOLTS AND REPLACE THEM IF NECESSARY.
THE SHEET METAL PANELS OF BOTH REAR DOORS HAVE OPENINGS FOR THE ROUTING OF THE ELECTRICAL WINDOW REGULATOR WIRING. THE PANEL OPENINGS HAVE SHARP EDGES THAT CAN DAMAGE THE INSULATION OF THE WIRING HARNESS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT IN THE WIRING CAN OCCUR RESULTING IN A POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL A PROTECTIVE EDGE COVER IN BOTH REAR DOOR INNER PANEL OPENINGS.
IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.
Consequence & remedy
Consequence: A WORN AND NOISY FAN MOTOR SHAFT CAN SEIZE RENDERINGTHE FAN MOTOR INOPERATIVE, EVENTUALLY CAUSING THE ENGINE TO OVERHEAT AND STALL. A STALLED VEHICLE IN TRAFFIC CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE COMPLETE COOLING FAN ASSEMBLY ON VEHICLE HAVING THE POTENTIAL SHAFT MATERIAL PROBLEM. DEALERS WILL INSTALL A NEW FAN BLADE INCLUDING A NEW LOCK NUT ON VEHICLE WITH LOOSE FAN BLADE LOCK NUTS.
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence & remedy
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW JACK.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
1994 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration