IllustrationENTIRE SOUND/RADIO SYSTEM SUDDENLY STOPPED THEREBY ELIMINATING MY BLUE TOOTH CONNECTIVITY FOR HANDSFREE PHONE USE
2011 Volkswagen Jetta Sportwagen
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2011 Volkswagen Jetta Sportwagen do not stand out strongly from the model-year median of 27.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta Sportwagen years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
00–25K
225–50K
950–75K
1075–100K
4100–150K
2150K+
27 reports with mileage · 6 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports3 fire reports1 injury reports
What owners actually said
33 reportsTL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA SPORTWAGEN. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND THE GLOW PLUG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO A PARKING LOT AND WAS TOWED TO THE DEALER (JOE HEIDT VOLKSWAGEN, 515 ROUTE 17 SOUTH, RAMSEY, NJ, 201-327-2900) WHERE IT WAS DIAGNOSED THAT TH…
Read full complaint
TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA SPORTWAGEN. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND THE GLOW PLUG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO A PARKING LOT AND WAS TOWED TO THE DEALER (JOE HEIDT VOLKSWAGEN, 515 ROUTE 17 SOUTH, RAMSEY, NJ, 201-327-2900) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP CONTAINED PIECES OF METAL, WHICH CAUSED THE FUEL SYSTEM TO FAIL. ALSO, A DIAGNOSTIC TEST WAS PERFORMED AND THE CONTACT WAS INFORMED THAT THE FUEL WAS BAD. THE FUEL PUMP SYSTEM WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 70,205.
RECENTLY MY 2011 JETTA SPORTWAGEN'S EXTERIOR LIGHT DASHBOARD INDICATOR CAME ON. UPON INVESTIGATION I FOUND THAT THE PASSENGER SIDE EXTERIOR FRONT AND REAR LIGHTS WERE NOT WORKING. INTERMITTENTLY OVER THE NEXT FEW DAYS THEY WOULD WORK AND THEN FAIL AGAIN WITHOUT ANY REASON. I TOOK THE CAR TO THE DEALER AND WAS TOLD I HAD ONE B…
Read full complaint
RECENTLY MY 2011 JETTA SPORTWAGEN'S EXTERIOR LIGHT DASHBOARD INDICATOR CAME ON. UPON INVESTIGATION I FOUND THAT THE PASSENGER SIDE EXTERIOR FRONT AND REAR LIGHTS WERE NOT WORKING. INTERMITTENTLY OVER THE NEXT FEW DAYS THEY WOULD WORK AND THEN FAIL AGAIN WITHOUT ANY REASON. I TOOK THE CAR TO THE DEALER AND WAS TOLD I HAD ONE BULB OUT AND THAT THERE WAS NOTHING WRONG WITH THE CAR. AND THAT THEY HAD NEVER EVER HEARD OF THIS ISSUE IN ANY VOLKSWAGEN. THE SAME DAY THE LIGHTS FAILED AGAIN. I INVESTIGATED THIS TIME MYSELF AND FOUND MULTIPLE COMPLAINTS ABOUT THE F16 FUSE. MY F16 FUSE WAS VISIBLY BURNT AND THE FUSE BOX WAS MELTED AT THE F16 SPOT. A NEW FUSE HAS TEMPORARILY FIXED THE PROBLEM, BUT I AM CONCERNED ABOUT A SAFETY ISSUE IF THIS IS MELTING THE FUSE BOX AND MY LIGHTS COULD FAIL AT A CRITICAL TIME.
WHILE DRIVING ON THE HIGHWAY SEVERAL MESSAGES STARTED TO APPEAR IN REFERENCE TO FAILED LIGHTS. I LOST SIGNAL LIGHTS, HEADLIGHTS AND BRAKE LIGHTS. REPLACING THE LIGHTS DID NOT SOLVE THE PROBLEM. AT THE DEALER THEY TOLD ME THAT THE FUSE BOX WAS BURNED OUT AND NEEDED REPLACEMENT. THIS IS WHAT HAPPENED TO ME WHILE DRIVING THE CAR ON…
Read full complaint
WHILE DRIVING ON THE HIGHWAY SEVERAL MESSAGES STARTED TO APPEAR IN REFERENCE TO FAILED LIGHTS. I LOST SIGNAL LIGHTS, HEADLIGHTS AND BRAKE LIGHTS. REPLACING THE LIGHTS DID NOT SOLVE THE PROBLEM. AT THE DEALER THEY TOLD ME THAT THE FUSE BOX WAS BURNED OUT AND NEEDED REPLACEMENT. THIS IS WHAT HAPPENED TO ME WHILE DRIVING THE CAR ON 3/24/2017.
FOR TWO YEARS PRIOR TO AUGUST 2016, I WENT INTO MY VW DEALER ONCE A MONTH BECAUSE THE CHECK TIRE LIGHT CAME ON. EACH TIME THEY JUST PUT AIR IN THE TIRES AND SAID THERE WAS NO PROBLEM, AND EACH TIME I ASKED THEM TO CHECK THE RIMS. ONCE OR TWICE THEY INSPECTED AND CLEANED THE RIMS AND SAID THERE WAS NO PROBLEM. IN JUNE 2016 I ASKE…
Read full complaint
FOR TWO YEARS PRIOR TO AUGUST 2016, I WENT INTO MY VW DEALER ONCE A MONTH BECAUSE THE CHECK TIRE LIGHT CAME ON. EACH TIME THEY JUST PUT AIR IN THE TIRES AND SAID THERE WAS NO PROBLEM, AND EACH TIME I ASKED THEM TO CHECK THE RIMS. ONCE OR TWICE THEY INSPECTED AND CLEANED THE RIMS AND SAID THERE WAS NO PROBLEM. IN JUNE 2016 I ASKED THEM TO CHECK AGAIN BECAUSE I PLANNED TO DRIVE FROM CHICAGO TO NEW YORK. THEY ASSURED ME I WOULD NOT HAVE A PROBLEM. BUT DRIVING BACK FROM NEW YORK IN AUGUST 2016, THE CAR WAS NOT HANDLING WELL, SO I CHECKED THE TIRES EVEN THOUGH THE CHECK TIRE LIGHT HAD NOT COME ON. I DIDN'T SPOT A PROBLEM, SO I CONTINUED TO DRIVE, BUT ON THE EXPRESSWAY JUST OUTSIDE OF YOUNGSTOWN, OHIO, THE LEFT FRONT TIRE SUDDENLY WENT FLAT, AND I BARELY WAS ABLE TO STEER THE CAR TO THE SIDE OF THE ROAD. WITH THE HELP OF A STATE TROUPER I FINALLY GOT A TOW TRUCK AND HAD THE SPARE PUT ON. THE NEXT MORNING I DROVE TO THE CLOSEST VW DEALER IN YOUNGSTOWN. THEY REPLACED THE TIRE, WHICH WAS DAMAGED BEYOND REPAIR. THEY SAID THAT THEY FOUND TWO SMALL INDENTATIONS ON THE INSIDE OF THE RIM THAT PROBABLY CAUSED THE TIRE TO LEAK AIR AND GO FLAT. THEY FIXED THE INDENTATIONS. BACK HOME AT THE VW DEALER IN GLENVIEW, IL, THEY AGAIN ASSURED ME THERE WAS NO PROBLEM, AND THEY REIMBURSED ME FOR THE REPAIRS. BUT JUST A COUPLE WEEKS AFTER THAT, MY CAR BEGAN TO HANDLE POORLY. I PUT AIR IN THE TIRES, AND A FEW HOURS LATER ON THE EXPRESSWAY THE CHECK TIRE LIGHT CAME ON. I ASKED VW TO REPLACE ALL THE RIMS AND TIRES FOR BY BACK THE CAR. THEY REFUSED. ONLINE I SEE OTHERS WITH THIS COMPLAINT. I HAVE DECIDED TO SELL THE CAR MYSELF, AT GREAT LOSS, AND BUY A SUBARU. THIS WAS A SAFETY ISSUE THAT I TOOK TO THE HIGHEST LEVELS AT VW, BUT THEY WOULDN'T LISTEN TO MY CLAIM. *TR
ON THIS VEHICLE, FUSE (F16 PLUG-IN POSITION) OVERHEATED AND DAMAGED THE FUSE BOX, CAUSING A PARTIAL LOSS OF EXTERIOR VEHICLE LIGHTING. THIS COULD INCREASE THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY. VW ISSUED 97AM ACTION ALERT FOR EARLIER YEAR SAME MODELS, BUT NOT THIS AND LATER YEAR MODELS.
CAR STALLS INTERMITTENTLY UNDER VARIOUS CONDITIONS ACCELERATING DE-ACCELERATING WARMED UP, AND COLD FUEL PUMP HAS BEEN REPLACED ALONG WITH FILTER AND NOW POWER RELAY HAS BEEN REPLACED BUT IT STILL STALLS VERY DANGEROUS TO DRIVE.
RIGHT FRONT HEADLIGHT ASSEMBLY (HIGH & LOW BEAM, TURN SIGNAL, DRL), RIGHT REAR TAILLIGHT, THIRD BRAKE LIGHT, LICENSE PLATE LIGHT AND LEFT REAR TURN SIGNAL ALL STOPPED WORKING AT THE SAME TIME. DASH INFORMATION CENTER REPORTED ALL OF THESE LIGHTS NEED TO BE CHECKED. AFTER 1.5 HOURS OF TROUBLESHOOTING WITH A FLUKE MULTI-METER, I…
Read full complaint
RIGHT FRONT HEADLIGHT ASSEMBLY (HIGH & LOW BEAM, TURN SIGNAL, DRL), RIGHT REAR TAILLIGHT, THIRD BRAKE LIGHT, LICENSE PLATE LIGHT AND LEFT REAR TURN SIGNAL ALL STOPPED WORKING AT THE SAME TIME. DASH INFORMATION CENTER REPORTED ALL OF THESE LIGHTS NEED TO BE CHECKED. AFTER 1.5 HOURS OF TROUBLESHOOTING WITH A FLUKE MULTI-METER, I FOUND A POST ON TDI FORUMS REFERENCING CAMPAIGN 97AM TO CHECK THE FUSE PANEL UNDER THE HOOD, POSITION F16, 30AMP FUSE FOR MELTING. I CHECKED THIS FUSE AND THE FUSE PANEL AND FUSE IS MELTED. I CONTACTED THE VW DEALERSHIP THAT VERIFIED THERE IS NO RECALL ON THIS ISSUE PERTAINING TO MY VIN. I THEN CONTACTED VW CUSTOMER CARE WHO ALSO SAID THERE IS NO RECALL OR SAFETY ISSUE AND THEY WILL NOT CORRECT IT BASED ON NUMEROUS COMPLAINTS ABOUT THE ISSUE ON THE 2009 - 2012 JETTA SPORTWAGENS. VW ADVISED ME TO TAKE THE CAR TO THE VW DEALERSHIP FOR FURTHER DIAGNOSIS BUT ADVISED I WOULD BE RESPONSIBLE FOR ANY CHARGES TO FIX THE CAR.
THE CLOCK SPRING GOT DEBRIS IN IT, PUSHING THE RIBBON OFF THE GUIDE WIRES AND CAUSING A KINK. THIS CAUSES A FAULT IN THE AIRBAG CONTROLS AS THERE IS UNRELIABLE CONNECTIVITY WITH THE COMPUTER. THUS, THE DRIVER'S SIDE AIRBAG WITHIN THE STEERING COLUMN TURNS ITSELF OFF. VW VOLUNTARILY RECALLED 420,000 CARS FOR THIS EXACT PROBLEM, I…
Read full complaint
THE CLOCK SPRING GOT DEBRIS IN IT, PUSHING THE RIBBON OFF THE GUIDE WIRES AND CAUSING A KINK. THIS CAUSES A FAULT IN THE AIRBAG CONTROLS AS THERE IS UNRELIABLE CONNECTIVITY WITH THE COMPUTER. THUS, THE DRIVER'S SIDE AIRBAG WITHIN THE STEERING COLUMN TURNS ITSELF OFF. VW VOLUNTARILY RECALLED 420,000 CARS FOR THIS EXACT PROBLEM, INCLUDING SOME VEHICLES WITHIN OUR SAME YEAR AND MODEL. FROM VW'S RECALL NOTICE: ON CERTAIN VEHICLES, THE STEERING WHEEL CLOCK SPRING COULD BECOME CONTAMINATED WITH LONG HAIR OR LONG FIBERS WHICH MAY CAUSE A DISPLACEMENT OF THE INTERNAL GUIDE LOOPS. WHEN THE GUIDE LOOPS ARE DRAGGED OUT OF POSITION, THEY MAY APPLY TENSION TO THE INTERNAL FLAT CABLE AND CAUSE IT TO TEAR. SHOULD THE CABLE TEAR, THE ELECTRICAL CONNECTION TO THE DRIVER'S FRONT AIRBAG MAY BE LOST, CAUSING THE AIRBAG MONITORING INDICATOR LIGHT TO ILLUMINATE. IN A CRASH THAT WARRANTS A DRIVER FRONT AIRBAG DEPLOYMENT, THE AIRBAG WILL NOT DEPLOY, LEADING TO A RISK OF DRIVER INJURY. THIS IS EXACTLY WHAT HAPPENED TO OUR VEHICLE, VERBATIM. OUR VEHICLE WAS NOT PART OF THE AFFECTED RECALL. I WAS TOLD BY A VW TECH THAT OUR VEHICLE WAS NOT PART OF THE RECALL BECAUSE THE PART INCLUDES A COMPUTER MODULE FOR THE HIGHLINE DISPLAY. THIS CONTROLS ALL STEERING COLUMN-MOUNTED BUTTONS (RADIO, ETC), AND MUST BE MANUALLY REPROGRAMMED FOR EACH MODEL IT'S INSTALLED IN. THE PART COST INCREASES FROM $115 TO $375 AND THE LABOR FOR INSTALLATION INCREASES FROM $100 TO OVER $400. SO BY NOT REPLACING THE HIGHLINE MODULES, VW WILL SAVE SEVERAL MILLION DOLLARS. MEANWHILE, PEOPLE ARE RIDING AROUND WITHOUT FUNCTIONING AIRBAGS BECAUSE VW CAN'T DESIGN A STEERING COLUMN THAT KEEPS LONG HAIR FROM GETTING TANGLED IN THEIR CLOCK SPRINGS. THE DESIGN FLAW ISN'T IN THE CLOCK SPRING ITSELF BUT IN THE STEERING COLUMN ASSEMBLY THAT CAN'T BLOCK DEBRIS FROM GETTING DOWN INTO THE CLOCK SPRINGS TO BEGIN WITH.
RADIO (INCLUDING BLUETOOTH) SUDDENLY WENT OUT AT 39K MILES. DEALER DIAGNOSIS WAS THAT RADIO FAILED.
Official recalls
116V078000 · Air Bags:frontal:driver Side:inflator Module
Feb 10, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922