2023 Volkswagen ID.4

I am driving home from work and I’m right around the corner from my house. As soon as I try to make a turn, the car begins beeping and the faults “Electrical system malfunction” and “12V power supply” show up. My car does not accelerate, I lose power steering, and I can no longer move while I’m still in the middle of the road with cars around me. Thankfully, there was a slight downhill that allowed me to coast somewhat off the road, but I had to push this 4600+ lbs car (by myself) further so it wasn’t sticking out. I had to get 4 other people to help push the car to my house across a residential collector road which took ~20 mins just to go a couple hundred feet. This is the THIRD time of this occurring, twice I’ve been to the dealership, and twice they told me they couldn’t replicate the issue. The other times “thankfully” occurred when the car was already parked, but one of the instances required a tow; this was not even a week after buying the car. The second time occurred not even 5 hours after getting my car back from the dealership service center, requiring me to ditch the car in the parking lot (dealership was closed). I’ve had the car for a little under a month. This is incredibly unsafe. I work in downtown and go on many major roads/interstates during my commute. If this would’ve happened on the freeway or a busier road, a serious accident and/or injury could’ve occurred.

Car has been in and out of various VW dealers since purchase at the end of August 2023. Car was purchased new. Immediately began receiving emergency “stop driving vehicle” messages on driver display. VW on call service advised if the car drives, I can operate it and no further action is necessary. Various Electical errors including charge 12V battery, infotainment screen going black or resetting while driving, no display while in reverse, car losing power on highway, car alarm going off while driving, if hazard lights are used, they do not shut off unless the car is off and driver is out of the car for at least ten minutes, interior lights flash on and off (this is a safety issue as is if incredibly difficult to see while driving at night, car has been in shop three times for this, no repairs, the car battery drains incredibly quickly; usually get about 2kWh in town driving, charging errors; charger not recognized, or car displays it is charging, but when complete, it didn’t charge, windows don’t respond to the controls, door handles don’t always work to open the doors; often have to access the car from passenger side (these have been replaced and still don’t work), emergency braking system doesn’t function, car ghost breaks (no objects ahead, clean sensors, driving and brakes slam on), multiple leaks in vehicle including headlights, rear driver tail light, and the light on top of the back hatch, car loses connection to emergency system, infotainment screen doesn’t respond to finger touches and must be reset, to initiate OTA updates, fuse needs to be pulled. I barely drive the car, and it’s my only vehicle. It’s not safe (lighting issues ongoing, alarms, safety features don’t work, can’t get into the car) and not reliable for travel as charging is hit or miss (at commercial charging stations and home charging station), and the battery life is extremely short, even in perfect conditions using cruise control in eco mode, the car only travels about 130 miles.

I was charging at Electrify America charging station for approximately 20 minutes when suddenly I felt the ID.4 shaking and then seconds later I was surrounded by smoke coming from outside and beneath the ID.4. The ID.4 was not turned on and was completely stationary. I unplugged the vehicle. During this time I made a best effort to not inhale but it happened so quickly that it was unavoidable. The smoke smelled really toxic and tasted like chemicals. I felt nauseous and woozy afterwards. I called 911 to report the smoke coming out of my ID.4. Call was made at 6pm, seconds after the smoke started pouring out. The vehicle was releasing extreme amounts of cloudy thick white smoke and it completely engulfed the ID.4 itself. There was also an orange/pink-like liquid pouring out of the left side of the vehicle from the bottom. The fire department came and from what they told me, they cut a "cut loop" to prevent the battery from continuing to get more power. They told me the cells in the battery were continuing to release energy and heat to the point that it was melting the carpets in the ID.4's floor. They hosed it down for over 2 hours until the battery was cooled off enough and safe to be towed to a safe area. There had been no warning leading to this. The car did not alarm of any issues.

I am advised by VW to not charge this vehicle using the L3 super chargers along with not to charge it "inside" a garage. However, there is no way to charge the vehicle then without spending thousands to have an electrician move the plug outside. So I am forced to have this vehicle not usable and VW offers zero fix. I have written them a formal demand letter over 3 weeks ago requesting a fix or buy back and they ignore it. They have sold a vehicle which is clearly unsafe, however offer no fix

VW has informed me that my 2023 ID4 has a faulty battery that is at risk of catching fire. The VW corporate representative told me not to charge at fast charging stations and to keep it clear from my property because of the risk of it catching fire. VW has not issued the recall yet as they dont have a solution, but warned me about the dangers. They said they don't expect to issue the recall until mid march. I also talked to a VW dealer and they said when the recall comes out that the wait time to fix will be significant. In the meantime, I feel very unsafe driving , charging, parking this car.

Date/Time of Incident: 1/29/36 at approximately 5:44 PM Location: Small school parking lot Vehicle: 2023 Volkswagen ID.4 On 1/29/36 at approximately 5:44 PM, I was pulling out of a parking space at low speed in a small school parking lot in my 2023 Volkswagen ID.4. As I began to move, the vehicle suddenly accelerated on its own, the steering would not turn left, and the car did not respond to braking, moving at an abnormal rate of speed over a very short distance. Prior to this, there had been no warning messages or alerts, except a routine notification to service the car in 1,000 miles. The collision involved three vehicles: my VW, the main car I hit, and a rental car. My car spun and veered sideways, the parked SUV on the right was pushed sideways, forming a rough “H” pattern, and the rental car went up onto a rail ramp where children walk. My grandson observed the car’s tires spinning at impact, and he hit the seat behind me. Without the parked cars, the vehicle would have continued directly toward the school building, creating a very serious risk of fatal injuries to parents, staff, and children. Injuries: Myself — pain and emotional trauma; grandson — soft cast on foot/leg, crutches, pain; his mother — pain. The vehicle is awaiting Volkswagen guidance for inspection. Likely involved systems include Speed Control, Fuel/Propulsion System, and Electrical, but the exact cause is UNKNOWN. The incident has been reported to State Farm (claim #0596B819B), Volkswagen (Case #07294060), and police.

When driving at low speed in a parking log, vehicle began to accelerate suddenly. Driver was able to brake to avoid collision. Seemed to be due toaccidental touch of capacitive touch RES button on left side of steering wheel, which resumed previous ACC speed. ACC had not been use for several days prior, but system remembered previous high speed and tried to resume.

Automatic parking assist and reverse braking systems exhibit severe, recurring malfunctions causing collisions and injuries. On May 24, 2025, at approx. 4:10 PM, auto-park uncommanded the vehicle to strike a mailbox in a familiar spot. Dealer dismissed incident without diagnostics. Beyond this collision, the vehicle exhibits frequent, violent, unintended braking during reverse. This occurs when: Turning body to look back: System abruptly locks brakes, causing whiplash-like neck pain to me. Dealer stated this was "normal" for "driver seating" despite explanation. Encountering minor obstacles: System misidentifies leaves/garbage bins as threats, engaging full, hard braking. This causes extreme distress and has violently thrown passengers forward. My teenager son sustained a visible bruise for one week after hitting the console during one such incident March 2024 These system malfunctions create high risk of injury to occupants and pedestrians. The unpredictable braking events are a fundamental flaw. These issues were reported to the dealer within weeks of purchase and to VW Group of America Customer Care (800-822-8987) after the mailbox incident. They remain unresolved."

Our VW ID.4 was leased in December 2023. The vehicle unexpectedly went into "turtle"mode or limp mode, which according to VW happens when the battery is very low. Notably, we had 80% of battery charge at the time (which is the optimum charge). Unexpectedly, the yellow turtle display came on and, worse, the vehicle lost power while driving. The speed was greatly reduced, the power was also greatly reduced. The car went from regenerative breaking to loss of regenerative breaking, while the center drive display still showed "B" for regenerative breaking. It was also almost not possible to drive up a small hill. The vehicle displayed 2 error messages (we have photos, also of the 80% battery charge, which we attach): 1. "Vehicle performance is limited. See owner's manual." 2. "Electrical system not working correctly. Safely stop the vehicle." Comment: In our opinion, the vehicle is not safe to drive. The unexpected reduction in speed and loss of power, paired with the loss of regenerative breaking, creates very dangerous conditions. It may not be possible to "Safely stop the vehicle". In addition, we have also lost the center display and dashboard display twice now, which we believe is mentioned in NHTSA Recall Number24V344. VW sent us a letter in July informing us that our vehicle is subject to this recall. Yes, we have experienced the issue, twice. It is even more scary, if this happens when the vehicle loses power unexpectedly on an 80% charge. It is unacceptable that VW states in its recall letter "A recall repair is not available yet". VW is exposing drivers and passengers to significant risk. We are concerned that this vehicle is not safe to drive. We have brought it to the dealer on Monday 8-26-2024 and are awaiting diagnostics and repair.