ENGINE STALLS AT LOW SPEEDS WITH THE CLUTCH IN (URANO GREY 6-SPEED MANUAL). SOMETIMES THE ENGINE DIES QUICK AND CLEAN, SOMETIMES SPUTTERS/FLUTTERS AND THEN DIES. CAR NEEDS TO BE RESTATED IN TRAFFIC - DANGEROUS! HAPPENS PRETTY RARELY, BUT HAPPENED 4 TIMES WITHIN CITY-ISH 50 MILES, SO CERTAINLY A CONCERN! NEW CAR HAS LESS THAN…
Read full complaint
ENGINE STALLS AT LOW SPEEDS WITH THE CLUTCH IN (URANO GREY 6-SPEED MANUAL). SOMETIMES THE ENGINE DIES QUICK AND CLEAN, SOMETIMES SPUTTERS/FLUTTERS AND THEN DIES. CAR NEEDS TO BE RESTATED IN TRAFFIC - DANGEROUS! HAPPENS PRETTY RARELY, BUT HAPPENED 4 TIMES WITHIN CITY-ISH 50 MILES, SO CERTAINLY A CONCERN! NEW CAR HAS LESS THAN 400 MILES ON IT.
NHTSA ODI #11205158
450 miles · May 1, 2019
EnginePower Train
THE CAR HAS A SIX SPEED MANUAL TRANSMISSION AND OCCASIONALLY STALLS WITH THE CLUTCH FULLY DEPRESSED, THE TRANSMISSION IN GEAR, AND VEHICLE SPEED BELOW 5MPH, FOR INSTANCE WHEN APPROACHING A RED LIGHT OR STOP SIGN. PRESSING THE CAR'S START BUTTON UPON REACHING A FULL STOP RE-STARTS THE CAR. THIS HAS HAPPENED MORE THAN A DOZEN TIME…
Read full complaint
THE CAR HAS A SIX SPEED MANUAL TRANSMISSION AND OCCASIONALLY STALLS WITH THE CLUTCH FULLY DEPRESSED, THE TRANSMISSION IN GEAR, AND VEHICLE SPEED BELOW 5MPH, FOR INSTANCE WHEN APPROACHING A RED LIGHT OR STOP SIGN. PRESSING THE CAR'S START BUTTON UPON REACHING A FULL STOP RE-STARTS THE CAR. THIS HAS HAPPENED MORE THAN A DOZEN TIMES OVER THE PAST TWO WEEKS.
NHTSA ODI #11204916
2,369 miles · Apr 30, 2019
EnginePower TrainUnknown Or Other
VEHICLE DIED WHEN STOPPING AT RED LIGHT IN EVENING RUSH HOUR. THERE WAS NO SHUTTER WITH THE ENGINE SHUTOFF. DID NOT NOTICE ENGINE WAS OFF AND WHEN ATTEMPTED TO ACCELERATE FROM A STAND STILL, I NOTICED THE VEHICLE WAS OFF. THIS HAPPENED HALF A MILE LATER AT AN ADDITIONAL STOP LIGHT. THERE WERE NO WARNING OR LIGHTS ON THE DASHBOAR…
Read full complaint
VEHICLE DIED WHEN STOPPING AT RED LIGHT IN EVENING RUSH HOUR. THERE WAS NO SHUTTER WITH THE ENGINE SHUTOFF. DID NOT NOTICE ENGINE WAS OFF AND WHEN ATTEMPTED TO ACCELERATE FROM A STAND STILL, I NOTICED THE VEHICLE WAS OFF. THIS HAPPENED HALF A MILE LATER AT AN ADDITIONAL STOP LIGHT. THERE WERE NO WARNING OR LIGHTS ON THE DASHBOARD.
NHTSA ODI #11204856
490 miles · Apr 26, 2019
EngineFuel/propulsion SystemPower Train
I AM CONCERNED WHEN COMING TO A STOP UNEXPECTEDLY MY CAR WILL START TO IDLE ROUGH AND THEN STALL. I'M CONCERNED IT WILL HAPPEN WHILE DRIVING AND THAT I COULD BE HIT. CURRENTLY IT HAPPENS AT LOW SPEED WHEN STOPPING AND I CANNOT KEEP THE CAR RUNNING WHEN I START IT UP AGAIN. I AM HAVING TO REV THE ENGINE TO KEEP IT RUNNING AND MOV…
Read full complaint
I AM CONCERNED WHEN COMING TO A STOP UNEXPECTEDLY MY CAR WILL START TO IDLE ROUGH AND THEN STALL. I'M CONCERNED IT WILL HAPPEN WHILE DRIVING AND THAT I COULD BE HIT. CURRENTLY IT HAPPENS AT LOW SPEED WHEN STOPPING AND I CANNOT KEEP THE CAR RUNNING WHEN I START IT UP AGAIN. I AM HAVING TO REV THE ENGINE TO KEEP IT RUNNING AND MOVE OFF THE ROAD. MY CAR HAS A MANUAL TRANSMISSION AND THE CLUTCH IS FULLY PRESSED DOWN WHEN THIS HAPPENS. I HAVE MORE THAN 3/4 TANK OF GAS WHEN THIS HAPPENED.
NHTSA ODI #11203843
75 miles · Apr 18, 2019
EnginePower TrainUnknown Or Other
WHITE 2019 RABBIT EDITION 6MT, BUILD DATE OF 10/18, PURCHASED 4/6/19. ISSUE BEGAN THE DAY OF PURCHASE WITH LESS THAN 100 MILES ON THE CAR. THE VEHICLE WILL FREQUENTLY STALL WHEN THE CLUTCH IS FULLY DEPRESSED SHORTLY BEFORE COMING TO A STOP. THE STALL IS UNCHARACTERISTIC OF OTHER STALLS DUE TO DRIVER ERROR, AS IT CAN BARELY BE FE…
Read full complaint
WHITE 2019 RABBIT EDITION 6MT, BUILD DATE OF 10/18, PURCHASED 4/6/19. ISSUE BEGAN THE DAY OF PURCHASE WITH LESS THAN 100 MILES ON THE CAR. THE VEHICLE WILL FREQUENTLY STALL WHEN THE CLUTCH IS FULLY DEPRESSED SHORTLY BEFORE COMING TO A STOP. THE STALL IS UNCHARACTERISTIC OF OTHER STALLS DUE TO DRIVER ERROR, AS IT CAN BARELY BE FELT THROUGH THE CAR. THIS HAS HAPPENED WHEN THE CAR IS BOTH IN GEAR AND OUT OF GEAR WHILE THE CLUTCH IS DEPRESSED. ONCE THE CAR STALLS, IT MUST BE RESTARTED BY PRESSING THE IGNITION BUTTON AGAIN. AFTER THE ENGINE IS RESTARTED, THE CAR WILL RESUME NORMAL DRIVING OPERATION UNTIL IT STALLS WHILE COMING TO A STOP AGAIN. THE STALLING ONLY SEEMS TO OCCUR WHEN THE CAR IS AT OPERATING TEMPERATURE. THE CAR HAS BEEN AT THE DEALER FOR DIAGNOSTICS TWICE, BOTH TIMES HAVING NO RESULTS. A VW TECH WAS ABLE TO REPLICATE THE ISSUE, BUT WAS UNABLE TO FIND ITS SOURCE.
NHTSA ODI #11197189
750 miles · Apr 17, 2019
Electrical SystemPower TrainUnknown Or Other
BOUGHT A BRAND NEW 2019 VW GOLF GTI RABBIT EDITION MANUAL 6-SPEED ON JANUARY 14, 2019 AND HAD IT DIE OUT ALMOST LIKE A "PUTTER" UNTIL THE ENGINE SHUT OFF WHILE I WAS DRIVING IT TODAY APRIL 17, 2019. HAPPENED WHEN I WAS COMING TO A STOP WITH THE CLUTCH IN AND IN FIRST GEAR. WHEN I RESTARTED THE CAR USING THE PUSH IGNITION I THEN …
Read full complaint
BOUGHT A BRAND NEW 2019 VW GOLF GTI RABBIT EDITION MANUAL 6-SPEED ON JANUARY 14, 2019 AND HAD IT DIE OUT ALMOST LIKE A "PUTTER" UNTIL THE ENGINE SHUT OFF WHILE I WAS DRIVING IT TODAY APRIL 17, 2019. HAPPENED WHEN I WAS COMING TO A STOP WITH THE CLUTCH IN AND IN FIRST GEAR. WHEN I RESTARTED THE CAR USING THE PUSH IGNITION I THEN HAD IT DIE ON ME TWICE MORE. LUCKILY THIS HAPPENED WHEN I WAS NEARLY HOME... I WAS ABLE TO FINALLY GET THE CAR STARTED AND REV THE ENGINE JUST ENOUGH TO GET BACK ON MY WAY BUT THEN HAD IT DIE ON ME AGAIN WHEN PULLING INTO MY DRIVEWAY AT HOME. THE CAR STILL HAS LESS THAN 800 MILES ON IT AND HAS BEEN PROPERLY DRIVEN SINCE TAKEN OFF THE CAR DEALER'S LOT.
NHTSA ODI #11197069
43 miles · Apr 11, 2019
Power Train
THE CAR HAS 43 MILES ON IT AND IS STALLING WHEN COMING TO A STOP. IT'S STALLING WHEN STATIONARY IN NEUTRAL WITH THE CLUTCH DEPRESSED. IT'S ALSO STALLING IN GEAR WITH THE CLUTCH PRESSED (AT A STOP SIGN, CAR IN FIRST GEAR, FOOT ON CLUTCH, RPMS DROP TO ZERO AND CAR QUIETLY JUST TURNS OFF). IT DOESN'T RUMBLE LIKE A NORMAL MOTOR STAL…
Read full complaint
THE CAR HAS 43 MILES ON IT AND IS STALLING WHEN COMING TO A STOP. IT'S STALLING WHEN STATIONARY IN NEUTRAL WITH THE CLUTCH DEPRESSED. IT'S ALSO STALLING IN GEAR WITH THE CLUTCH PRESSED (AT A STOP SIGN, CAR IN FIRST GEAR, FOOT ON CLUTCH, RPMS DROP TO ZERO AND CAR QUIETLY JUST TURNS OFF). IT DOESN'T RUMBLE LIKE A NORMAL MOTOR STALL WOULD, IT JUST SHUTS OFF (LIKE AUTO ON/OFF WOULD ON A AUTOMATIC).
NHTSA ODI #11195547
400 miles · Apr 10, 2019
Power Train
CAR WILL SOFTLY STALL OUT WHEN I COME TO A STOP WITH THE CLUTCH FULLY DEPRESSED OR THE STICK OUT OF GEAR. STARTED HAPPENING WITH LESS THAN 200 MILES ON THE CAR. HAPPENED THREE SEPERATE OCCASIONS BEFORE 420 MILES. CAR WILL RESTART RIGHT AWAY IN EVERY INSTANCE EXCEPT FOR THE ONE RIGHT BEFORE 420 MILES. THAT INSTANCE THE CAR STALLE…
Read full complaint
CAR WILL SOFTLY STALL OUT WHEN I COME TO A STOP WITH THE CLUTCH FULLY DEPRESSED OR THE STICK OUT OF GEAR. STARTED HAPPENING WITH LESS THAN 200 MILES ON THE CAR. HAPPENED THREE SEPERATE OCCASIONS BEFORE 420 MILES. CAR WILL RESTART RIGHT AWAY IN EVERY INSTANCE EXCEPT FOR THE ONE RIGHT BEFORE 420 MILES. THAT INSTANCE THE CAR STALLED, I HIT THE START BUTTON, STARTED AGAIN, THEN STALLED IMMEDIATELY. STARTED AGAIN, STALLED AGAIN. STARTED AGAIN, STAYED IDLE AND I STARTED MOVING.
NHTSA ODI #11195492
4,400 miles · Apr 10, 2019
EngineFuel/propulsion SystemPower Train
WHILE DRIVING AT LOW SPEED THE ENGINE WILL STALL
NHTSA ODI #11195459
350 miles · Apr 10, 2019
EnginePower Train
2019 GTI SE 6MT. CAR SOFT STALLS - RPM DROPS TO ZERO (WITHOUT JERKING MOTION) AT RANDOM INTERVALS WHEN COMING TO A COMPLETE STOP WITH CLUTCH PEDAL FULLY DEPRESSED. PRESSING THE START/STOP BUTTON STARTS THE ENGINE AGAIN AND THE CAR OPERATES AS NORMAL. CAR IS AT OPERATING TEMPERATURE, AMBIENT OUTSIDE TEMPERATURE WAS APPROXIMATELY …
Read full complaint
2019 GTI SE 6MT. CAR SOFT STALLS - RPM DROPS TO ZERO (WITHOUT JERKING MOTION) AT RANDOM INTERVALS WHEN COMING TO A COMPLETE STOP WITH CLUTCH PEDAL FULLY DEPRESSED. PRESSING THE START/STOP BUTTON STARTS THE ENGINE AGAIN AND THE CAR OPERATES AS NORMAL. CAR IS AT OPERATING TEMPERATURE, AMBIENT OUTSIDE TEMPERATURE WAS APPROXIMATELY 70 DEGREES. BEHAVIOR IS NOT READILY REPRODUCIBLE. CAR HAS APPROXIMATELY 350 MILES ON THE ODOMETER WITH A BUILD DATE OF 1/19.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Golf, Golf Alltrack, Golf Sportwagen, 2019-2020 Golf GTI, and Jetta vehicles equipped with a conventional ignition switch. The ignition switch may fail, especially in high temperature environments.
Consequence & remedy
Consequence: Ignition switch failure can cause the electrical system to shut down and the engine to stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the ignition switch, free of charge. Owner notification letters were mailed February 1, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 28H7.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP19003 · Vehicle Stalling - Manual Transmission
Opened Sep 3, 2019 · Closed Jun 30, 2020
Status: closed (inferred from source dates) · Engine; Power Train:manual Transmission
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Additional source detail variants (2)
Engine
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Power Train:manual Transmission
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
2019 Volkswagen Gti Problems, Complaints & Recalls | Skip That Year
Illustration