Fuel pump and thermostat failure. Known issue on 2017 GTI models and VW corporate will not grant an exception for the class action settlement since vehicle is outside of coverage period. All scheduled maintenance on vehicle has been done at a dealership and i have had no issues. Spoke with VW Corporate and they will not grant a…
Read full complaint
Fuel pump and thermostat failure. Known issue on 2017 GTI models and VW corporate will not grant an exception for the class action settlement since vehicle is outside of coverage period. All scheduled maintenance on vehicle has been done at a dealership and i have had no issues. Spoke with VW Corporate and they will not grant an exception or allow me to speak to anyone else after requesting an escalation request to a supervisor. They also said filing a complaint will not do anything since the outcome will not change.
NHTSA ODI #11753293
Mileage unknown · Jul 24, 2026
EngineFuel/propulsion System
On June 24, 2026, Safety Recall 20UF (Suction Jet Pump) was completed by an authorized Volkswagen dealer. Upon leaving the dealership, the vehicle immediately experienced a severe engine stall and extended no-start condition. During the recall service, liquid fuel flooded the EVAP lines and charcoal canister, saturating the inta…
Read full complaint
On June 24, 2026, Safety Recall 20UF (Suction Jet Pump) was completed by an authorized Volkswagen dealer. Upon leaving the dealership, the vehicle immediately experienced a severe engine stall and extended no-start condition. During the recall service, liquid fuel flooded the EVAP lines and charcoal canister, saturating the intake with raw fuel. This caused an immediate safety hazard, stalling the vehicle in active traffic in 110+ degree summer heat. The vehicle was brought back to the dealer, who confirmed the stall but incorrectly blamed a fuel injector, refusing to acknowledge the EVAP flooding caused by the recall work. Due to the no-start condition, the vehicle was flatbed towed. Raw fuel from this EVAP lines washed past the piston rings, requiring an emergency engine oil change to prevent catastrophic engine failure from severe oil dilution. VW Customer CARE (Case #07594393) refused reimbursement for the towing ($167.00) and oil flush ($101.74) resulting directly from the botched recall. VW failed to provide a safe, effective, cost-free recall remedy. Repair documents attached.
NHTSA ODI #11752743
65,000 miles · Sep 19, 2020
Engine
THERE IS A CONSTANT COOLANT LEAK COMING FROM THE THERMOSTAT HOUSING AND WATER PUMP AREA. IT STARTED AS A SLOW LEAK, EVERY 10,000 MILES OR SO I WOULD HAVE TO TOP IT OFF AND NOW IT HAS GOTTEN TO THE POINT WHERE I HAVE TO FILL IT BACK UP EVERY DAY. LOOKED INTO IT ONLINE AND IT SEEMS THAT NEARLY EVERYONE THAT OWNS THIS CAR HAS THE S…
Read full complaint
THERE IS A CONSTANT COOLANT LEAK COMING FROM THE THERMOSTAT HOUSING AND WATER PUMP AREA. IT STARTED AS A SLOW LEAK, EVERY 10,000 MILES OR SO I WOULD HAVE TO TOP IT OFF AND NOW IT HAS GOTTEN TO THE POINT WHERE I HAVE TO FILL IT BACK UP EVERY DAY. LOOKED INTO IT ONLINE AND IT SEEMS THAT NEARLY EVERYONE THAT OWNS THIS CAR HAS THE SAME ISSUE AND EVERYONE'S LEAK COMES FROM THIS AREA.THE LEAK HAPPENS AT ALL TIMES BUT IS GREATLY ACCELERATED WHEN DRIVING AND THE COOLANT SYSTEM IS RUNNING.
NHTSA ODI #11359910
45,000 miles · Sep 9, 2020
Engine
DISCOVERED COOLANT LEAK ON OIL PAN AND CONTACTED DEALERSHIP. THIS WAS DURING ROUTINE INSPECTION. DEALERSHIP INSPECTION REVEALED A FAILED WATER PUMP HOUSING. DEALERSHIP REPLACED HOUSING, THERMOSTAT AND THERMOSTAT GASKET UNDER WARRANTY.
NHTSA ODI #11354081
90,000 miles · Jun 10, 2020
Engine
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GTI. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL AT A RATE OF ONE GALLON OF FUEL EVERY FIVE MINUTES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CHARCOAL CANISTER AND SUCTION PUMP NEEDED TO BE REPLACED. CHAPMAN VOLKSWAGEN OF T…
Read full complaint
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GTI. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL AT A RATE OF ONE GALLON OF FUEL EVERY FIVE MINUTES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CHARCOAL CANISTER AND SUCTION PUMP NEEDED TO BE REPLACED. CHAPMAN VOLKSWAGEN OF TUCSON (4500 E 22ND ST, TUCSON, AZ 85711) WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS REFERRED TO THE MANUFACTURER FOR ASSISTANCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #11328131
36,974 miles · Mar 9, 2020
EnginePower Train
THERMOSTAT HOUSING LEAK CAUSES COOLANT LEAK AND LOW COOLANT WARNINGS. WAS OPERATING THE VEHICLE UNDER NORMAL CONDITIONS WHEN LOW COOLANT WARNING ILLUMINATED.
NHTSA ODI #11317146
26,000 miles · Mar 4, 2020
Engine
CAR SUFFERED A FAILURE OF THE THERMOSTAT AT 26837 MILES CAUSING A LOSS OF COOLANT. COOLANT ODOR WAS APPARENT SINCE THE CAR WAS NEW. THIS APPEARS TO BE A WIDESPREAD PROBLEM WITH THIS MODEL AT LOW MILEAGE.
NHTSA ODI #11315968
55,168 miles · Mar 3, 2020
Engine
AFTER 55K MILES, MY CAR HAD A WATERPUMP LEAK THAT SEEMS COMMON IN THE FORUMS I ATTEND.
NHTSA ODI #11315880
40,150 miles · Feb 6, 2020
Engine
2017 VW GTI 4 DOOR. SE TRIM. A COUPLE WEEKS AFTER REACHING 40K MILES, AFTER DRIVING SEVERAL BLOCKS AND MAKING IT ONTO A MAIN ROAD, THE VEHICLE STALLED OUT AND DIED WHILE IN MOTION AT ABOUT 20-25MPH. THIS WAS AFTER WHAT SEEMED LIKE A VERY CLUNKY FEELING SHIFTING TRANSMISSION FOR A FEW DAYS LEADING UP TO THE CAR BREAKING DOWN. …
Read full complaint
2017 VW GTI 4 DOOR. SE TRIM. A COUPLE WEEKS AFTER REACHING 40K MILES, AFTER DRIVING SEVERAL BLOCKS AND MAKING IT ONTO A MAIN ROAD, THE VEHICLE STALLED OUT AND DIED WHILE IN MOTION AT ABOUT 20-25MPH. THIS WAS AFTER WHAT SEEMED LIKE A VERY CLUNKY FEELING SHIFTING TRANSMISSION FOR A FEW DAYS LEADING UP TO THE CAR BREAKING DOWN. CAR SMELLED LIKE FUEL IN THE CABIN. CAR NEEDED TO BE TOWED TO VEWDEALERSHIP IN LATE HOURS OF THE EVENING. DEALERSHIP CALLED THE NEXT DAY TO SAY THEY WERE ABLE TO TURN THE CAR ON AND DRIVE IT. NO OBVIOUS ERROR CODES ON VEHICLE AND THEY WOULD DO SOME DEEPER DIVING INTO WHAT CAN BE WRONG. THEY HELD ONTO THE CAR FOR 4 DAYS AND WERE NOT ABLE TO "DUPLICATE THE ISSUE" SO THEY RETURNED THE CAR BACK TO ME. THEY THOUGHT "MAYBE A PIECE OF DIRT GOT INTO A FUEL INJECTOR BUT WORKED IT'S WAY OUT" AFTER NOT EVEN A WEEK, THE CAR STALLED OUT AND DIED IN THE MIDDLE OF A MAIN ROAD AGAIN WHILE MOVING ABOUT 20MPH. THIS TIME AFTER ABOUT 10 MINUTES I WAS ABLE TO GET IT TO TURN ON AND DROVE DIRECTLY BACK TO THE SAME DEALERSHIP WITH BO ERROR FAULT CODES APPEARING ON THE DASH ONCE AGAIN. NO CABIN FUEL SMELL THIS TIME BUT STALLED OUT EXACTLY THE SAME. THEY HAVE BEEN HOLDING ONTO MY VEHICLE AGAIN WITH NO APPARENT IDEAS HOW TO REPAIR IT. THEY ARE GOING TO OPEN A CLAIM WITH VW. THIS WAS A DANGEROUS SITUATION STALLING BOTH TIMES ON MAIN ROADS WHERE I COULD HAVE BEEN REAR ENDED. CHILDREN ARE DRIVEN AROUND IN MY VEHICLE WHICH CAN RESULT IN SERIOUS INJURY.
NHTSA ODI #11307416
21,000 miles · Jan 2, 2020
Engine
THE THERMOSTAT HOUSING ON THE ENGINE DEVELOPED A SIGNIFICANT LEAK, ALLOWING COOLANT TO DRIP ON THE ROADWAY AND ALSO ENDANGERING THE CAR'S ENGINE FROM OVERHEATING AND POSSIBLE POWER LOSS. THIS COULD OF COURSE CAUSE A SLIPPERY ROAD SURFACE AND COULD ALSO RESULT IN THE CAR LOSING POWER ON THE STREET CREATING A HAZARD.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2017 Volkswagen Gti Problems, Complaints & Recalls | Skip That Year
Illustration