NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
10 reportsClear category filterMileage unknown · Jan 15, 2026
Fuel/propulsion SystemUnknown Or Other
I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refuel…
Read full complaint
I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refueling (fuel pump nozzle repeatedly shut off even with a low fuel level). These symptoms were similar to prior EVAP system failures that required replacement of the charcoal canister and EVAP purge (N80) valve earlier in 2025. I brought the vehicle to the dealership on December 29, 2025, specifically requesting completion of Recall 20UF and inspection/replacement of EVAP components if necessary. The dealership initially refused to perform the recall unless I returned the vehicle with less than one-quarter tank of fuel, despite the recall documentation specifying that fuel extraction equipment (VAS5190A or equivalent) is required for this repair. A diagnostic report generated by the dealership listed a “Fuel Pump (in tank)” replacement as a customer-pay repair before later removing it once it was identified as recall-related. After significant delays, the dealership stated the recall had been completed and declined to replace any EVAP components. Since the recall service, the vehicle continues to experience intermittent shuddering and difficulty accelerating. While refueling has temporarily improved, drivability concerns persist, raising questions about whether the recall repair was properly performed and whether the vehicle remains safe to operate. I am concerned about inconsistent handling of a safety recall, improper diagnostic practices, and continued fuel-system-related drivability issues that may pose a safety risk.
NHTSA ODI #11711276
Mileage unknown · Jul 23, 2025
Unknown Or Other
I was driving on the highway, and heard a quiet sound like someone sprinkling sand on my windshield for about 10 seconds. All of a sudden, the sun roof burst and shattered with a loud pop. Luckily the internal slide-able screen webbing kept the glass from entering the compartment (except a bit of glass dust and small shards). …
Read full complaint
I was driving on the highway, and heard a quiet sound like someone sprinkling sand on my windshield for about 10 seconds. All of a sudden, the sun roof burst and shattered with a loud pop. Luckily the internal slide-able screen webbing kept the glass from entering the compartment (except a bit of glass dust and small shards). I never heard a rock hit, or any other cause. I believe the ‘sand sprinkling’ sound was the ‘spider web’ cracks spreading prior to the burst. Obviously that is extremely dangerous while driving on the highway. If it wasn’t for the internal screen keeping the glass off me, it could have been much worse. I was able to pull off the highway and temporarily secure the glass with some cardboard and packing tape.
NHTSA ODI #11675516
Mileage unknown · Dec 14, 2020
EngineFuel/propulsion SystemUnknown Or Other
IT SUCKS IN TOO MUCH AIR AND FAILS AS IF IT HAD A SPARKPLUG FAULT IT WASTES TOO MUCH GAS AND SOMETIMES SUFFOCATES AND WANTS TO TURN OFF
NHTSA ODI #11383274
30,600 miles · Mar 7, 2020
Electrical SystemStructureUnknown Or Other
MY 2016 GOLF GTI SE HAS A LEAKING PANAORMIC SUNROOF, IT LEAKS INTO THE INTERIOR CAUSING DAMAGE TO THE CEILING, THE PASSENGER SEAT, THE OVERHEAD LIGHTING CONTROLS, AND THE PASSENGER VISOR LIGHT. THIS HAPPENS EVEN WHEN THERE IS A MINOR AMOUNT OF RAIN. THIS HAPPENS WHEN THE CAR IS MOVING OR STATIONARY. THERE ARE SO MANY PEOPLE W…
Read full complaint
MY 2016 GOLF GTI SE HAS A LEAKING PANAORMIC SUNROOF, IT LEAKS INTO THE INTERIOR CAUSING DAMAGE TO THE CEILING, THE PASSENGER SEAT, THE OVERHEAD LIGHTING CONTROLS, AND THE PASSENGER VISOR LIGHT. THIS HAPPENS EVEN WHEN THERE IS A MINOR AMOUNT OF RAIN. THIS HAPPENS WHEN THE CAR IS MOVING OR STATIONARY. THERE ARE SO MANY PEOPLE WITH THIS PROBLEM THAT VW SHOULD BE ISSUING A RECALL TO FIX IT. I HAVE A VIDEO SHOWING WHAT IS HAPPENING BUT, YOU GUYS ONLY ACCEPT PICTURES.
NHTSA ODI #11316769
17,000 miles · Dec 8, 2019
Unknown Or Other
REARVIEW BACKUP CAMERA AT TIMES STOPS WORKING IN 1 OUT OF 3 INSTANCES WHEN SHIFTING INTO REVERSE. THERE IS FIRST AT DISTORTED PICTURE, EVENTUALLY SHUTTING DOWN ALTOGETHER "PARK PILOT NOT AVAILABLE". THIS HAPPENS INTERMITTENTLY WITH NO RHYME OR REASON. REAR CAMERA IS WORKING; THERE ARE DAYS IT IS ALWAYS WORKING, ON OTHERS EVERY R…
Read full complaint
REARVIEW BACKUP CAMERA AT TIMES STOPS WORKING IN 1 OUT OF 3 INSTANCES WHEN SHIFTING INTO REVERSE. THERE IS FIRST AT DISTORTED PICTURE, EVENTUALLY SHUTTING DOWN ALTOGETHER "PARK PILOT NOT AVAILABLE". THIS HAPPENS INTERMITTENTLY WITH NO RHYME OR REASON. REAR CAMERA IS WORKING; THERE ARE DAYS IT IS ALWAYS WORKING, ON OTHERS EVERY REVERSE RESULTS IN A FAILURE. RESETTING THE HEAD UNIT DOES NOT FIX IT. SHUTTING DOWN CAR AN LETTING IT RESET ITSELF SOMETIMES WORKS. THIS SOFTWARE MALFUNCTION IS A SAFETY HAZARD WHOSE FREQUENCY APPEARS TO INCREASE WITH TIME.
NHTSA ODI #11287724
62,500 miles · Mar 4, 2019
Unknown Or OtherInjury
CENTER CONSOLE TRIM BECAME UNGLUED AND SHARP. CHROME SURROUNDING THE CENTER STORAGE PEELED UP AND CUT ME SEVERAL TIMES BEFORE I HAD THE PIECE REPLACED OUT OF MY WALLET.
NHTSA ODI #11183848
33,000 miles · Feb 21, 2019
Unknown Or OtherInjury
THE SILVER METAL TRIM THAT BORDERS THE GEAR SHIFTER HAS STARTED TO PEEL AWAY FROM THE PLASTIC BASE TRIM UNDERNEATH. THIS IS A DESIGN FLAW AND WAS DONE BECAUSE IT IS CHEAPER TO MAKE A FLAT METAL PLATE AND JUST GLUE IT ON TOP OF THE BASE PLATE THAN IT IS TO MAKE AN EDGE THAT ROLLS OVER AND DOWN THE SIDE OF THE BASE PLATE IT IS GLU…
Read full complaint
THE SILVER METAL TRIM THAT BORDERS THE GEAR SHIFTER HAS STARTED TO PEEL AWAY FROM THE PLASTIC BASE TRIM UNDERNEATH. THIS IS A DESIGN FLAW AND WAS DONE BECAUSE IT IS CHEAPER TO MAKE A FLAT METAL PLATE AND JUST GLUE IT ON TOP OF THE BASE PLATE THAN IT IS TO MAKE AN EDGE THAT ROLLS OVER AND DOWN THE SIDE OF THE BASE PLATE IT IS GLUED TO. SO IN ESSENCE WHEN IT SEPARATES, IT'S BASICALLY A RAZOR BLADE EDGE BECAUSE IT IS SO THIN. MY WIFE HAS CUT HER HAND OPEN ON THIS AS HAVE SEVERAL OTHER PEOPLE ON FORUMS SO THIS APPEARS TO BE A COMMON ISSUE.
NHTSA ODI #11181722
28,000 miles · Feb 20, 2019
Unknown Or OtherInjury
THE CHROME TRIM DETAIL AROUND THE GEAR SELECTOR BASE PEELED UP SLIGHTLY RIGHT IN FRONT OF THE STORAGE CUBBY. IT IS NOT VISIBLE FROM A NORMAL SEATED POSITION THAT IT PEELED UP. WHEN REMOVING AN ITEM FROM THE STORAGE CUBBY THE PEELED UP METAL DEEPLY SLICED MY FINGER AND IT BLED FOR HOURS. THE PEELED UP METAL IS RAZOR SHARP. TH…
Read full complaint
THE CHROME TRIM DETAIL AROUND THE GEAR SELECTOR BASE PEELED UP SLIGHTLY RIGHT IN FRONT OF THE STORAGE CUBBY. IT IS NOT VISIBLE FROM A NORMAL SEATED POSITION THAT IT PEELED UP. WHEN REMOVING AN ITEM FROM THE STORAGE CUBBY THE PEELED UP METAL DEEPLY SLICED MY FINGER AND IT BLED FOR HOURS. THE PEELED UP METAL IS RAZOR SHARP. THE VW DEALER WAS FAMILIAR WITH THE ISSUE ON SIMILAR VEHICLES AND REPLACED THE ENTIRE ASSEMBLY. THIS HAPPENED IN DECEMBER 2017. I AM REPORTING IT NOW AFTER HEARING OF SEVERAL SIMILAR OCCURRENCES WITH THIS MAKE/MODEL.
NHTSA ODI #11181359
10,000 miles · Jan 27, 2019
Unknown Or Other
REPEATED HARD KNOCK COMING FROM THE FRONT OF THE CAR WHEN ACCELERATING QUICKLY FROM A DEAD STOP. SUSPECTED THE ENGINE MOUNT AND TRANSMISSION MOUNTS. SIMILAR REPORTS HAVE BEEN REPORTED BY OTHER OWNERS ONLINE. NOISE DOES NOT OCCUR ONCE THE CAR IS IN MOTION.
NHTSA ODI #11172436
14,000 miles · Jun 28, 2018
Unknown Or Other
I WAS DRIVING AT AROUND 15MPH IN A RESIDENTIAL AREA WHEN I HEARD THE LOUD SOUND LIKE A GUNSHOT. I STOPPED IMMEDIATELY AND WENT OUTSIDE TO FIND THAT MY SUNROOF WAS SHATTERED. THAT WAS NOTHING ON THE GROUND THAT COULD'VE HIT THE SUNROOF OR WAS THERE ANYTHING HIGH NEARBY (TREES, BUILDINGS, ETC.) THAT SOMETHING COULD'VE FELL FROM.
NHTSA ODI #11104517
Official recalls
4Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Jul 27, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
Remedy: Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.
Aug 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Sep 7, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration