NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
13 reportsClear category filterMileage unknown · Feb 21, 2026
EngineForward Collision AvoidanceFuel/propulsion System
NHTSA Recall 24V-110 (VW 20UF). The vehicle is in Limp Mode and experiencing low oil pressure symptoms. It is also subject to Recall 24V-110, which identifies a fire risk due to fuel leakage. Despite the safety hazard, the local Volkswagen dealership has refused to perform the recall repair or diagnose the vehicle, stating it is…
Read full complaint
NHTSA Recall 24V-110 (VW 20UF). The vehicle is in Limp Mode and experiencing low oil pressure symptoms. It is also subject to Recall 24V-110, which identifies a fire risk due to fuel leakage. Despite the safety hazard, the local Volkswagen dealership has refused to perform the recall repair or diagnose the vehicle, stating it is at their 'discretion.' I am reporting a failure by the manufacturer and the dealer to remedy an active safety defect, leaving me with an unsafe, undriveable vehicle."
NHTSA ODI #11719667
Mileage unknown · Jan 15, 2026
Fuel/propulsion SystemUnknown Or Other
I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refuel…
Read full complaint
I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refueling (fuel pump nozzle repeatedly shut off even with a low fuel level). These symptoms were similar to prior EVAP system failures that required replacement of the charcoal canister and EVAP purge (N80) valve earlier in 2025. I brought the vehicle to the dealership on December 29, 2025, specifically requesting completion of Recall 20UF and inspection/replacement of EVAP components if necessary. The dealership initially refused to perform the recall unless I returned the vehicle with less than one-quarter tank of fuel, despite the recall documentation specifying that fuel extraction equipment (VAS5190A or equivalent) is required for this repair. A diagnostic report generated by the dealership listed a “Fuel Pump (in tank)” replacement as a customer-pay repair before later removing it once it was identified as recall-related. After significant delays, the dealership stated the recall had been completed and declined to replace any EVAP components. Since the recall service, the vehicle continues to experience intermittent shuddering and difficulty accelerating. While refueling has temporarily improved, drivability concerns persist, raising questions about whether the recall repair was properly performed and whether the vehicle remains safe to operate. I am concerned about inconsistent handling of a safety recall, improper diagnostic practices, and continued fuel-system-related drivability issues that may pose a safety risk.
NHTSA ODI #11711276
Mileage unknown · Aug 1, 2025
Fuel/propulsion System
Fuel is leaking from near the gas tank when the car is running and creates a puddle- I took my car to the local VW dealership in February to get the Suction Jet Pump Recall completed.
NHTSA ODI #11677730
Mileage unknown · Apr 23, 2021
Fuel/propulsion System
THE CAR ON IS LEAKING GASOLINE FROM BACK OF THE GAS TANK, THE CAR VAS IN MOTION AND I SMELL GASOLINE FROM MY CAR AND MAY CAUSE A FIRE BECAUSE IS NEAR THE WHEEL.
NHTSA ODI #11413570
18,090 miles · Feb 15, 2021
Fuel/propulsion System
THE SUCTION PUMP (PART 5Q0-201-029) IN THE EVAP EMISSION CONTROL OF MY VEHICLE FAILED ON FEBRUARY 7 2021 CAUSING FUEL TO BE BROUGHT INTO THE CHARCOAL CANISTER AND THEN INTO THE PURGE VALVE. THIS LED TO HEAVY FUEL SMELL IN MY VEHICLE AND REQUIRED REPLACEMENT OF SUCTION PUMP, CHARCOAL CANISTER AND PURGE VALVE. NOTE THAT THIS FAILU…
Read full complaint
THE SUCTION PUMP (PART 5Q0-201-029) IN THE EVAP EMISSION CONTROL OF MY VEHICLE FAILED ON FEBRUARY 7 2021 CAUSING FUEL TO BE BROUGHT INTO THE CHARCOAL CANISTER AND THEN INTO THE PURGE VALVE. THIS LED TO HEAVY FUEL SMELL IN MY VEHICLE AND REQUIRED REPLACEMENT OF SUCTION PUMP, CHARCOAL CANISTER AND PURGE VALVE. NOTE THAT THIS FAILURE WITH EXACT SAME DESCRIPTION WAS IDENTIFIED AS PART OF THE SAFETY RECALL 20Y6 (HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2016/RCRIT-16V647-1179.PDF) ISSUED BY NHSTA ON OCTOBER 13 2016 AND MY VEHICLE WAS PART OF THIS RECALL. IT WAS CLAIMED THAT THE ISSUE WAS FIXED ON MY VEHICLE ON JUNE 28 2017 AS PART OF THIS RECALL BY VW DEALERSHIP. HOWEVER, THE SUCTION PUMP WHICH FAILED ON FEBRUARY 7 2021 HAD THE MANUFACTURING DATE STAMP OF 15.08.15 WHICH INDICATES THAT PERHAPS VW DIDN'T REPLACE THE SUCTION PUMP AS PART OF THE RECALL REPAIR OR REPLACED IT WITH ANOTHER FAULTY SUCTION PUMP WHICH STILL HAD THE ISSUE (SINCE THE MANUFACTURING DATE OF THE FAILED SUCTION PUMP IS ALMOST 2 YEARS BEFORE THE DATE OF RECALL REPAIR). VW OF AMERICA HASN'T PROVIDED ME CLEAR ANSWERS TO MY QUESTIONS STATED BELOW (SEE ATTACHED LETTER DATED FEBRUARY 13 2021, THAT I SENT TO VW OF AMERICA RAISING THESE CONCERNS): I) WOULD THIS SUCTION PUMP THAT FAILED AND WHICH WAS MANUFACTURED ON 15.08.15 WILL HAVE THE FIX FOR THE ISSUE IDENTIFIED IN 20Y6? II) WHAT WAS THE MANUFACTURING DATE OF THE SUCTION PUMP ORIGINALLY INSTALLED ON MY VEHICLE BEFORE THE RECALL REPAIR WAS PERFORMED? VW OF AMERICA REPLIED TO ME ON FEBRUARY 15 2021 STATING THAT THEY WON'T HELP ME WITH THIS REPAIR AS THE PART WAS OUT OF WARRANTY. HOWEVER, THEY DIDN'T PROVIDE ME ANSWERS TO THE SPECIFIC QUESTIONS I RAISED. IF THE RECALL REPAIR WAS NOT DONE PROPERLY, ISN'T VW STILL RESPONSIBILE TO FIX THE ISSUE THAT MY VEHICLE SUFFERED AND I WOULD ALSO LIKE THEM TO PROVIDE ME CLEAR ANSWERS TO THE ABOVE TWO QUESTIONS.
NHTSA ODI #11396358
Mileage unknown · Dec 14, 2020
EngineFuel/propulsion SystemUnknown Or Other
IT SUCKS IN TOO MUCH AIR AND FAILS AS IF IT HAD A SPARKPLUG FAULT IT WASTES TOO MUCH GAS AND SOMETIMES SUFFOCATES AND WANTS TO TURN OFF
NHTSA ODI #11383274
47,215 miles · Oct 19, 2020
Fuel/propulsion System
SUCTION PUMP INSIDE GAS TANK ALLOWED GAS TO COLLECT WITHIN THE EVAPORATIVE-EMISSION SYSTEM. THIS FILLED THE CHARCOAL CANISTER FILTER WITH LIQUID GASOLINE. THIS GASOLINE SPILLED OUT INTO THE CAR ON THE PASSENGER SIDE REAR WHEEL WELL AND ON TO THE GARAGE FLOOR. I HAD ABOUT ONE QUARTER (1/4) OF A TANK OF GAS IN THE CAR WHEN I PA…
Read full complaint
SUCTION PUMP INSIDE GAS TANK ALLOWED GAS TO COLLECT WITHIN THE EVAPORATIVE-EMISSION SYSTEM. THIS FILLED THE CHARCOAL CANISTER FILTER WITH LIQUID GASOLINE. THIS GASOLINE SPILLED OUT INTO THE CAR ON THE PASSENGER SIDE REAR WHEEL WELL AND ON TO THE GARAGE FLOOR. I HAD ABOUT ONE QUARTER (1/4) OF A TANK OF GAS IN THE CAR WHEN I PARKED IN MY HOME GARAGE AFTER A SHORT DRIVE TO DAIRY QUEEN TO PICK UP A BLIZZARD ICE CREAM BIRTHDAY CAKE. WHEN MY ROOMMATE PULLED INTO THE GARAGE SHE SAID SHE SMELLED GAS. I WENT BACK INTO THE GARAGE AND IT SMELLED VERY STRONGLY OF GAS. I LOOKED UNDER THE CAR AND THERE WAS A GOOD SIZE PUDDLE OF GAS UNDER THE PASSENGER SIDE REAR TIRE. I BACKED THE CAR OF MY HOME GARAGE AND DROVE STRAIGHT TO THE NEAREST OPEN MECHANIC SHOP. THEY REMOVED THE REAR TIRE AND THE INNER FENDER WELL. THEN WE COULD SEE THE CHARCOAL CANNISTER WAS LEAKING LIQUID GASOLINE. I CHECKED THE VIN NUMBER WITH VW ONLINE AND THERE WAS RECALLS FOR 2015-2016 VW GTI BUT THE RECALL DID NOT INCLUDE MY CAR SPECIFIC VIN NUMBER. THE MECHANIC REPLACED THE CANNISTER AND FUEL TANK. VW HAD A NEW PART NUMBER FOR A NEW DESIGN TANK THAT SUPERSEDED THE OLD PART NUMBER AND REQUIRED NEW GAS LINES TOO. CAR HAS BEEN REPAIRED WITH MY ONW MONEY AND SEEMS TO RUN FINE WITH NO SMELL OF GAS OR VISIBLE LEAKS. I SPOKE WITH THE VW DEALER WHERE I PURCHASED THE CAR THIS MORNING AND THEN SPOKE WITH VW CUSTOMER CARE THIS AFTERNOON. THEY BOTH SAID ONCE A RECALL HAS BEEN ISSUED I CAN SUBMIT FOR REIMBURSEMENT. THIS WAS A VERY DANGEROUS PROBLEM THAT COULD HAVE CAUGHT FIRE WITH ME IN THE CAR OR PARKED IN MY HOME GARAGE COULD HAVE INJURED MY FAMILY AND OUR DOG. *LN*JB VIN [XXX} was not included in the recall. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”
NHTSA ODI #11365177
65,000 miles · Aug 25, 2020
Fuel/propulsion System
TURBO FAILED AFTER 65,000 MILES.
NHTSA ODI #11351096
52,415 miles · Aug 3, 2020
EngineFuel/propulsion System
AT THE GAS STATION, THE VEHICLE DOES NOT ALLOW FOR NORMAL FUEL UP TO OCCUR. THE PUMP NOZZLE KEEPS CLICKING OFF AND I CAN'T PUT MORE THAN 1/4 TANK OF GAS WITHOUT THE FUEL SPILLING OUT OF THE TANK FILLER NECK/TUBE. WHILE DRIVING, THE VEHICLE IS EXPERIENCING POWER LOSS THAT CAN BE FELT AS A SUDDEN "BUCKING" MOTION WHEN ACCELERAT…
Read full complaint
AT THE GAS STATION, THE VEHICLE DOES NOT ALLOW FOR NORMAL FUEL UP TO OCCUR. THE PUMP NOZZLE KEEPS CLICKING OFF AND I CAN'T PUT MORE THAN 1/4 TANK OF GAS WITHOUT THE FUEL SPILLING OUT OF THE TANK FILLER NECK/TUBE. WHILE DRIVING, THE VEHICLE IS EXPERIENCING POWER LOSS THAT CAN BE FELT AS A SUDDEN "BUCKING" MOTION WHEN ACCELERATING NORMALLY AND AT CONSTANT CRUISE SPEEDS ABOVE 40 MPH. THE VOLKSWAGEN DEALER DIAGNOSIS REPORTED PLUGGED EVAP CANISTER VENT LINES AND FUEL TANK AND RECOMMENDED REPLACEMENT. THE CAR ONLY HAS 52,500 MILES AND I'M THE ORIGINAL OWNER. MANY OWNERS OF THIS YEAR MODEL IN OTHER STATES ARE REPORTING THE EXACT SAME FUEL UP ISSUE ON INTERNET AUTO FORUMS.
NHTSA ODI #11343104
40,000 miles · Dec 10, 2018
Fuel/propulsion System
SOMETIMES, AFTER THE CAR HAS WARMED UP AND UNDER HARD ACCELERATION THERE IS A RATTLING NOISE COMING FROM THE LOWER ENGINE AREA. THE VW DEALER INVESTIGATED AND CONFIRMED IT IS THE FUEL LINES RATTLING THAT IS MAKING THE NOISE. THEY TRIED TO INSERT SOME DAMPENING MATERIAL TO SECURE THE FUEL LINES BUT THE NOISE PERSISTS.
NHTSA ODI #11160616
Official recalls
4Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Jul 27, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
Remedy: Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.
Aug 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Sep 7, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration