Electrical SystemEngine And Engine CoolingFuel System, Gasoline
SINCE CAR WAS BOUGHT IN 2001 MIL LIGHT HAS BEEN COMING ON IN RAINING CONDITIONS. VW SAID IT WAS THE CATALYTIC CONVERTER AND REPLACED IN AT NO CHARGE IN MARCH OF 2003. SINCE REPLACEMENT LIGHT STILL COMES ON, AND IS NOW PERMANENTLY ON. WHEN CAR IS WET YOU CAN SEE SPARKS COMING FROM THE IGNITION COIL. THERE ARE NOTICEABLE CRACKS IN…
Read full complaint
SINCE CAR WAS BOUGHT IN 2001 MIL LIGHT HAS BEEN COMING ON IN RAINING CONDITIONS. VW SAID IT WAS THE CATALYTIC CONVERTER AND REPLACED IN AT NO CHARGE IN MARCH OF 2003. SINCE REPLACEMENT LIGHT STILL COMES ON, AND IS NOW PERMANENTLY ON. WHEN CAR IS WET YOU CAN SEE SPARKS COMING FROM THE IGNITION COIL. THERE ARE NOTICEABLE CRACKS IN THE COIL HOUSING. *******EPA REFERENCE INFORMATION(IHTTP://WWW.EPA.GOV/OTAQ/CERT/RECALL/420B04018.PDF) *******EPA STATES THE FOLLOWING: CYLINDER IGNITION COIL FAILURE. CAUSING THE ENGINE TO MISFIRE AND ILLUMINATE THE MALFUNCTION INDICATOR LAMP (MIL). TWO SEPARATE FAILURE MODES MAY EXIST WITHIN THE DEFECTIVE IGNITION COILS TESTED, (1)COIL HOUSING DAMAGE CAUSED DURING THE ASSEMBLY PROCESS AT THE APPLICABLE VW OR AUDI FACTORY, (2)COIL DESIGN SHORTCOMINGS BY THE SUPPLIER. *****************NOTE: THE 2002 GOLF GTI VR6 (ENGINE CLASS 2VWXV02.8224) AND THE 2001 EURO VAN VR6 (ENGINE CLASS 1VWXV02.8225)USE THE SAME IGNITION COILS AS MY CAR, THE 2001 GOLF GTI VR6 (ENGINE CLASS 1VWXV02.8224). PLEASE HELP TO INCLUDE MY CALL THE 2001 GOLF GTI (VR6). MY CAR IS NOW AND HAS BEEN GOING THROUGH ALL KINDS OF ELECTRICAL ISSUES, EXCESS FUEL CONSUMPTION, EMISSIONS FAULTS, LOSS OF POWER ENGINE POWER WHILE DRIVING, EXCESS OIL COMSUMPTION ETC. *NM
NHTSA ODI #10155392
45,000 miles · Aug 16, 2005
Fuel System, GasolineFuel System, Other
DT: THE ENGINE WILL BUCK OR STALL AND THEN COMPLETELY SHUT DOWN. THIS HAPPENED AT ALL SPEEDS AND EVEN AT AN IDLE. HAS BEEN TO THE DEALER 4 TIMES. THE DEALER CANNOT FIND THE CAUSE OF THE PROBLEM. VEHICLE HAS BEEN DIAGNOSTICALLY TESTED. ALSO, FUEL INJECTION WA SCLEANED. AT ANOTHER TRIP TO THE DEALER, AND THEY REPLACED…
Read full complaint
DT: THE ENGINE WILL BUCK OR STALL AND THEN COMPLETELY SHUT DOWN. THIS HAPPENED AT ALL SPEEDS AND EVEN AT AN IDLE. HAS BEEN TO THE DEALER 4 TIMES. THE DEALER CANNOT FIND THE CAUSE OF THE PROBLEM. VEHICLE HAS BEEN DIAGNOSTICALLY TESTED. ALSO, FUEL INJECTION WA SCLEANED. AT ANOTHER TRIP TO THE DEALER, AND THEY REPLACED THE FUEL PUMP AND FILTER, AND DID ANOTHER DIAGNOSTIC TEST. CURRENTLY, THE VEHICLE IS IN THE DEALERSHIP FOR THE SAME REASON AWAITING REPAIRS. CONTACTED THE MANUFACTURER, AN AREA REPRESENTATIVE CAME TO INSPECT THE VEHICLE, NO INFORMATION ON HIS FINDINGS. *AK
NHTSA ODI #10133042
39,000 miles · Apr 7, 2003
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
MY BLINKERS STOPPED WORKING IN AUGUST 2002. DEALER REPAIRED UNDER WARRANTY. JANUARY 2003 CHECK ENGINE LIGHT CAME ON. CAR OFF WARRANTY; TURBO CUT OFF VALVE REPLACED AND COOLANT TEMP SENSOR. CHECK ENGINE LIGHT CAME ON A COUPLE WEEKS LATER. TOOK GTI TO DEALER AGAIN. DEALER REPLACED THE FUEL PUMP RELAY. NOW, 3 DAYS LATER THE CH…
Read full complaint
MY BLINKERS STOPPED WORKING IN AUGUST 2002. DEALER REPAIRED UNDER WARRANTY. JANUARY 2003 CHECK ENGINE LIGHT CAME ON. CAR OFF WARRANTY; TURBO CUT OFF VALVE REPLACED AND COOLANT TEMP SENSOR. CHECK ENGINE LIGHT CAME ON A COUPLE WEEKS LATER. TOOK GTI TO DEALER AGAIN. DEALER REPLACED THE FUEL PUMP RELAY. NOW, 3 DAYS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN. *NLM
NHTSA ODI #10014099
Mileage unknown · Feb 22, 2001
Air BagsElectrical SystemFuel System, Gasoline
AIR BAG SENSOR LIGHT STAYED ON. VEHICLE BEEN INTO DEALER ON TWO OCCASIONS, AND PROBLEM STILL REOCCURRING. *AK THE FOG LIGHT BURN OUT WHILE THE VEHICLE WAS NEW. ALSO, THE INTERIOR LIGHTS WERE DEFECTIVE. CHECK ENGINE LIGHT COMES ON REPEATDLY AND FUSE PANEL REPLACED. FUEL PUMP RELAY REPLACED . *YH
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
2001 Volkswagen Gti Problems, Complaints & Recalls | Skip That Year
Illustration