2001 Volkswagen Gti

THE COIL PACK FAILS, I HAVE REPLACED IT TWICE AND NO MATTER WHAT THE CHECK ENGINE LIGHT COMES BACK ON IN NO TIME AT ALL AND IT'S COIL PACK FAILURE, WHICH ALSO TRIGGERS OTHER SENSORS LIKE THE COOLANT SENSOR WHICH I HAVE REPLACED AS WELL. I THINK THE LONGEST TIME MY CHECK ENGINE LIGHT WAS OFF WAS 3 WEEKS! THIS CAR COSTS A FORTUNE TO FIX AND IT'S NEVER FIXED. *TR

ON THE MORNING OF 27 APRIL 2007, I STARTED MY 2001 VOLKSWAGEN GTI 1.8T. THE VEHICLE WAS IDLING VERY ROUGH AND DID NOT SOUND NORMAL. I THOUGHT THAT IT WAS BECAUSE THE VEHICLE WAS COLD. AT THIS POINT IT BACKED OUT OF MY DRIVEWAY AND DROVE DOWN THE ROAD. APPROXIMATELY A MILE OR TWO DOWN THE ROAD I CAME TO A STOP SIGN AND AFTER STOPPING AND THEN PROCEEDING THROUGH THE INTERSECTION MY VEHICLE SEEMED LIKE IT HAD LITTLE OR NO POWER TO THE ENGINE. AT THIS POINT MY CHECK ENGINE LIGHT STARTED FLASHING SO I IMMEDIATELY PULLED OF TO THE SIDE OF THE ROAD AND SHUT OFF MY ENGINE. I THEN OPENED MY HOOD AND SMOKE POURED OUT OF THE ENGINE COMPARTMENT. AT THIS POINT I CHECKED MY OIL TO SEE IT IT SMELT BURNT WHICH IT DID NOT. I THEN CHECKED MY COOLANT LEVEL AND IT WAS FULL AND WASN'T EVEN WARM. I THEN HAD MY VEHICLE TOWED TO MY MECHANIC AND HE DIAGNOSED MY VEHICLE AND TOLD ME THAT 1 OF THE 4 COILS IN MY ENGINE HAD STOPPED WORKING AND HAD CAUGHT ON FIRE AND THAT'S WHAT HAD CAUSED THE SMOKE AND THE CHECK ENGINE LIGHT. HE ALSO SAID THE ALL FOUR NEED TO BE REPLACED OR THIS COULD HAPPEN AGAIN. AT THIS POINT ALL FOUR COILS WERE REPLACED AND THE OLD ONES WERE GIVEN TO ME TO KEEP AS PROOF THAT THE PARTS WERE DEFECTIVE. *JB

SINCE CAR WAS BOUGHT IN 2001 MIL LIGHT HAS BEEN COMING ON IN RAINING CONDITIONS. VW SAID IT WAS THE CATALYTIC CONVERTER AND REPLACED IN AT NO CHARGE IN MARCH OF 2003. SINCE REPLACEMENT LIGHT STILL COMES ON, AND IS NOW PERMANENTLY ON. WHEN CAR IS WET YOU CAN SEE SPARKS COMING FROM THE IGNITION COIL. THERE ARE NOTICEABLE CRACKS IN THE COIL HOUSING. *******EPA REFERENCE INFORMATION(IHTTP://WWW.EPA.GOV/OTAQ/CERT/RECALL/420B04018.PDF) *******EPA STATES THE FOLLOWING: CYLINDER IGNITION COIL FAILURE. CAUSING THE ENGINE TO MISFIRE AND ILLUMINATE THE MALFUNCTION INDICATOR LAMP (MIL). TWO SEPARATE FAILURE MODES MAY EXIST WITHIN THE DEFECTIVE IGNITION COILS TESTED, (1)COIL HOUSING DAMAGE CAUSED DURING THE ASSEMBLY PROCESS AT THE APPLICABLE VW OR AUDI FACTORY, (2)COIL DESIGN SHORTCOMINGS BY THE SUPPLIER. *****************NOTE: THE 2002 GOLF GTI VR6 (ENGINE CLASS 2VWXV02.8224) AND THE 2001 EURO VAN VR6 (ENGINE CLASS 1VWXV02.8225)USE THE SAME IGNITION COILS AS MY CAR, THE 2001 GOLF GTI VR6 (ENGINE CLASS 1VWXV02.8224). PLEASE HELP TO INCLUDE MY CALL THE 2001 GOLF GTI (VR6). MY CAR IS NOW AND HAS BEEN GOING THROUGH ALL KINDS OF ELECTRICAL ISSUES, EXCESS FUEL CONSUMPTION, EMISSIONS FAULTS, LOSS OF POWER ENGINE POWER WHILE DRIVING, EXCESS OIL COMSUMPTION ETC. *NM

ENGINE MISFIRES ON DAMP MORNINGS CREATING SUDDEN LOSS OF ACCELERATION AND INTERMITTENT STALL CONDITION. MIL LIGHT MAY FLASH BUT DOESN'T REMAIN LIT AFTER EPISODE. DIAGNOSED AS SECOND COIL FAILURE IN JUST 2 YEARS TOTALING OVER $1,200 IN REPAIRS. THIS IS THE VR6 ENGINE WITH A SINGLE COIL UNIT - THE "GOOD" COIL NOT SUBJECT TO VOLKSWAGEN'S SECRET WARRANTY AS OFFERED ON COILS OF OTHER 2001 MODELS AND ON THE 2002 MODEL OF THE VR6. IT WOULD SEEM THE SECRET WARRANTY MAY HAVE BEEN ARBITRARILY LIMITED IN SCOPE. *JB

ON OCTOBER 4, 2005 THE CHECK ENGINE LIGHT ACTIVATED ON MY 2001 VW GTI, UPON BRINGING IT TO MY REPAIR SHOP - THEY NOTIFIED ME THAT MY IGNITION COIL WAS DEFECTIVE AND NEEDED REPLACEMENT, THIS REPAIR COST ME NEARLY $1,000. UPON LEARNING THAT THE IGNITION COIL ON 2001 VW'S WAS DEFECTIVE AND READING A PRESS RELEASE FROM VW THAT STATED IN PART ALL 2001 VW CARS INCLUDING GTI'S EQUIPPED WITH 2.8 LITER VR6 WOULD BE REPLACED AT NO COST" AND ALL CUSTOMERS WILL BE NOTIFIED THAT THIS PART DOESN'T MEET OUR HIGH STANDARDS AND WILL BE REPLACED, I CONTACTED VW AND REQUESTED REIMBURSEMENT FOR MY REPAIR. THEY NOTIFIED ME THAT, CONTRARY TO THE INFO CONTAINED IN THEIR PRESS RELEASE, MY CAR WASN'T ELIGIBLE FOR THIS REPAIR. IT APPEARS THAT THIS IS THE PART REFERENCED IN SERVICE BULLETIN 0401 AND 0402, 10007016 AND 10007205 ON THIS WEBSITE. IT APPEARS THAT VW ISN'T LIVING UP TO THEIR COMMITMENT, THEY NEITHER NOTIFIED ME INITIALLY OR AGREED TO REIMBURSEMENT OR OTHER REMEDY WHEN I CONTACTED THEM TODAY.*JB

VEHICLE IS IN SHOP FOR REPLACEMENT OF CATALYTIC CONVERTER AND MASS AIR FLOW SENSOR, BOTH STILL UNDER WARRANTY BECAUSE THEY ARE EMISSION CONTROL. THE CULPRIT FOR THE FAILURE SEEMS TO BE THE COIL PACK HAS FAILED. THE COIL IS NOT COVERED UNDER WARRANTY AS THE CAR NOW HAS 43,000 MILES AND IS OUTSIDE OF WARRANTY, COST IS ABOUT $800. THE COIL PACK FAILED AND WAS REPLACED AT 19,000 MILES UNDER WARRANTY. WAS TOLD BY DEALER TO EXPECT TO REPLACE THE COIL ABOUT EVERY 2 YEARS. IN ADDITION HAD THE DRIVERS WINDOW CLIPS FAIL TWICE AND THE WINDOW FELL INTO THE DOOR, HORN SHORTED 3 SEPERATE TIMES, THE DEALER FINALLY REPLACED THE RELAY THE 3RD TIME IT CAME IN AND THAT CORRECTED IT.

IGNITION SWITCH HAS FAILED THREE TIMES. FAILURE OF IGNITION SWITCH PREVENTS NORMAL FUNCTIONING OF MANY ELECTRICAL SYSTEMS. THIS PROBLEM IS A FIRE HAZARD. OVERHEATING OF THE SWITCH ASSEMBLY MELTS PLASTIC HOUSING AND DAMAGES INSULATION AND CONDUCTOR OF WIRES CONNECTED TO THE SWITCH. PROBLEM ONLY OCCURS WHEN DRIVING LIGHTS (I.E. HEADLAMP SWITCH PULLED OUT) ARE ON. NO PROBLEM OCCURS WITH DRIVING LIGHTS OFF. PROBLEM MAY BE CAUSED BY INADEQUATE SWITCH DESIGN. DEALER SOLUTION WAS TO REPLACE ENTIRE DASH WIRING HARNESS, WHICH WAS UNACCEPTABLE DUE TO COST. OWNER REPAIRED DAMAGED WIRE WITH VOLKSWAGEN REPAIR KIT AND REPLACED IGNITION SWITCH, AND NO LONGER USES DRIVING LIGHTS. PHOTOS OF FAILED SWITCH AVAILABLE.

FIVE OF THE 6 ENGINE CYLINDERS WERE MISFIRING SO THE VEHICLE FAILED THE STATE EMISSION TEST. THE DEALERSHIP INDICATED THAT THE IGNITION COILS HAD TO BE REPLACED. THEY DIDN'T INDICATE WHAT WAS WRONG WITH THE COILS. THE MANUFACTURER INDICATED THAT THERE A RECALL ON THIS PART ON THIS MODEL BUT THE VEHICLE IDENTIFICATION NUMBER DID NOT FALL WITHIN THE RECALL.(NOT FOUND IN ARTEMIS). *JB

I BOUGHT A VOLKSWAGEN GTI 1.8T IN 2001. IT HAD NUMEROUS FAILURES ON ME. IGNITION COIL FAILURE, WINDOW COLLAPSED SUDENTLY, SHIFT IS STUCK IN PARKING, CATALYST CONVERTER FAILURE, REAR BRAKE PADS WORNED OUT VERY FAST WHILE THE FRONT PAD WAS LIKE NEW. I AM EXTREMELY DISAPPOINTED IN VOLKSWAGEN. THEIR CUSTOMER SERVICE WAS HORRIBLE. ALLLTHEIR RESPONSES WERE THIS IS NOT UNDER THE WARRANTY, IT'S NORMAL WEAR AND TEAR ETC. *AK