← New search

2010 Volkswagen Golf

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

56 reports with mileage · 13 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel System, Diesel. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports0 fire reports0 injury reports

Fuel System, Diesel complaints

22 reports
Clear category filter
23,000 miles · Aug 23, 2011
Fuel System, Diesel

SINCE I FIRST BOUGHT THE TDI GOLF IT HAS BEEN EASY TO STALL, SOMETIMES STALLING WHILE STILL IN MOTION GOING DOWN THE ROAD. AT APPROXIMATELY 20K MILES STALLING BECAME SOMETIMES UNAVOIDABLE NO MATTER HOW MUCH GAS YOU GAVE IT FROM A STOP. THIS CAUSED THE CAR TO PULL OUT INTO TRAFFIC AND STALL, LEAVING ME DEAD IN THE WATER IN DANGER…

Read full complaint

SINCE I FIRST BOUGHT THE TDI GOLF IT HAS BEEN EASY TO STALL, SOMETIMES STALLING WHILE STILL IN MOTION GOING DOWN THE ROAD. AT APPROXIMATELY 20K MILES STALLING BECAME SOMETIMES UNAVOIDABLE NO MATTER HOW MUCH GAS YOU GAVE IT FROM A STOP. THIS CAUSED THE CAR TO PULL OUT INTO TRAFFIC AND STALL, LEAVING ME DEAD IN THE WATER IN DANGEROUS TRAFFIC!! NO MATTER HOW MUCH GAS I GAVE THE CAR OR HOW MUCH I SLIPPED THE CLUTCH IT WOULD STILL SOMETIMES STALL AFTER PROPELLING ME INTO ONCOMING TRAFFIC. I HAVE DRIVEN A MANUAL TRANSMISSION MY ENTIRE LIFE AND I KNOW HOW TO WORK A CLUTCH... THIS PROBLEM IS NOT NORMAL AND MANY FRIENDS WHO I HAVE HAD DRIVE THE CAR AGREE WITH ME. AT APPROXIMATELY 19,000 MILES THE GLOW PLUG LIGHT ILLUMINATED AND BLINKED AFTER STARTING THE ENGINE. THE CAR WOULDN'T GO ABOVE 20MPH. I TURNED OFF THE IGNITION AND RESTARTED WITH NO FURTHER PROBLEM. AT APPROX. 23,000 MILES THE CAR STALLED 4 TIMES IN A ROW AFTER CRANKING THE ENGINE AND ATTEMPTING TO PULL STRAIGHT FORWARD OUT OF A PARKING LOT. AT THIS POINT THE CHECK ENGINE LIGHT CAME ON AND THE GLOW PLUG LIGHT ALSO CAME BACK ON AND BLINKED. THE CAR PERFORMANCE NOW IS TERRIBLE AND IT IS GOING INTO THE DEALERSHIP FOR REPAIR. I AM CONCERNED ABOUT SAFETY AND THE POSSIBILITY OF CONTINUING EXPENSIVE ISSUES I MAY HAVE THAT EXCEED THE WARRANTY PERIOD WITH THIS CAR. PLEASE HELP!!! *TR

NHTSA ODI #10421170

8,000 miles · Aug 9, 2011
Fuel System, Diesel

2010 VOLKSWAGEN GOLF TDI; ON MULTIPLE OCCASIONS VERY NOTICEABLE LOSS OF POWER LASTING 2-5 SECONDS USUALLY WHILE ACCELERATING; NO STALL NOTED BUT VERY DISCONCERTING. HAS OCCURRED MORE THAN 20 TIMES. ALSO, HAS VERY SENSITIVE CLUTCH WITH EASY STALLS FROM START IN 1ST GEAR, HAVE DRIVEN MANUAL-TRANSMISSION CARS FOR 20+ YEARS AND HA…

Read full complaint

2010 VOLKSWAGEN GOLF TDI; ON MULTIPLE OCCASIONS VERY NOTICEABLE LOSS OF POWER LASTING 2-5 SECONDS USUALLY WHILE ACCELERATING; NO STALL NOTED BUT VERY DISCONCERTING. HAS OCCURRED MORE THAN 20 TIMES. ALSO, HAS VERY SENSITIVE CLUTCH WITH EASY STALLS FROM START IN 1ST GEAR, HAVE DRIVEN MANUAL-TRANSMISSION CARS FOR 20+ YEARS AND HAVE NEVER STALLED A CAR WITH SUCH EASE AS THE TDI GOLF. HAS CREATED MULTIPLE DANGEROUS SITUATIONS BUT NO ACCIDENTS. CAR HAS 8K MILES ON IT SO FAR. *TR

NHTSA ODI #10418105

12,000 miles · Jul 1, 2011
Fuel System, Diesel

VW GOLF TDI, 2010. I HAVE 12,000 MILES IN IT. MANUAL TRANSMISSION. STALLING PROBLEM AND OCCASIONAL DECREASE OF POWER FOR SECONDS. NEVER PUT A DROP OF GASOLINE INSTEAD OF DIESEL FUEL. STALLING ONLY OCCURS UPON SHIFTS FROM 1ST INTO 2ND GEAR AT SLOW SPEEDS AND ONLY OCCASIONALLY, I HAVE TO BE UNUSUALLY CAREFUL WHEN DOING IT. I H…

Read full complaint

VW GOLF TDI, 2010. I HAVE 12,000 MILES IN IT. MANUAL TRANSMISSION. STALLING PROBLEM AND OCCASIONAL DECREASE OF POWER FOR SECONDS. NEVER PUT A DROP OF GASOLINE INSTEAD OF DIESEL FUEL. STALLING ONLY OCCURS UPON SHIFTS FROM 1ST INTO 2ND GEAR AT SLOW SPEEDS AND ONLY OCCASIONALLY, I HAVE TO BE UNUSUALLY CAREFUL WHEN DOING IT. I HAVE BEEN DRIVING ONLY MANUAL TRANSMISSION CARS THE PAST 20 YEARS, THIS IS NOT A DRIVER MISTAKE OR INEXPERIENCE WITH MANUAL TRANS. NO OTHER CAR GAVE ME PROBLEM LIKE THIS. TEST-DRIVING THE 2010 JETTA GAVE ME THE SAME TROUBLE. *TR

NHTSA ODI #10410209

19,000 miles · Jun 25, 2011
Fuel System, Diesel

I WAS ON A 350 MILE TRIP, AND I STOPPED AND FILLED UP WITH DIESEL AT A CHEVRON STATION ABOUT 60 MILES INTO THE TRIP. I HAVE THE RECEIPT THAT SAYS "DIESEL" ON IT. THE CAR STARTED FINE AND DROVE FINE UNTIL I STOPPED ABOUT 200 MILES LATER. THEN THE CAR WOULD NOT RESTART RIGHT AWAY. AFTER TRYING IT A FEW TIMES IT STARTED. I FIN…

Read full complaint

I WAS ON A 350 MILE TRIP, AND I STOPPED AND FILLED UP WITH DIESEL AT A CHEVRON STATION ABOUT 60 MILES INTO THE TRIP. I HAVE THE RECEIPT THAT SAYS "DIESEL" ON IT. THE CAR STARTED FINE AND DROVE FINE UNTIL I STOPPED ABOUT 200 MILES LATER. THEN THE CAR WOULD NOT RESTART RIGHT AWAY. AFTER TRYING IT A FEW TIMES IT STARTED. I FINISHED DRIVING THE LAST 90 MILES WITHOUT PROBLEMS AND STOPPED THE CAR AND SHUT IT OFF. THEN THE CAR WOULD NOT RESTART AT ALL. THE NEXT MORNING THE CAR STARTED AND RAN ROUGHLY FOR 30 SECONDS, THEN SMOOTHED OUT AND RAN FINE. I DROVE TO THE DEALER. I HAD READ ABOUT HIGH PRESSURE FUEL PUMP (HPFP) PROBLEMS WITH THESE CARS AND TOLD THEM TO CHECK IT OUT. THEY CALLED THE NEXT DAY AND SAID THE PUMP WAS FINE BUT THAT THEY WERE STILL INVESTIGATING. TWO MORE DAYS LATER THEY SAID THE HPFP WAS BAD DUE TO CONTAMINATED FUEL AND IT NEEDED $8,000 IN REPAIRS. THEY SAID THEY TRIED TO BURN A SAMPLE OF THE FUEL AND IT BURNED, AND THEY SAID THAT DIESEL WON'T BURN, SO THEREFORE THEY SAID THERE WAS GAS IN THE TANK. THEY TOLD ME TO CALL MY INSURANCE SINCE IT WASN'T COVERED UNDER WARRANTY. I CALLED THE CHEVRON STATION WHERE I BOUGHT THE FUEL, AND TO MY AMAZEMENT THEY TALKED TO THEIR DISTRIBUTOR WHO AGREED TO PAY THE CHARGES. I FEEL VERY LUCKY. I THINK THIS IS VOLKSWAGEN'S PROBLEM WITH THESE PUMPS, GIVEN ALL THE OTHER COMPLAINTS AND NO COMPLAINTS FROM CHEVY AND FORD DIESEL PICKUP TRUCK DRIVERS ABOUT "CONTAMINATED FUEL" SINCE WE ALL BUY FUEL AT THE SAME PLACES. NOW I'M SCARED THAT I'LL BE PAYING THE BILL THE NEXT TIME THIS HAPPENS. THE CAR IS A 2010 VW GOLF WITH ONLY 19,000 MILES. THE DEALER TOOK 3 WEEKS TO FIX THE CAR. *TR

NHTSA ODI #10408900

31,000 miles · Jun 15, 2011
Fuel System, Diesel

THE HIGH PRESSURE FUEL PUMP FAILED ON MY 2010 VW GOLF TDI WHILE DRIVING. IT CAUSED THE CAR TO SHUT OFF IN AN INTERSECTION. THE CAR THEN HAD TO BE PUSHED OUT OF THE INTERSECTION AND TOWED TO THE DEALERSHIP. THE FUEL PUMP DAMAGED THE ENTIRE FUEL SYSTEM ONCE IT FAILED. THE ENTIRE FUEL SYSTEM HAD TO BE REPLACED. THE DEALERSHIP WAS…

Read full complaint

THE HIGH PRESSURE FUEL PUMP FAILED ON MY 2010 VW GOLF TDI WHILE DRIVING. IT CAUSED THE CAR TO SHUT OFF IN AN INTERSECTION. THE CAR THEN HAD TO BE PUSHED OUT OF THE INTERSECTION AND TOWED TO THE DEALERSHIP. THE FUEL PUMP DAMAGED THE ENTIRE FUEL SYSTEM ONCE IT FAILED. THE ENTIRE FUEL SYSTEM HAD TO BE REPLACED. THE DEALERSHIP WAS KIND ENOUGH TO DO IT UNDER WARRANTY. *TR

NHTSA ODI #10407044

18,800 miles · Apr 29, 2011
Fuel System, Diesel

2010 VW GOLF TDI LOSS OF POWER AND SUBSEQUENT ENGINE STALL WHILE DRIVING ON A HIGHWAY. THIS HAPPENED ON TWO SEPARATE OCCASIONS AT 17500 MILES AND THEN AGAIN AT 18,800 MILES. THE VW DEALERSHIP REPLACED THE FUEL PUMP UNDER WARRANTY AFTER THE SECOND INCIDENT. I UNDERSTAND VW IS HAVING 2009-2010 HPFP PROBLEMS AND IS CLAIMING THAT 90…

Read full complaint

2010 VW GOLF TDI LOSS OF POWER AND SUBSEQUENT ENGINE STALL WHILE DRIVING ON A HIGHWAY. THIS HAPPENED ON TWO SEPARATE OCCASIONS AT 17500 MILES AND THEN AGAIN AT 18,800 MILES. THE VW DEALERSHIP REPLACED THE FUEL PUMP UNDER WARRANTY AFTER THE SECOND INCIDENT. I UNDERSTAND VW IS HAVING 2009-2010 HPFP PROBLEMS AND IS CLAIMING THAT 90% OF THE FAILURES ARE DUE TO FUEL CONTAMINATION. I HAVE BEEN DRIVING DIESEL CARS FOR 10 YEARS NOW AND I'M THE SOLE DRIVER OF THIS CAR. THERE WAS NO FUEL CONTAMINATION IN THIS CASE. *TR

NHTSA ODI #10398313

10,000 miles · Dec 19, 2010
Fuel System, Diesel

2010 VW GOLF TDI 2DR, 6 SPEED MANUAL: LOSS OF POWER OCCURS ON OCCASION, TYPICALLY UNDER HARD ACCELERATION AFTER SHIFTING FROM 1ST INTO 2ND AND PUSHING DOWN ACCELERATOR, CAR WILL LOSE ALL POWER, BUT NOT STALL, FOR 2-5 SECONDS FOLLOWED BY REGAINING POWER. WHEN IT REGAINS POWER THERE IS A HUGE PLUME OF WHITE SMOKE OUT THE TAIL PI…

Read full complaint

2010 VW GOLF TDI 2DR, 6 SPEED MANUAL: LOSS OF POWER OCCURS ON OCCASION, TYPICALLY UNDER HARD ACCELERATION AFTER SHIFTING FROM 1ST INTO 2ND AND PUSHING DOWN ACCELERATOR, CAR WILL LOSE ALL POWER, BUT NOT STALL, FOR 2-5 SECONDS FOLLOWED BY REGAINING POWER. WHEN IT REGAINS POWER THERE IS A HUGE PLUME OF WHITE SMOKE OUT THE TAIL PIPE THAT QUICKLY DISSIPATES, LEADING ME TO BELIEVE FUEL OR WATER. CAR ALSO DONE EXACTLY SAME EVEN WHILE ATTEMPTING TO PASS A CAR: DOWNSHIFTING FROM 5TH TO 3RD GEAR, HITTING THE ACCELERATOR AND EXACT SAME LAG/LOSS OF POWER. CAR NOW HAS 15K MILES AND I HAVE EXPERIENCED THIS ABOUT 6-10 TIMES OVER THE PAST 6 MONTHS. DEALERSHIP MECHANICS CLAIM THEY CAN NOT REPLICATE OR FIND ANY ERROR CODES PLUS CLAIMING THEY'VE NEVER HEARD OF THIS TYPE OF COMPLAINT, ALSO THEY CLAIM/SUGGEST THIS COULD BE A POOR FUEL ISSUE, SUGGESTING GOING TO ANOTHER GAS STATION. SALESPERSON WHO SOLD ME CAR INFORMED ME, OFF THE RECORD, THIS IS A COMMON COMPLAINT AND THEIR IS SAFETY CAMPAIGN CURRENTLY GOING ON WITH THE 2009 JETTA TDI, BUT CLEARLY THIS IS THE SAME ENGINE AS THE '09. THIS TYPE OF COMPLAINT IS ALSO ALL OVER THE INTERNET AND FOUND IN NUMEROUS COMPLAINTS ON THE 2009 JETTA TDI ON THIS SAME WEBSITE, THEREFORE IT SURE SOUNDS LIKE A COVER-UP WHEN THE MECHANICS TELL ME THEY'VE NEVER HEARD OF ANY COMPLAINTS LIKE THIS??? AS A VETERAN LAW ENFORCEMENT OFFICER AND ACCIDENT INVESTIGATOR FOR THE PAST 20 YEARS, THIS IS A VERY MAJOR SAFETY CONCERN. *TR

NHTSA ODI #10371203

2,000 miles · Oct 29, 2010
Fuel System, Diesel

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN GULF TDI. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE SUDDENLY STALLED. THERE WAS NO POWER STEERING WHEN THE FAILURE OCCURRED SO THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND RESTARTED IT. THE FAILURE OCCURRED TWO ADDITIONAL TIMES AND WAS TOWED TO AN AUTHORIZED DE…

Read full complaint

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN GULF TDI. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE SUDDENLY STALLED. THERE WAS NO POWER STEERING WHEN THE FAILURE OCCURRED SO THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND RESTARTED IT. THE FAILURE OCCURRED TWO ADDITIONAL TIMES AND WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 2,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 6,700. UPDATED 01/06/11*LJ UPDATED 04/07/11

NHTSA ODI #10362907

5,040 miles · Oct 19, 2010
Fuel System, Diesel

NEW VEHICLE TDI FUEL PUMP AND FULL FUEL SYSTEM NEEDS TO BE REPLACED!!! *TR

NHTSA ODI #10361255

11,799 miles · Sep 2, 2010
Fuel System, Diesel

WAS DRIVING AT APPROXIMATELY 65 MPH ON AN ILLINOIS HIGHWAY WHEN I SUDDENLY LOST POWER AND HEARD A TAPPING COMING FROM THE ENGINE AREA. THIS WAS VERY DANGEROUS BECAUSE I WAS ALMOST REAR ENDED AFTER LOSING POWER. THEN DIESEL FUEL STARTED SPRAYING ALL OVER THE CAR AND THE HIGHWAY. PULLED OVER AND FIRE DEPARTMENT CAME TO CLEAN UP…

Read full complaint

WAS DRIVING AT APPROXIMATELY 65 MPH ON AN ILLINOIS HIGHWAY WHEN I SUDDENLY LOST POWER AND HEARD A TAPPING COMING FROM THE ENGINE AREA. THIS WAS VERY DANGEROUS BECAUSE I WAS ALMOST REAR ENDED AFTER LOSING POWER. THEN DIESEL FUEL STARTED SPRAYING ALL OVER THE CAR AND THE HIGHWAY. PULLED OVER AND FIRE DEPARTMENT CAME TO CLEAN UP AS MUCH FUEL AS THEY COULD. CAR WAS TOWED TO LOCAL VW DEALER. IT TURNED OUT THAT THE FUEL LINE TO INJECTOR FOR CYLINDER #2 WAS LEAKING. THEY REMOVED AND REPLACED THIS PART. 03L-130-301-R LINE WAS REPLACED. *TR

NHTSA ODI #10353458

Official recalls

4

18V148000 · Air Bags:frontal:driver Side:inflator Module

Mar 6, 2018

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q9. Note: This recall partially supersedes recall 16V-078.

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

16V078000 · Air Bags:frontal:driver Side:inflator Module

Feb 10, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.