2006 Volkswagen Golf

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE AIR BAG CLOCKSPRING FAILED. AS A RESULT, THE DRIVER'S AIR BAG WOULD NOT TO DEPLOY IN THE EVENT OF A CRASH DUE TO LACK OF ELECTRICITY. THE VEHICLE WAS TAKEN TO SCHUMACHER VOLKSWAGEN (3001 OKEECHOBEE BOULEVARD, WEST PALM BEACH, FL 33409) WHERE IT WAS DIAGNOSED THAT THE CLOCKSPRING FAILED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE MANUFACTURER WARRANTED CLOCKSPRING REPAIR. THE MANUFACTURER ALSO ADVISED THAT THE REPAIR WAS COVERED FOR A THREE YEAR WARRANTY AND 36,000 MILES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 119,390.

THE FRONT HOOD LATCH AND LOCKING MECHANISM HAS A DESIGN ERROR THAT MAKES IT DIFFICULT TO CLOSE AND LOCK THE HOOD. THE HOOD LATCH AND LOCKING MECHANICAL PARTS IN MY OPINOIN NEEDS TO BE MODIFIED TO WORK CORRECTLY. CAR HOODS NEED TO BE SECURED AND LOCK PROPERLY FOR THE SAFE OPERATION OF A VEHICLES. I AM UNABLE TO DRIVER THE VEHICLE BECAUSE THE HOOD WILL NOT CLOSE.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN GOLF. WHILE DRIVING APPROXIMATELY 55 MPH, THE HOOD OF THE VEHICLE UNLATCHED WITHOUT WARNING AND SHATTERED THE WINDSHIELD. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WINDSHIELD, HOOD, AND OTHER UNKNOWN COMPONENTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY WERE UNWILLING TO PAY FOR THE REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE REAR PASSENGER SEAT BELT STITCHING BEGAN TO UNRAVEL. THE DEALER AND MANUFACTURER WERE NOTIFIED BUT DENIED ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 107,000 AND CURRENT MILEAGE WAS 112,000. UPDATED 08/15/11 *BF UPDATED 08/24/11

2006 VW GOLF TDI 70K MILES OF NORMAL DRIVING CONDITIONS IN ILLINOIS. FAILURE OF BOTH DRIVER AND PASSENGER SIDE COIL SPRINGS WITHIN 6 WEEKS OF EACH OTHER. IN EACH CASE THE COIL SPRING BROKE TOWARDS THE END. AT THE TOP ON ONE SIDE, ON THE BOTTOM ON THE OTHER SIDE. COIL SPRINGS ARE GENERALLY FAIRLY STURDY UNDER NORMAL DRIVING CONDITIONS. COULD THERE HAVE BEEN A MANUFACTURE DEFECT? (THE FAILED SPRINGS TO NOT APPEAR TO BE CORRODED AT THE FAILURE POINT, LOOKS MORE LIKE CLEAN SNAP.) *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE IDLES WHEN THE ACCELERATOR PEDAL IS DEPRESSED TO THE FLOOR. THE FAILURE CAUSES THE VEHICLE TO STALL WHILE THE ENGINE IS STILL RUNNING. HE ALSO STATED THAT THE VEHICLE DOES NOT RESPOND TO THE FUEL INJECTION. THE DEALER HAS NOT OFFERED MUCH ASSISTANCE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. THE CURRENT MILEAGE IS 21,000.

I WAS REAR ENDED WHILE MY CAR WAS AT A DEAD STOP. THE PICK UP TRUCK BEHIND ME HIT ME GOING AT AN ESTIMATED SPEED OF 50 MPH CAUSING ME TO HIT THE CAR IN FRONT OF ME. BOTH MY FRONT AND REAR END OF MY CAR SUFFERED SEVERE DAMAGES, BUT MY AIR BAG DID NOT DEPLOY AND MY SEAT CAME UNLOCKED AND CAUSED ME TO SMASH INTO MY STEERING WHEEL AND DASHBOARD. *JB

(1) INTERCOOLER LEAKING OIL @ 16K MILES ON A 2006 VW GOLF TDI. FAILURE IS DUE TO CHAFFING OF THE ALUMINUM INTERCOOLER PIPES BY THE PERPENDICULAR PIECE OF PLASTIC THAT EXTENDS TO IT FROM THE FRONT PASSENGER SIDE GRILL AND TOUCHES THE INTERCOOLER. DURING NORMAL DRIVING, OVER TIME, THE PLASTIC MOVES AND RUBS AGAINST THE INTERCOOLER AND EVENTUALLY CREATES HOLES WHERE OIL LEAKS OUT AND PUDDLES ON THE FRONT SIDE OF THE PASSENGER WHEEL WELL. (2)AS SOON AS I SAW THE OIL PUDDLING IN SMALL 3-5" CIRCLES, I BROUGHT THE CAR TO THE DEALER WHERE THEY VERIFIED MY CONCERN. IF LEFT UNCHECKED, THIS WOULD LEAD TO CONTINUED LOSS OF OIL, LOSS OF BOOST AND EVENTUALLY FAILURE OF THE TURBO. (3)DEALER IS FIXING UNDER WARRANTY, BUT TOLD ME THEY WILL ONLY REPLACE THE INTERCOOLER AND WILL DO NOTHING TO RESOLVE THE ROOT CAUSE OF THE PROBLEM, WHICH IS THAT THE HARD PLASTIC RUBS AGAINST THE SOFT ALUMINUM METAL OF THE INTERCOOLER PIPES AND CAUSES A HOLE. DEALER CLAIMS THERE IS NO TSB FROM VW WHICH IS ABSURD. NUMEROUS INTERNET SEARCHES AND LOOKING ON WWW.TDICLUB.COM SHOW MANY OCCURRENCES OF THIS PROBLEM. IT IS SPECIFIC TO THE TDI VERSION OF THE GOLF SINCE IT HAS A TURBO. AT A MINIMUM, THE PLASTIC NEEDS TO BE TRIMMED AND A PIECE OF FOAM OR SOMETHING SOFT NEEDS TO BE INSERTED SO NOTHING HARD CAN RUB AGAINST THE ALUMINUM INTERCOOLER PIPES. IF THE ROOT CAUSE IS NOT ADDRESSED THEN THIS WILL CONTINUE TO FAIL. IT IS A RELIABILITY CONCERN, A SAFETY CONCERN (LOSS OF BOOST, TURBO FAILURE), AN ENVIRONMENTAL CONCERN (LEAKING OIL) AND A COST CONCERN SINCE EVENTUALLY THE CAR WILL BE OUT OF WARRANTY.*JB

TL*- THE CONTACT OWNS A 2006 VW GOLF 16000 AND STOPPING AND PRESSING ON THE ACCELERATOR THE VEHICLE REVVED UP, BUT DID NOT MOVE. THE CONTACT SAID THAT IT DIDN'T HAPPEN ALL OF THE TIME, AND THE WEATHER CONDITIONS HAVE NOT BEEN A FACTOR. THE CONTACT TOOK THE CAR TO THE DEALER THEY MADE AN ADJUSTMENT, BUT THE CONTACT FELT THAT ITWAS WORSE NOW. *AK