2004 Volkswagen Golf

WHILE I WAS DRIVING ON I-35 IN KANSAS AT ABOUT 60 MPH ON DECEMBER 13, 3007 AT APPROXIMATELY 10:30 PM, THE LATCH TO MY VEHICLE RELEASED WITHOUT WARNING AND CAUSED THE HOOD OF MY VEHICLE TO FLY UP IMPAIRING MY VIEW. I WAS ABLE TO PULL OVER TO THE SHOULDER OF THE HIGHWAY AND CALLED THE KANSAS HIGHWAY PATROL. THE HIGHWAY PATROL OFFICER PUSHED DOWN ON THE HOOD BUT WAS UNABLE GET THE HOOD TO LATCH. DUE TO THE FAILURE OF THE HOOD LATCH MY HOOD HAS BEEN DAMAGED. I CHECKED YOUR WEBSITE FOR COMPLAINTS FOR THE SAME YEAR, MAKE, AND MODEL AND DISCOVERED THIS DEFECT HAD HAPPENED PREVIOUSLY TO THE SAME VEHICLE. *TR

MY WIFE WAS TAKING A SHORT TRIP TO PICK ME UP FROM WORK IN OUR 2004 VW GOLF, WHEN THE CLUTCH FAILED SUDDENLY AT A TRAFFIC LIGHT. SHE WAS ABLE TO CONTINUE, BUT THE CLUTCH WAS FAILING TO FULLY DISENGAGE. FORTUNATELY, SHE WAS ON SURFACE STREETS AND DID NOT HAVE TO DRIVE AT HIGHWAY SPEEDS. WE LIMPED HOME AND REQUESTED TO HAVE THE VEHICLE TOWED TO A VW SERVICE CENTER. THE SERVICE CENTER INDICATED THAT THE CLUTCH FAILURE WAS DUE TO WEAR AND WAS NOT A WARRANTY ITEM. WE HAD NO INDICATIONS OF IMPENDING FAILURE (SLIPPAGE, DIFFICULTY PUTTING IN GEAR, VIBRATIONS, STRANGE NOISES, ETC.) AND MY WIFE AND I ARE BOTH EXPERIENCED USERS OF MANUAL TRANSMISSIONS. THE SERVICE CENTER MADE THE REPAIRS (TOTAL COST OVER $1900) AND WE HAVE RESUMED USING THE VEHICLE. *TR

GLOW PLUG LIGHT BEGAN TO FLASH WHILE DRIVING, RESEARCHED THIS PROBLEM ON THE INTERNET AND FOUND THAT THERE HAVE BEEN RECALLS FOR PREVIOUS MODEL YEARS AND CHECKED MY VEHICLE. THOUGH MY VEHICLE DOES NOT FALL INTO THE RECALL YEARS AND I HAVE NOT RECEIVED AN NOTIFICATION ABOUT A RECALL THE BRAKE LIGHT SWITCH HAS FAILED ON MY VEHICLE RESULTING IN MY BRAKE LIGHTS NOT LIGHTING WHEN I BRAKE. THIS IS A HAZARD TO ME AND OTHER DRIVERS ON THE ROAD. *JB

2004 VOLKSWAGEN GOLF TDI 1.9 I NOTICED THE FUEL MILEAGE STARTED TO DECREASE AND THE VEHICLE STARTED TO PRODUCE EXCESS SMOKE. THE PROBLEM CONTINUED TO GET WORSE OVER THE COURSE OF THE NEXT 2 MONTHS. THE OIL CHANGES WERE CONDUCTED WITH 0W40 SYNTHETIC OIL RECOMMENDED BY THE MANUFACTURE. THE FUEL FILTER WAS CHANGED AT 20K, 42K, 50K AND 70K TO HELP REDUCE THE SLUGGISHNESS OF THE ENGINE. NOTHING APPEARED TO CORRECT THE PROBLEM. AT 73500 MILE THE ENGINE BEGAN TO LOSE POWER DURING ACCELERATION AND UNDER A LOAD. THE ENGINE ALSO DEVELOPED A SKIP RESULTING IN THE ENGINE LIGHT INDICATOR TURNING ON. I DROVE THE VEHICLE TO THE VOLKSWAGEN DEALER AND INDICATED ALL OF THE ABOVE PROBLEMS TO THE SERVICE REPRESENTATIVE. THE SERVICE SECTION CHECKED AND REPLACED THE MASS AIR FLOW SENSOR AND OXYGEN SENSOR. INFORMED ME THE PROBLEM WAS CORRECTED. I PICKED UP MY VEHICLE AND DROVE LESS THAN ONE BLOCK AND COULD NOT STAY IN THE FLOW OF TRAFFIC BECAUSE OF THE LACK OF POWER. I RETURNED TO THE SERVICE SECTION AND DROPPED THE VEHICLE FILLING OUT THE PAPERWORK REINFORCING THE SAME PROBLEMS AS ABOVE. THE VEHICLE HAD EXTREME HESITATION, LACK OF POWER AND EXCESSIVE SMOKE UNDER ACCELERATION AND LOAD. THE SERVICE TECH CHECK THE ENGINE AND FOUND THAT THE CAMSHAFT HAD NO LOBES ON THE 1 AND 2 CYLINDER AND THE NUMBER 3 CYLINDER WAS BEGINNING TO LOSE THE LOBE OR ROUNDED. THE LACK OF THE LOBE PREVENTED THE INTAKE AND EXHAUST VALVES TO PROPERLY OPEN AND CLOSE TO ALLOW FUEL MIXTURE INTO THE CYLINDER AND THE EXHAUST TO BE REMOVED FROM THE CYLINDER. THIS PROBLEM COULD ONLY BE CORRECTED BY REPLACING THE ENTIRE HEAD. THE WEAR ON THE CAMSHAFT IS VERY NOTICEABLE AND ABOVE THE NUMBER 1 CYLINDER THE CAMSHAFT HAS A DEEP SCRATCH OR GOUGE IN THE MIDDLE OF THE LOBE. THE SERVICE TECHNICIAN HAD NO EXPLANATION FOR THE ROUNDING OF THE LOBES OR THE SCRATCH OR GOUGE IN THE LOBE. *NM

THE ENGINE MADE A SOUND AS IF AIR UNDER PRESSURE WAS BEING RELEASED, ALONG WITH A QUITE NOTICEABLE VIBRATION WHEN TURNING IT OFF ON THE EVENING OF 30 AUG 2005. ENROUTE TO THE DEALER TO BE CHECKED ON 31 AUG 2005, WHEN ATTEMPTING TO STOP, I PUSHED THE BRAKE PEDAL TO THE FLOOR, TWICE, WITH NO RESPONSE FROM THE BRAKE SYSTEM. AS A RESULT, I HIT THE TRAILER HITCH OF A STOPPED SUV. MINIMAL DAMAGE TO THE SUV; HOWEVER, CONSIDERABLE DAMAGE TO THE GOLF. NO REPAIR WORK DONE YET; THE BRAKE PEDAL HAS SLIGHT RESISTANCE NOW. THE DEALER PROMISED TO CHECK THE OBDII FOR FAULT CODES, BUT HAS NOT DONE SO YET. *NM