PTC auxiliary heater core connection point failure . It was reported that the wrong type of metal was used for the main electrical connection point for this part causing significant over heating further leading to melting and burning plastic. This then introduces potentially dangerous fumes into the vehicle cabin via the HVAC sy…
Read full complaint
PTC auxiliary heater core connection point failure . It was reported that the wrong type of metal was used for the main electrical connection point for this part causing significant over heating further leading to melting and burning plastic. This then introduces potentially dangerous fumes into the vehicle cabin via the HVAC system. If unaddressed this would likely cause fire damage. The problem has been reproduced by multiple vehicle owners and happens during cold conditions as it supplies heat to the cabin prior to the engine hitting optimal operating temperatures. No warning messages or codes are thrown as a result of this issue. It is a hazard and could cause harm to operators of the vehicles affected.
NHTSA ODI #11699778
Mileage unknown · Dec 30, 2024
Electrical SystemEngine
In the last year, my car has experienced multiple instances of the Diesel Particulate Filter (DPF) warning light, check engine light, and a flashing glow plug light on the dashboard. Despite multiple visits and repairs at Sheehy Volkswagen of Springfield, these issues persist, particularly in sub-freezing temperatures. Upon inde…
Read full complaint
In the last year, my car has experienced multiple instances of the Diesel Particulate Filter (DPF) warning light, check engine light, and a flashing glow plug light on the dashboard. Despite multiple visits and repairs at Sheehy Volkswagen of Springfield, these issues persist, particularly in sub-freezing temperatures. Upon independent inspection of the engine compartment, I found multiple exposed wires, broken wires, and poorly repaired broken wires. The most significant concerns are as follows: Repeated DPF Issues: Over the last three years, the DPF warning and related issues have recurred each winter. Initial attempts to rectify the issue included a DPF regeneration procedure, which temporarily cleared the fault codes but did not address the underlying problem. The DPF was finally replaced in mid-2024, yet the same problems manifested with a brand new component just months later. Extended Repair Time: Sheehy Volkswagen of Springfield had my vehicle for a total of six months (Dec-23 to May-24), during which they were unable to diagnose or fix the problem despite escalating the case to Volkswagen HQ (Business Case Numbers: BT1167682 and BT1177805). This delay is unacceptable. Poor Customer Service: Throughout this period, customer service was unsatisfactory. I was frequently passed between customer service representatives, none of whom were sufficiently informed about the ongoing repairs. Incorrect Diagnosis and Repairs: After replacing the DPF, ECM, temperature sensor, and wiring harnesses, the issue persisted. It was eventually suggested that a wiring problem might be to blame, yet no comprehensive solution was provided. Incompetence and Safety Concerns: Upon retrieving my vehicle, I noticed white smoke emanating from the engine compartment, which I discovered was due to the coolant reservoir being overfilled. Additionally, an independent inspection revealed exposed and poorly repaired wires, posing a serious safety hazard.
NHTSA ODI #11633263
Mileage unknown · Dec 11, 2024
Electrical System
Supplementary auxiliary electric heater ground connector melted and could have caused a fire. Original part #5Q0963235B. A recall (17V-62) for this part was active for various Audi and VW models but for whatever reason my car was not included. Car was brought to Valenti VW on 3/1/24 for inspection after burning smell was emittin…
Read full complaint
Supplementary auxiliary electric heater ground connector melted and could have caused a fire. Original part #5Q0963235B. A recall (17V-62) for this part was active for various Audi and VW models but for whatever reason my car was not included. Car was brought to Valenti VW on 3/1/24 for inspection after burning smell was emitting from vents. Dealer was unable to locate the source of the problem. Discovered the defective heater myself during fall season when heat was necessary. Please see attached photos. I feel I am entitled to reimbursement for the costs associated with getting this dangerous situation repaired.
NHTSA ODI #11630163
Mileage unknown · Dec 22, 2023
Electrical System
TDI Auxiliary heater (PTC) brown ground wire melting and causing a terrible plastic burning smell inside cabin. Wire likely will cause a fire. Many reports of this happening to other individuals on the Internet forum TDIforum.com
NHTSA ODI #11561553
Mileage unknown · Nov 16, 2023
Electrical System
In 2019, VW issue a recall (37M2) Shift Lever Micro Switch for failing resulting in noncompliant Theft Protection and Rollaway Prevention. The recall was issued for 2015-2019 Golf and 2017-2019 Golf Sportwagen, HOWEVER, in Canada, the recall included 2015-2019 Golf Sportwagen. I have a 2015 Golf Sportwagen (USA) with a failing…
Read full complaint
In 2019, VW issue a recall (37M2) Shift Lever Micro Switch for failing resulting in noncompliant Theft Protection and Rollaway Prevention. The recall was issued for 2015-2019 Golf and 2017-2019 Golf Sportwagen, HOWEVER, in Canada, the recall included 2015-2019 Golf Sportwagen. I have a 2015 Golf Sportwagen (USA) with a failing Shift Lever Micro Switch. There is no different between the Canadian and US Model for this part. I believe that VAG should include 2015 models in the recall.
NHTSA ODI #11555465
Mileage unknown · Mar 12, 2023
Air BagsElectrical SystemPower Train
I backed up my car and upon turning the wheel I heard some crackling from the steering wheel. The airbag and transmission error lights came on and I lost functionality of all the buttons on the steering wheel and the horn. Based on research, this is a clock spring that has been recalled for other model years.
NHTSA ODI #11511409
Mileage unknown · Feb 4, 2023
Electrical System
My vehicle has been smoking inside cab and through vent system. After troubleshooting, discovered the brown ground wire and surrounding plastic of the PTC auxiliary heater has been burning. VW said the have no inventory for replacement parts and no date getting these in. I asked if there was a recall for this issue and they s…
Read full complaint
My vehicle has been smoking inside cab and through vent system. After troubleshooting, discovered the brown ground wire and surrounding plastic of the PTC auxiliary heater has been burning. VW said the have no inventory for replacement parts and no date getting these in. I asked if there was a recall for this issue and they said there was not. Once the issue was located, I discovered a recall for the exact same issue on Audi vehicles. I am fortunate a fire did not ignite next to my leg while driving, however I did breath in a large amount of the smoke as the issue intermittently occured and the issue wasn't easily discovered. I am very frustrated VW would allow a fire hazzard to exist next to foot pedals. This should have been fixed long ago with a recall instead of forcing me and my family to breathe in smoke and risk a much larger fire. There were no warning lights and a dealer has not inspected the issue. However, brown cable housing is burnt/blackened.
NHTSA ODI #11505589
Mileage unknown · Oct 28, 2022
Electrical System
The screen which is for the radio and back up camera has started to "flicker" This looks to be a common problem people are fixing it by having the head unit replaced but clearly it's a safety issue since the backup camera is hard to use. This is a dieselgate car so it wasn't purchased new until 2017 and it seems crazy for th…
Read full complaint
The screen which is for the radio and back up camera has started to "flicker" This looks to be a common problem people are fixing it by having the head unit replaced but clearly it's a safety issue since the backup camera is hard to use. This is a dieselgate car so it wasn't purchased new until 2017 and it seems crazy for this to be happening when the car has only been on the road for 5 years. https://www.youtube.com/watch?v=MgRQp6E16Rc
NHTSA ODI #11491278
Mileage unknown · Sep 20, 2022
Electrical System
-the failed part is available for inspection -fire hazard, shock hazard and toxic fume hazard - Audi has issued a recall for the same part on their vehicles https://static.nhtsa.gov/odi/rcl/2017/RCONL-17V622-5223.pdf -there were no warning lamps or other symptoms Description of the Issue: The ground terminal on the Auxiliary …
Read full complaint
-the failed part is available for inspection -fire hazard, shock hazard and toxic fume hazard - Audi has issued a recall for the same part on their vehicles https://static.nhtsa.gov/odi/rcl/2017/RCONL-17V622-5223.pdf -there were no warning lamps or other symptoms Description of the Issue: The ground terminal on the Auxiliary Heater also sometimes known as the Supplmentary PTC Heater (P/N 5Q0.963.235)began to corrode which caused it to get so hot that the insulation melted, the heater housing melted and live wires became loose in the passenger compartment. The burning plastic also created terrible fumes inside of the car. Here is a picture of a live wire that has melted the housing and come loose. https://forums.tdiclub.com/index.php?media/aux-heater-1-jpg.140387/ Here is the melted housing where the terminal should normally be. https://forums.tdiclub.com/index.php?media/aux-heater-2-jpg.140386/ This seems to be a common issue in these vehicles and is well known to the car enthusiast community. Here are some links to forums posts which document this issue https://forums.tdiclub.com/index.php?threads/burning-smell-from-heat.513304/ https://www.youtube.com/watch?v=dnNW-onPK9M&ab_channel=mr-fix https://www.seatcupra.net/forums/threads/ptc-heater-burning-smell.459372/
NHTSA ODI #11485405
Mileage unknown · Sep 12, 2022
Electrical System
On starting the car the system monitoring safety features shows first a fault detected in the ABS, then the air bag, then tire pressure and sometimes indicates that the key battery should be replaced. It also turns off the idle control that raises the rpm when the brake peddle is released when stopped, and defeats the roll back …
Read full complaint
On starting the car the system monitoring safety features shows first a fault detected in the ABS, then the air bag, then tire pressure and sometimes indicates that the key battery should be replaced. It also turns off the idle control that raises the rpm when the brake peddle is released when stopped, and defeats the roll back when stopped on a hill. This started over six months ago and was intermittent, often turning off (no symbols lighted) and idle controls restored after a few minutes. About 5 weeks ago it became constant. In fact, the tire pressures are within the specifications, the key battery is new and measures 3V as expected. The status of the ABS and airbag cannot be checked by the consumer. This problem was reported to the Dealer, Flow Companies of Asheville, who found that the left rear speed sensor was faulty, but did not have the part. Replacement is now scheduled for October 3. This replacement hopefully will restore the monitoring system. My concern is that a monitoring system designed such that a fault in one system triggers false positive warnings in other safety related functions is dangerous. That it also affects the idle controls should not be acceptable. I have reviewed the TDI Forum and Golf Forums and found that this lighting up of multiple faults is not a rare occurrence. A faulty ABS speed sensor is sometimes the cause, other times is seems that moisture is penetrating a connector or cable. In any case a safety monitoring system providing false information should not be tolerated. I also drive a 2003 VW TDI Jetta, it also monitors the air bag, ABS and other systems, but a fault in one does not trigger a cascade of false positives.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2015 Volkswagen Golf Sportwagen Problems, Complaints & Recalls | Skip That Year
Illustration