Illustration1. TAKATA RECALL - AIRBAG NOT REPLACED YET. 2. RECALL FOR FOR FUEL PUMP CONTROL MODULE INFORMATION NOT RECEIVED YET.
2012 Volkswagen Cc
Owner reports · Recalls · Investigations
More warning signs than most Cc years
Owner complaints for the 2012 Volkswagen Cc are substantially higher than the model-year median of 83.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cc years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
2125–50K
4350–75K
3375–100K
27100–150K
2150K+
144 reports with mileage · 86 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports3 fire reports6 injury reports
Air Bags complaints
86 reportsI HAVE SPENT 1000 ON THE WATER PUMP REPAIR, PURCHASED 2 LIGHTS AT 110. AN THEWATER PUMP WENT OUR AGAIN FOR THE SECOND TIME IN 4 MONTHS.THE AIR BAG RECALL HAS BEEN RECALLED 3TIMES ALREADY I HAVE HAD TO TAKE IT IN. LIKE THIS VEHICLE HAS HAD TO MANY PROBLEMS ELECTRICAL . WHEN THE WATER PUMP OUT THE CAR WAS STATIONARY.
TAKATA RECALL - THIS RECALL WAS ISSUED IN FEBRUARY 2016 UPON WHICH I WAS TOLD THEY DID NOT HAVE THE PARTS AVAILABLE. NOW, ONE YEAR AND EIGHT MONTHS LATER I'M RECEIVING NOTIFICATIONS ABOUT BRINGING MY VEHICLE IN TO BE REPAIRED. THE MOST RECENT STATES "THIS IS A SERIOUS ISSUE THAT MUST BE TAKEN CARE OF - DEFECTIVE COMPONENTS CAN C…
Read full complaint
TAKATA RECALL - THIS RECALL WAS ISSUED IN FEBRUARY 2016 UPON WHICH I WAS TOLD THEY DID NOT HAVE THE PARTS AVAILABLE. NOW, ONE YEAR AND EIGHT MONTHS LATER I'M RECEIVING NOTIFICATIONS ABOUT BRINGING MY VEHICLE IN TO BE REPAIRED. THE MOST RECENT STATES "THIS IS A SERIOUS ISSUE THAT MUST BE TAKEN CARE OF - DEFECTIVE COMPONENTS CAN CAUSE THE AIRPAG TO DEPLOY IMPROPERLY, SHOOTING METAL FRAGMENTS ANT DRIVERS AND PASSENGERS, WHICH CAN CAUSE SERIOUS INJURY OR DEATH." I'M CONCERNED THAT IT TOOK NEARLY TWO YEARS TO RESOLVE THIS ISSUE, ESPECIALLY GIVEN THE STATEMENT BEING SENT OUT VIA POSTCARD. SECONDLY, NOW THERE IS YET ANOTHER RECALL FOR SOMETHING RELATED TO THE ELECTRICAL POWER TO THE FUEL PUMP MODULE. I HAVE ALREADY TAKEN MY VEHICLE IN MULTIPLE TIMES FOR A RELATED RECALL, ONE THAT LEFT ME STRANDED AND HAVING TO BE TOWED BEFORE VW EVER EVEN NOTIFIED ME. ABSOLUTELY UNREAL!
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V078000 (AIR BAGS) AND 15V483000 (AIR BAGS). THE PARTS FOR THE RECALL REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE CONTACT…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V078000 (AIR BAGS) AND 15V483000 (AIR BAGS). THE PARTS FOR THE RECALL REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE CONTACT TOOK THE VEHICLE TO ALEXANDRIA VOLKSWAGEN (107 W GLEBE RD, ALEXANDRIA, VA, 22305; 703-684-8888); HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
TAKATA RECALL - IN APRIL 2016, VW INFORMED ME THAT THE DRIVER'S SIDE AIRBAG WAS DEFECTIVE AND POTENTIALLY DANGEROUS. TODAY (JULY 5, 2017) I CALLED THE VW DEALER, AND THE VW DEALER CLAIMS THE PARTS FOR THE AIRBAG REPAIR WILL NOT BE AVAILABLE UNTIL SEPT. 30, 2017. THAT MEANS I WILL HAVE BEEN DRIVING AN UNSAFE CAR FOR 18 MONTHS. CA…
Read full complaint
TAKATA RECALL - IN APRIL 2016, VW INFORMED ME THAT THE DRIVER'S SIDE AIRBAG WAS DEFECTIVE AND POTENTIALLY DANGEROUS. TODAY (JULY 5, 2017) I CALLED THE VW DEALER, AND THE VW DEALER CLAIMS THE PARTS FOR THE AIRBAG REPAIR WILL NOT BE AVAILABLE UNTIL SEPT. 30, 2017. THAT MEANS I WILL HAVE BEEN DRIVING AN UNSAFE CAR FOR 18 MONTHS. CAN NHTSA GET VW TO DO THE REPAIRS SOONER?
TL* THE CONTACT OWNS A 2012 VOLKSWAGEN CC. WHILE DRIVING UPHILL AT APPROXIMATELY 65 MPH AND ATTEMPTING TO PASS ANOTHER VEHICLE, THE CONTACT'S VEHICLE LOST ACCELERATION AND THE EPC WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. WHEN THE VEHICLE WAS RESTARTED, THE…
Read full complaint
TL* THE CONTACT OWNS A 2012 VOLKSWAGEN CC. WHILE DRIVING UPHILL AT APPROXIMATELY 65 MPH AND ATTEMPTING TO PASS ANOTHER VEHICLE, THE CONTACT'S VEHICLE LOST ACCELERATION AND THE EPC WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. WHEN THE VEHICLE WAS RESTARTED, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO A SERVICE STATION AND TOWED TO AN INDEPENDENT MECHANIC (JOSHO AUTO, 10945 RANDOLPH, COSTA MESA, CA 92626, 714-557-2601) WHERE THE VEHICLE WAS KEPT FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. ALSO, APPROXIMATELY ONE YEAR AGO, THE FRONT PASSENGER SIDE OF THE VEHICLE WAS CRASHED INTO BY ANOTHER VEHICLE. NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A BODY SHOP (PACIFIC ELITE AUTO BODY SHOP IN COSTA MESA CA) AND REPAIRED BY THE INSURANCE COMPANY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT RECENTLY SEARCHED THE VIN AND FOUND NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS). THE FAILURE MILEAGE WAS APPROXIMATELY 62,000. PARTS DISTRIBUTION DISCONNECT.
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS) HOWEVER THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED AND CONFIRME…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS) HOWEVER THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY AND ADVISED TO CONTACT THE MANUFACTURER. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WERE NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 07/11/17*LJ UPDATED 08/08/2017*JS
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT …
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
IT HAS BEEN OVER ONE YEAR SINCE THE AIRBAG ON MY VEHICLE HAS BEEN RECALLED AND VOLKSWAGEN HAS YET TO DO ANYTHING. THE TURBO ALSO SEEMS TO BE MALFUNCTIONING.
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V078000 (AIR BAGS) AND 15V483000 (AIR BAGS); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. TH…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V078000 (AIR BAGS) AND 15V483000 (AIR BAGS); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Official recalls
618V329000 · Unknown Or Other
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.
18V148000 · Air Bags:frontal:driver Side:inflator Module
Mar 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q9. Note: This recall partially supersedes recall 16V-078.
17V509000 · Fuel System, Gasoline:delivery:fuel Pump
Aug 16, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2016 Volkswagen CC, 2006-2010 Passat and Passat Wagon vehicles. Interruption of electrical power to the fuel pump control module may cause the fuel pump to fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump control module, free of charge. The recall began June 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20AE.
16V078000 · Air Bags:frontal:driver Side:inflator Module
Feb 10, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
15V483000 · Air Bags:frontal
Aug 4, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Volkswagen CC, and Passat, 2010-2013 Eos, 2011-2014 Golf, GTI, Jetta, and Tiguan, and 2012-2014 Jetta Sportwagen vehicles. In the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. This contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.
Consequence & remedy
Consequence: A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. If the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Volkswagen customer service at 1-800-822-8987.
11V312000 · Tires:pressure Monitoring And Regulating Systems
Jun 6, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012, CC VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." THE FACTORY INSTALLED WHEELS AND TIRES WERE REPLACED AT THE PORT WITH ACCESSORY WHEELS AND TIRES THAT WERE NOT EQUIPPED WITH THE PROPER TPMS SENSORS.
Consequence & remedy
Consequence: WITH THE INCORRECT TPMS SENSORS, DRIVERS WILL RECEIVE A CONSTANT WARNING FROM THE TIRE PRESSURE MONITOR SYSTEM. THE SYSTEM ALERTS THE DRIVER BUT, DUE TO INCORRECT TPMS SENSORS, THE SYSTEM CANNOT DETERMINE IF THE VEHICLE TIRES ARE PROPERLY INFLATED. THIS INCREASES THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: VOLKSWAGEN WILL REPLACE THE TPMS SENSORS WITH THE PROPER SENSORS TO MAKE THE TPMS SYSTEM OF THE VEHICLES COMPLIANT WITH FMVSS 138. AS OF JUNE 1, 2011, VOLKSWAGEN HAS CONTACTED ALL AFFECTED CUSTOMERS TO SCHEDULE THE REPAIRS FREE OF CHARGE. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
RQ17009 · Air Bag Clockspring Failure
Opened Nov 13, 2017 · Closed May 4, 2018
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
PE15010 · Air Bag Clockspring Failure
Opened Mar 24, 2015 · Closed Sep 28, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Additional source detail variants (3)
Air Bags:frontal
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Air Bags
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.