2024 Volkswagen Atlas

Within a year of owning my vehicle, I began to notice a SEVERE shudder on braking when descending from 7000 foot elevation (Mammoth Lakes, CA) to a 4400 foot elevation (Bishop, CA) on [XXX] of [XXX} upon braking. I have driven this route approximately 25 times in the past 1.5 years. Normally, I would set the adaptive cruise control to 73-75 mph on this downhill grade to control speed, and let the adaptive cruise control do the work of controlling speed, while keeping my own foot off the break. However, if I did need to slow further due to traffic, I would experience a SEVERE shudder upon manual braking- see attached screenshot of a video taken at night. I brought this incident up to VW (See mechanic video) in 1/2025, and they blamed the problem on overheating of the front rotor (see technician video link below). Upon return trips to Mammoth, I now realize that this overheating was caused by the adaptive cruise control itself attempting to control auto speed. Now, in order to make this LESS dangerous, I have to let the car get up to 80 mph and then pulse the breaks- because if I let the adaptive cruise control do the work as designed, it creates an unsafe driving condition BECAUSE OF A FAULTY DESIGN by VW- if heat is an issue, better dissipation is needed, or a temperature sensor is needed. VW's solution was for me to spend $700 to replace brakes and rotors due to a VW design flaw, despite my car being under warranty, and I cannot afford this currently. I think this issue MUST be recalled immediately before I (or someone else) who drives on long hilly grades has a fatal car accident due to a design flaw in the VW Atlas Adaptive Cruise Control. VW Technician report found here: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When the Atlas is cold, there is a weird screeching/grinding sound coming from the drivers side front when I press the brakes while in motion. Car has 12 miles on it. Brought it into the dealer and they say that it’s a known issue with the OEM brakes, but as it “does not cause a safety concern” it’s not covered under warranty. Dealer said that he could replace brakes with non OEM and the problem would go away. Dealer says that it is from “initial brake build-up” but that it is not likely to go away without replacing the brakes.

The brakes sound horrible when they are cold. They grind and vibrate until they are warmed up and the car only has 8K miles on it. We are being forced to pay to have the brake pads replaced with ceramic brake pads from the semi-metallic factory ones. We have only had the car 2 weeks. They said VW would cover 70% of the cost, but with the number of complaints, this should be covered completely.

Grinding noise accompanied with vibration and pulsating feel in brake pedal. Fluid movement noises near driver footwell. Cavitation of hydraulic fluid in brake systems can result in corrosion and premature failure of components. Inconsistency in brake feel with pedal vibration has resulted in over and under braking. The problem has been substantiated 3 times by two independent dealers. No warning lights present.

We purchased our vehicle in August 2024. We only have around 3,200 miles on it. When leaving a space (driveway, parking space, etc), even if only parked for a short time, the brakes have a noticeable screech which I have never had on a new vehicle. The dealership inspected and said there are no issues and they will not replace the pads. They blame the type of pads used by the manufacturer. I have never had this issue on new vehicles whether it is hot, cold, wet, dry, etc. My used vehicle recently had brake pads changed and there are no sounds.