2022 Volkswagen Atlas

I am reporting a recurring coolant system issue that raises safety concerns. My 2022 VW Atlas has triggered the coolant warning light several times since new. A dealership eventually replaced the head gasket under warranty, yet the warning returned again months later. At the most recent service visit, a pressure test showed no leak, and I was told the problem was likely "air bubbles" — the same explanation I received before the head gasket was replaced. VW has issued TSB 19-22-01, advising dealers to blame repeated warnings on trapped air and to avoid replacing parts unless a leak is confirmed. This contradicts VW’s own official dashboard warning guidance, which instructs drivers to “Stop! Engine coolant level too low, engine coolant temperature too high, or engine coolant system malfunction” and “Do not drive.” This creates a conflict: VW tells customers a coolant warning is urgent and dangerous, while internally telling dealers to do nothing unless symptoms worsen. Meanwhile, owners are left driving vehicles that could overheat, stall, or fail without proper diagnosis. I request NHTSA investigate whether this approach allows VW to underreport or delay addressing a possible defect. I am concerned about the safety and reliability of this vehicle and the potential for this issue to affect other Atlas owners.

The engine shut-off while still driving between 10-15 mph when entering a gas station and turning uphill. Cannot say for certain, but the vehicle behaved similar to when the "start-stop" engine system activates. Electrical seemingly remained on, could not accelerate, and the dashboard requested something along the lines of needing to "restart." Similar scenario occurred the day prior but this time we were completely stopped. Came to a stop, attempted to accelerate, and the dashboard was referencing the same warning as above. This could clearly cause a major accident especially when it occurs while still moving at a respectable speed. VW offers a switch to turn off this system, but the system does not keep the setting once the vehicle is turned off. It automatically activates upon ignition. Ironically, the failure of unwanted & over-complicated engineering cannot be permanently switched off by the vehicle remembering the last setting unless you wish to spend $100 from a third-party. Hopefully my wife remembers to press the magic button every time she turns on the vehicle.

When the vehicle is at a stop or slowing maybe to park the engine shuts down. I get a start/stop error and it indicates I must restart the car manually. I then have to put the car in park and restart the vehicle. This has happened while the vehicle was in motion and in major city traffic. The vehicle displays a check engine light now. It is currently at the dealership being serviced.

Steering gear failed twice i have the first one make my car shake so bad and second it makes horrible noise every time i moved the steering wheel . Both front head light led failed for the day running light. Car has misfiring problems with spark plugs and injectors making driving unpredictable and engine start shaking out of nowhere and epc (electronic power control )light comes on

Vehicle stalling at intersections and is very dangerous. Took vehicle to VW dealership and even though they know and told me the problem was the carbon canister they are unable to repair due to no check engine light or the ability to replicate during there 5 minute test drive. This vehicle need repaired before it causes my family to be involved in an accident and they are refusing even though they know the problem.

Vehicle stalls at Idle or close to Idle. It's very dangerous as this could happen in an intersection leading to a collision. When I contacted VW they are completely aware of the issue, Know the part to fix and have even given the part an extended warranty. However, this will still not help if it causes an accident or injury to my family! According to VW of America, and the Dealership it's the Carbon Canister that is causing this problem. If this has not been a factor in an accident yet it certainly will be . Please address this issue immediately.

The first issue at 26k miles when the coolant light turned on. It was a broken head gasket which required the replacement of the full motor on the vehicle. After the motor was replaced, the vehicle had to be taken back to the dealership that completed the work on 3 different occasions for installation concerns including a loose bolt and low coolant levels. The second issue at 33k miles was the failure of the charcoal canister which ruined the fuel tank lining, resulting a replacement of the fuel tank. This issue caused the car to stall anytime it was idle (if I was in traffic and not able to accellerate or in a parking lot going slowly, it would stall requiring it to be put into park and restarted. This issue was a huge safety concern since my car would shut down in traffic. No indicator lights came on during this issue. Next, at 37k miles, I smelled terrible gas fumes each time the car idled. At one point, when blowing my nose, I had black soot residue, so I can't imagine what I was breathing or the risk of the vehicle catching fire with such strong fumes. I had to take the car in twice before they took me seriously. The car had broken O rings from the engine replacement. No indicator lights came on for this issue either. Last week, we received the car back after 33 days in the shop for ANOTHER broken head gasket. Within a day of getting the car back, it misfired and the check engine light was on again. The car does not accellerate correctly which poses a safety risk when trying to pull out into moving traffic or cross oncoming traffic. Volkswagen corporate office is well aware of all the issues but declined the buy-back process because we don't fall under our state's lemon laws.

1. Noise from the Front End - Shortly after purchasing the vehicle, I noticed a persistent noise coming from the front end while driving. I reported this issue to the dealership within the first 30 days of ownership, but they were unable to identify or resolve the problem on multiple occasions. Eventually, I took the vehicle to Dublin Volkswagen, where the issue was diagnosed, but I had to pay $80 out-of-pocket for the diagnostic fee. 2. Stalling Issue - The vehicle has been sporadically stalling, which initially led me to believe it was related to the auto stop/start feature. However, I later discovered that this is a recurring issue reported by other Volkswagen Atlas owners [XXX] ). This stalling issue has occurred multiple times, even to my brother during his visit from Canada. Given that this vehicle is used to transport children and other passengers, this is a serious safety concern and liability risk. Picture of message that pops up when the issue occurs. 3. Brake Performance Problems - The brakes have been squealing and exhibit shaking and grinding during use after sitting for different periods of time. Despite contacting the dealership (Dorito Brothers Volkswagen) numerous times about this issue, I have been repeatedly dismissed by their service advisors, technicians and manager. Their lack of attention to detail and unwillingness to address my concerns has eroded my confidence in their ability to service the vehicle properly. I was also informed that Volkswagen would be dealing with the brakes issues by the end of the fourth quarter in 2024 but to-date nothing has been heard nor done. They are recommending brake pads and rotors but why are those needing to be replaced after less than a year of owning it. There's more going on than they are disclosing. Attached is a copy of a report from a different dealer than the car was purchased from. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)