2022 Volkswagen Atlas Cross Sport

The contact owns a 2022 Volkswagen Atlas Cross Sport. The contact stated that overnight 1/3 of the engine oil had leaked onto the ground. While starting the vehicle, there was an abnormal oil burning odor and visible smoke coming from the engine. There was no warning light illuminated. The vehicle was towed to an independent mechanic to be diagnosed, and the contact was informed that the VVT sensors, timing cover gasket, and timing cover needed to be replaced. The parts were replaced; however, the oil leak persisted, and the parts were replaced a second time. The contact was informed that the PCV was inoperable as per the Emissions Service Action Code: 10LP. The contact was referred to the manufacturer for assistance. The manufacturer was notified of the failure; however, the contact was advised that the repair would be an out-of-pocket expense, minus the PCV. The vehicle was not repaired. The failure mileage was 82,933.

I am filing a safety complaint regarding my 2022 Volkswagen Atlas Cross Sport, VIN: [XXX] The vehicle was purchased new in October 2021. Volkswagen issued Recall 13i4 / NHTSA Campaign 22V-753 for certain Atlas Cross Sport vehicles due to an engine connecting rod/connecting rod bearing manufacturing defect that can cause engine failure, loss of motive power while driving, and potential safety risks. My vehicle was inspected by an authorized Volkswagen dealer under Recall 13i4 in 2023. I was told the recall condition was not present and the recall was marked completed. On or about [XXX], the vehicle developed the exact issue covered by Recall 13i4. I brought it to an authorized Volkswagen dealer, and the dealer confirmed that the failure is the same engine connecting rod/connecting rod bearing issue identified in the recall. The required repair is engine replacement. Volkswagen is refusing to reopen or reauthorize the recall repair because the recall was previously marked completed after the 2023 inspection and because the factory warranty expired in October 2025. I am now being told I may be responsible for the engine replacement cost, even though the dealer has confirmed this is the exact safety defect covered by the recall. I believe this is a failed or inadequate recall remedy. The 2023 inspection did not permanently remedy the defect and appears to have missed a latent manufacturing issue that has now manifested. This is not a normal out-of-warranty mechanical failure. It is the specific safety-related defect Volkswagen reported to NHTSA. I am asking NHTSA to review whether Volkswagen’s Recall 13i4 remedy process is inadequate, especially for vehicles that passed the initial inspection but later develop the same covered engine defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Description of Fault This vehicle exhibits a recurring, intermittent failure of the electronic throttle control system. Three distinct symptom patterns have been observed: 1.Throttle non-responsive at stop-start (approx. monthly/bi-monthly): After coming to a complete stop (e.g. at a traffic light), pressing the accelerator pedal produces no engine response. The vehicle will not move. Switching the ignition fully off and performing a cold restart resolves the issue immediately. 2.Throttle failure while vehicle was in motion (Wednesday, March 4, 2026): While my wife was driving the vehicle, the throttle stopped responding entirely mid-journey. The accelerator pedal produced no engine response while the vehicle was moving at speed. This is a direct and serious safety hazard. As with other incidents, switching the ignition fully off and performing a cold restart resolved the issue. 3.Erratic/hypersensitive throttle response on inclines: On slight uphill gradients, a light press of the accelerator pedal produces a disproportionately strong acceleration response, suggesting inconsistent signal output from the accelerator pedal position sensor (APPS). Safety Concern The occurrence of complete throttle loss while the vehicle was in motion — experienced by my wife on March 4, 2026 — is a serious safety defect. A driver who loses throttle response at highway speed, on a merge, or when crossing an intersection is at significant risk of collision. I am formally documenting this concern so that it is part of the vehicle's permanent service record.

Got the PCV valve repaired on February 13th and on February 18th the EPC light came on. The 2022 Volkswagen Atlas was taken to dealership and said the charge air inlet and the diverter valve leaking oil. Recommended to replace the turbo diverter valve and the charge air inlet seal at this time and re-testing the turbo. My car is shutting off when sitting at a light and car only has 52, 294 mileage

The contact owns a 2022 Volkswagen Atlas Cross Sport. The contact stated while driving from a complete stop at 10 MPH, the vehicle stalled and became inoperable. The contact was unable to pull over to the side of the road. The contact was able to restart the vehicle. Several unknown messages were displayed. The contact stated that the failure recurred 10 minutes later while driving in a parking lot. The dealer was contacted, and an appointment was scheduled for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 25,000.

The car’s engine start/stop feature has failed multiple times while at an incomplete stop. This failure endangers the driver because the car will not drive, forcing the driver to put the car in park & manually restart the car. This failure has occurred at least 6 times, reported as the original owner of the car for 3+ years. Recently, as a potential result(?), the car’s check engine light has appeared (@52k miles). The dealership suggested replacement of the N80 purge valve,~$400 repair at VW dealership, to fix the tandem start/stop error & check engine light issue.

This vehicle has an issue where the engine stalls when operating a slow speeds/a stop. When the engine stalls, a message appears on the dashboard stating that you must put the car in park, turn off the ignition, restart the car, and then put it back into drive. This has posed as a significant risk to myself, my wife, and our [XXX] daughter. Additionally, my wife is currently [XXX]. The engine has stalled on us in the middle of an 8 lane intersection when attempting to turn left, when merging onto a highway, and numerous other very dangerous situations. This issue begin about 1 year after purchasing the car (brand new) from Volkswagen. Since then, we have brought the car back to the dealership where we purchased it (Heritage Volkswagen Parkville) over 5 times to have them look into this issue. They have attempted to replace the gas tank (claimed it had shrunk) and reset the computer system, yet neither of these things have worked. Neither myself or the dealership can "make" the car stall as it happens very randomly (which increases the risk that this issue poses) and now we are stuck - where Volkswagen has won't continue to research the issue/attempt to fix it yet my family is still left at risk with a car we purchased brand new off of their lot. The vehicle has not been inspected by the police, insurance, or any other people outside of Volkswagen and the vehicle has no warning signals that there is an issue and no code that they have been able to pull at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Volkswagen Atlas Cross Sport. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the crankcase ventilation valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 51,346.

Slowing down as I pulled into a turning lane. The vehicle lost power and cut off with a warning light saying please restart engine manually. I did start engine manually to begin with. I had to throw my car in park in the middle of the road. And restart it. The vehicle restarted and I got out of the way with my kids in the car. And after continuing to drive the vehicle feels like it has no power. This is not the first incident my car has 53k miles on it. Has had 2 gear shifters, 2 auto stop start relays and gone through several batteries