Fuel System, Gasoline. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports1 injury reports

Fuel/propulsion System complaints

2 reports

Clear category filter

30,300 miles · May 6, 2020

Fuel/propulsion System

PLASTIC GAS TANK HAS EXPANDED. LIKELY DUE TO ETHANOL IN FUEL CAUSING WATER ABSORPTION IN PLASTIC. TANK IS VERY DIFFICULT TO INSTALL AFTER REMOVAL. STRESS ON TANK BECAUSE OF IMPROPER FIT COULD CAUSE CRACKS AND LEAKS. *TR

NHTSA ODI #11323503

52,550 miles · Jun 27, 2016

Fuel/propulsion System

Read full complaint

FUEL TANK WAS REMOVED FROM MOTORCYCLE TO INSTALL A NEW THROTTLE CABLE. WHEN FUEL TANK WAS REINSTALLED, THE MOUNTING HOLES FOR THE FUEL TANK NO LONGER LINED UP, THE FUEL TANK DIDN'T FIT BETWEEN THE FRAME RAILS AND TO MOUNT THE FUEL TANK A CONSIDERABLE AMOUNT OF PRESSURE NEEDED TO BE APPLIED TO FORCE THE MOUNTING HOLES TO LINE UP. THIS PUTS THE WHOLE TANK UNDER SEVERE STRESS AND COULD CAUSE LEAKS. THE NEXT TIME IT IS REMOVED, I DO NOT BELIEVE THE TANK WILL GO BACK INTO THE MOTORCYCLE. THIS SEEMS TO BE A COMMON PROBLEM WITH ANY OF THE PLASTIC TANKS DUE TO ETHANOL FUEL THAT IS REQUIRED HERE IN THE US ON MANY MAKES/MODELS OF THE MOTORCYCLES.

NHTSA ODI #10877002

Official recalls

04V156000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Apr 7, 2004

ON CERTAIN MOTORCYCLES, THE FUEL CONNECTOR LINKING EACH OF THE FEED AND RETURN FUEL HOSES TO THE FUEL PUMP MOUNTING PLATE MAY FRACTURE FOLLOWING IN-SERVICE HANDLING.

Consequence & remedy

Consequence: FUEL COULD ESCAPE FROM THE FRACTURED BODY OF THE CONNECTOR ONTO THE ENGINE OR SIDE OF THE BIKE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE CONNECTOR. THE RECALL BEGAN ON JULY 30, 2004. OWNERS SHOULD CONTACT TRIUMPH AT 1-678-854-2010.

02V242000 · Wheels

Sep 10, 2002

ON CERTAIN MOTORCYCLES, THE REAR WHEEL NEEDLE ROLLER BEARING AS FITTED ONLY TO CERTAIN SINGLE SIDED SWINGING ARM MOTORCYCLES CAN DETERIORATE AND SEIZE CAUSING THE REAR WHEEL TO LOCK-UP.

Consequence & remedy

Consequence: THIS CAN CAUSE A LOSS OF CONTROL OF THE MOTORCYCLE.

Remedy: DEALERS WILL REPLACE ALL REAR WHEEL BEARINGS. OWNER NOTIFICATION BEGAN SEPTEMBER 19, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TRIUMPH AT 1-678-854-2010.

01V339000 · Power Train:clutch Assembly:pedal/hand Lever(motorcycle)

Nov 2, 2001

VEHICLE DESCRIPTION: MOTORCYCLES. THE CLUTCH CONTROL CABLE CAN FRAY AND FAIL. THE BARREL AT THE END OF THE INNER CABLE SEIZES IN THE CONTROL LEVER BORE, THEREBY STRESSING THE INNER CABLE.

Consequence & remedy

Consequence: THIS CAUSES THE RIDER TO BE UNABLE TO ENGAGE THE CLUTCH, INCREASING STOPPING DISTANCES AND INHIBITING DRIVING CONTROL.

Remedy: DEALERS WILL REPLACE THE CLUTCH CABLE. OWNER NOTIFICATIONBEGAN JANUARY 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TRIUMPH AT 678-854-2010.

00V312000 · Fuel System, Gasoline:storage

Oct 11, 2000

VEHICLE DESCRIPTION: MOTORCYCLES. A FUEL LEAK COULD OCCUR FROM THE FUEL LEVER SENDER LOCATED INSIDE THE FUEL TANK.

Consequence & remedy

Consequence: IF THIS CONDITION OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, POSSIBLY COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL SENDER.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE03053 · Fuel Line Fitting Leaks

Opened Nov 20, 2003 · Closed Apr 2, 2004

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

TRIUMPH RESPONDED TO ODI'S INFORMATION REQUEST ON FEBRUARY 23, 2004. IN ADDITION TO THE MY2000-2002 TRIUMPH DAYTONA AND SPRINT MODELS, TRIUMPH IDENTIFIED THE FOLLOWING ADDITIONAL MODELS THAT WERE BUILT WITH THE SAME FUEL LINE FITTINGS:2000-2003 TT600, 2002-2004 SPEED FOUR, 2004 DAYTONA 600, 1997-2004 DAYTONA T595 & 955, 1997-2004 SPEED TRIPLE 855 & 955, 2000-2004 SPRINT RS 955, 1999-2004 SPRINT ST 955, AND 1999-2004 TIGER 855 & 955.THE MAJORITYOF THESE MOTORCYCLES WILL BE INCLUDED IN THE RECALL.A MODIFIED CONNECTOR WAS INTRODUCED LATE IN CALENDAR YEAR 2003, WHICH DOES NOT APPEAR TO EXHIBIT THE DEFECT. MOTORCYCLES BUILT AFTER THE MODIFICATION WILL NOT BE RECALLED.TRIUMPH IDENTIFIED 13 UNITED STATES AND 6 UK COMPLAINTS.ONE US COMPLAINT APPEARED TO BE RELATED TO A POSSIBLE CRASH WHERE LEAKING FUEL CAUSED A LOSS OF TRACTION. AFTER ODI'S REVIEW OF TRIUMPH'SDOCUMENTS, FOLLOWED BY A DISCUSSION OF RELEVANT FACTS WITH TRIUMPH, THEY MADE THE DECISION TO CONDUCT THE RECALL.THE RECALLED VEHICLES WILL HAVE THE PLASTIC FUEL CONNECTORS REPLACED WITH A SIMILARLY DESIGNED ALUMINUM CONNECTOR. THIS INVESTIGATION IS CLOSED.