My 2017 Tacoma TRD Off Road (manual transmission) makes a constant chirping sound when the engine is running and increases chirping sound when accelerator is pressed. The chirping sound ceases when the clutch is pressed in. It's clear through research that this is a "throw out bearing" issue. Toyota dealership confirmed the s…
Read full complaint
My 2017 Tacoma TRD Off Road (manual transmission) makes a constant chirping sound when the engine is running and increases chirping sound when accelerator is pressed. The chirping sound ceases when the clutch is pressed in. It's clear through research that this is a "throw out bearing" issue. Toyota dealership confirmed the same issue and replaced the throw out bearing on 6/24/26 through 7/2/26 (as covered by extended warranty). On 7/3/26, the chirping sound remains, possibly worse/louder. On 8/28/26 through 8/31/26, a different Toyota dealer changed the throw out bearing again, but added changing the entire clutch system (being clutch disc assembly, clutch cover assembly, pressure plate, fly wheel and fly wheel sub assembly). Car was picked up and still makes chirping noise. Research of this issue notes: Quill Wear: The aluminum snout (quill) the bearing slides on can groove and wear down over time; and Toyota TSB: Dealerships previously addressed this under technical service bulletins with updated OEM replacement parts, though the noise can sometimes return if the core design interaction isn't changed. This is a design flaw, using an aluminum snout/quill versus a steel snout. This issue is all over the internet, although when I called Toyota Brands, they said they cannot help me. This should be a recall item for Toyota to fix.
NHTSA ODI #11761605
Mileage unknown · Dec 31, 2025
Power Train
There is a leak the rear differential. There is a recall on this issue
NHTSA ODI #11708042
Mileage unknown · Nov 21, 2025
EnginePower Train
I was driving on the highway when my vehicle suddenly lost power. The engine light and traction control light came on, and I lost power, and the engine started sputtering. I had to pull off to the side and put on hazards. My Tacoma would only drive about 25 MPH after this happened. Based on a quick search, this is a very common …
Read full complaint
I was driving on the highway when my vehicle suddenly lost power. The engine light and traction control light came on, and I lost power, and the engine started sputtering. I had to pull off to the side and put on hazards. My Tacoma would only drive about 25 MPH after this happened. Based on a quick search, this is a very common problem in 3rd-generation Tacomas!
NHTSA ODI #11700837
Mileage unknown · Mar 18, 2024
Fuel/propulsion SystemPower Train
The Tacoma still has only 10,000 original miles. We yearly replace the oil when we have our annual vehicle inspection. The truck has been trouble since the beginning. Early on I noticed when going downhill, the automatic transmission seems to slip when applying the gas. I have taken the truck back to the dealer in Kona to be to…
Read full complaint
The Tacoma still has only 10,000 original miles. We yearly replace the oil when we have our annual vehicle inspection. The truck has been trouble since the beginning. Early on I noticed when going downhill, the automatic transmission seems to slip when applying the gas. I have taken the truck back to the dealer in Kona to be told that it is not part of the rear end differential recall some years ago. I asked them to make a notation of this should the transmission or rear end differential fail in the future. Recently, we received an informational letter from Toyota regarding something about a possible faulty high pressure fuel pump. I made an appointment at the dealer and since I was there asked them for tire rotation, oil change and annual vehicle inspection. I explained to the service writer that I still believe there is a rear end or transmission problem. At first, she said, the recall was never done and later said it was done. More importantly, I have been smelling gasoline when I exit the truck although I see no visible fuel on the ground. I believe that this is related to the fuel pump issue which I received the letter from you. I was told several hours after I dropped off the truck that the fuel smell was not related to the letter I received.
NHTSA ODI #11578089
Mileage unknown · Jul 7, 2023
Power Train
Transmission line was described by two auto mechanics (one from a Toyota dealership) as “rusted out” and “porous”, “low pressure/fluid” and “needs to be fixed”. I was totally unaware of the issue until I had to get my AC recharged. Note: this is a 2017 truck with 82,000 miles driven in Massachusetts. No warning lights went off.
NHTSA ODI #11530826
48,000 miles · Sep 9, 2021
Power TrainCrash
The contact owns a 2017 Toyota Tacoma. The contact stated that after shutting off the vehicle with the push-button keyless ignition, the vehicle was parked inside of the garage with the garage door remaining opened and the contact exited the vehicle. When the contact came back to the garage, he noticed that the vehicle was missi…
Read full complaint
The contact owns a 2017 Toyota Tacoma. The contact stated that after shutting off the vehicle with the push-button keyless ignition, the vehicle was parked inside of the garage with the garage door remaining opened and the contact exited the vehicle. When the contact came back to the garage, he noticed that the vehicle was missing as it had reversed down the driveway inadvertently while the engine was off. However, the transmission gear shifter was on the drive position. The vehicle had crashed into two trees in the woods. No police report was filed. The vehicle was taken to a body shop and remained at the body shop, waiting for repairs to the front and rear passenger side doors, rear windshield, rear fender, and passenger side mirror. The dealer and manufacturer were not made aware of the failure. The failure mileage was approximately 48,000.
NHTSA ODI #11432280
Mileage unknown · Sep 2, 2021
Power Train
as vehicle was being shifted from reverse to drive the shift lever locked up in neutral ! ! !
NHTSA ODI #11431460
Mileage unknown · Jun 3, 2021
Power Train
I have been having several intermittent issue with the automatic transmission on my 2017 Tacoma TRD off Road with 43000 miles. Among them are as follows: It fails to shift correctly (hunting for gears) on the highway and hesitates to accelerate when needed, Also the transmission sometimes has a delayed engagement when putting it…
Read full complaint
I have been having several intermittent issue with the automatic transmission on my 2017 Tacoma TRD off Road with 43000 miles. Among them are as follows: It fails to shift correctly (hunting for gears) on the highway and hesitates to accelerate when needed, Also the transmission sometimes has a delayed engagement when putting it into reverse or drive from a standstill. The engine will rev up like it was in neutral then abruptly catch the reverse gear causing a loud and disturbing “BANG” and even some tire spin on the pavement. I also intermittently experience a loud “CLUNK” when slowing down to a stop in traffic as if the transmission is not downshifting properly from the higher gears to the lower ones and is forced to come to an abrupt halt. The dealer has performed a software update but this has not helped. The dealer also cannot replicate these problems because the issues are intermittent. I understand that a lot of 3’rd generation Tacoma owners are experiencing the same exact issues but it seems that Toyota is not issuing a recall for some reason. I believe this is a potential safety hazard and should be addressed.
EVERY SO OFTEN I HEARD A BANG COMING FROM THE DRIVETRAIN WHILE I'M DRIVING AND ALSO WHEN I PUT THE TRUCK ON REVERSE THE SOUND IT'S LOUD. I DON'T KNOW IT'S A TRANSMISSION PROBLEM OR THE JOINTS WITH THE DIFFERENTIAL. BUT IT'S GETTING BAD. ALSO I HAVE PROBLEMS WITH THE CHARGING SYSTEM AND IT WAS BROUGHT IN AND THE DAY THERE IS NO P…
Read full complaint
EVERY SO OFTEN I HEARD A BANG COMING FROM THE DRIVETRAIN WHILE I'M DRIVING AND ALSO WHEN I PUT THE TRUCK ON REVERSE THE SOUND IT'S LOUD. I DON'T KNOW IT'S A TRANSMISSION PROBLEM OR THE JOINTS WITH THE DIFFERENTIAL. BUT IT'S GETTING BAD. ALSO I HAVE PROBLEMS WITH THE CHARGING SYSTEM AND IT WAS BROUGHT IN AND THE DAY THERE IS NO PROBLEM BUT FOR SOME REASON SOME TIMES LIGHTS WILL COME UP OUT OF THE BUE.
NHTSA ODI #11399560
23,000 miles · Jan 22, 2021
EngineFuel/propulsion SystemPower Train
IDLE SURGES . RPM SURGE WHILE AT PARK AND IT SURGES WHEN ABOUT TO DRIVE FROM THE PARKING
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018 Toyota Camry and Highlander vehicles, 2017 Toyota Sienna and Tacoma vehicles and 2017 Lexus RX350 vehicles. During the manufacturing process, the oil galley in the rotor for the brake booster vacuum pump assembly may have been improperly machined possibly resulting in a sudden loss of brake assist.
Consequence & remedy
Consequence: A sudden loss of braking assist can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the brake booster vacuum pump, free of charge. The recall began on May 9, 2018. Owners may contact Toyota customer service at 1-888-270-9371, or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0K/JLD.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles equipped with a six-cylinder engine. The affected vehicles have a crank position sensor that may malfunction, potentially resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the crank position sensor with an improved design, free of charge. The recall began July 26, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0H.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles. Oil may leak from the area where the rear differential carrier is assembled to rear axle housing.
Consequence & remedy
Consequence: If the vehicle is operated with an insufficient amount of oil in the rear differential, the differential may seize and cause a loss of control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the rear differential for oil leakage. Based on the inspection, dealers will either tightening the fastening nuts or replace the fastening nuts and gasket. If the rear differential components are damaged, the rear differential carrier assembly will be replaced. The repairs will be performed free of charge. The recall June 19, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
2017 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration