Truck has 116k miles, started losing power and acceleration diminished. CEL and Trac Off light came on. Pulled over twice after experiencing same issue. Took to mechanic and diagnostic code P0301 (cylinder 1 misfire). Replaced 6 spark plugs to be safe, and replaced broken coil in cylinder 1. Drove less than a mile and CEL came b…
Read full complaint
Truck has 116k miles, started losing power and acceleration diminished. CEL and Trac Off light came on. Pulled over twice after experiencing same issue. Took to mechanic and diagnostic code P0301 (cylinder 1 misfire). Replaced 6 spark plugs to be safe, and replaced broken coil in cylinder 1. Drove less than a mile and CEL came back on. Brought to dealership this time and they found a leak in the head gasket and noticed warping in cylinder 1, along with code P0301 still present. They reported back to me stating it needed a machinist to resurface the the cylinder head, that the repair is mechanical. Even outside of warranty this fix should not be costing $13,000. The truck has been properly maintained for the past 9 years, all oil services and replacing any wear and tear items. Mechanical (warping) is manufacturing issues.
NHTSA ODI #11741962
Mileage unknown · May 1, 2026
Fuel/propulsion System
Vehicle stalled on highway bridge. Took to mechanic shop. They put the diagnostic code machine on and the code indicated fuel pump failure. Toyota does have a recall notice for the year, make, and model of my vehicle. But not showing on my VIN.
NHTSA ODI #11735232
Mileage unknown · Nov 6, 2025
Fuel/propulsion System
Fuel leak at the fuel lines at the rear connection near the fuel tank, drivers side rear.
NHTSA ODI #11697819
Mileage unknown · Sep 17, 2025
Fuel/propulsion System
Truck does not accelerate fully when I hit gas pedal. The truck stalls and my gas consumption is off.
NHTSA ODI #11687805
Mileage unknown · Aug 7, 2025
Fuel/propulsion System
I was driving my 2017 Toyota Tacoma and I my car suddenly was lurching and running rough. I had to put on hazards on a main road and pull over immediately and was not even able to let it run for air conditioning. It was 108 degrees out that day, waited for 1 hour 30 minutes in heat. Had truck towed to mechanic that stated my fue…
Read full complaint
I was driving my 2017 Toyota Tacoma and I my car suddenly was lurching and running rough. I had to put on hazards on a main road and pull over immediately and was not even able to let it run for air conditioning. It was 108 degrees out that day, waited for 1 hour 30 minutes in heat. Had truck towed to mechanic that stated my fuel pump was bad and there was a federal mandate recall on this. I have the paperwork for this (attached), when I called dealership they said it was not covered so I called advocate for Toyota that stated my truck was built in June and the mandate was only for September of 2017 and forward. So I have the exact same problem that they have a federal mandate to fix but won't fix mine. If I had been on the freeway I could have been killed. I have attached estimate to fix.
NHTSA ODI #11679142
Mileage unknown · May 19, 2024
EngineFuel/propulsion System
2017 Toyota Tacoma double cab-V6 with 62K approx miles. On or around April 29th 2024, I was traveling in this truck when there was a sudden and complete loss of power, two check engine lights came on-The "trac off" light and the check engine light came on. I needed to pull over immediately for safety. I ended up driving the …
Read full complaint
2017 Toyota Tacoma double cab-V6 with 62K approx miles. On or around April 29th 2024, I was traveling in this truck when there was a sudden and complete loss of power, two check engine lights came on-The "trac off" light and the check engine light came on. I needed to pull over immediately for safety. I ended up driving the vehicle to the Toyota dealership in limp mode. The vehicle has sat at Tustin Toyota now for weeks with the Toyota dealership initially suggesting that a ACIS Flap broke off inside the intake manifold of the car. This was replaced and the vehicle is still providing the same alarms and still in limp mode. The initial fix(whihc did not fix the problem was a full replacement of the intake manifold). Now the dealer is suggesting that a piece(s) broke off the intake manifold and ended up inside the engine so now dealer is recommending and entire engine break down to attempt to further diagnose the situation. Again it looks to be a complete failuure of the ACIS system and the intake manifold. This problem has presented a EXTREME safety issue due to comp[lete loss for power initially then truck sits in LIMP Mode. Very dangerous!
NHTSA ODI #11589525
Mileage unknown · Mar 18, 2024
Fuel/propulsion SystemPower Train
The Tacoma still has only 10,000 original miles. We yearly replace the oil when we have our annual vehicle inspection. The truck has been trouble since the beginning. Early on I noticed when going downhill, the automatic transmission seems to slip when applying the gas. I have taken the truck back to the dealer in Kona to be to…
Read full complaint
The Tacoma still has only 10,000 original miles. We yearly replace the oil when we have our annual vehicle inspection. The truck has been trouble since the beginning. Early on I noticed when going downhill, the automatic transmission seems to slip when applying the gas. I have taken the truck back to the dealer in Kona to be told that it is not part of the rear end differential recall some years ago. I asked them to make a notation of this should the transmission or rear end differential fail in the future. Recently, we received an informational letter from Toyota regarding something about a possible faulty high pressure fuel pump. I made an appointment at the dealer and since I was there asked them for tire rotation, oil change and annual vehicle inspection. I explained to the service writer that I still believe there is a rear end or transmission problem. At first, she said, the recall was never done and later said it was done. More importantly, I have been smelling gasoline when I exit the truck although I see no visible fuel on the ground. I believe that this is related to the fuel pump issue which I received the letter from you. I was told several hours after I dropped off the truck that the fuel smell was not related to the letter I received.
NHTSA ODI #11578089
Mileage unknown · Dec 8, 2021
Fuel/propulsion System
I went to the gas station to fill up my tank and once I was done. I had trouble closing my fuel filler door. Fuel filler door is now broken and won’t close at all.
NHTSA ODI #11443025
95,000 miles · May 4, 2021
Fuel/propulsion System
THE TACH SHOWS THE ENGINE IS BOUNCING ALL OVER THE PLACE WHICH IS ESPECIALLY EVIDENT WHEN IDLING, BUT ALSO NOTICIBLE WHILE IN MOTION. I BELIEVE MY TRUCK SHOULD HAVE THE FUEL PUMP REPLACED. THE ENGINE RPMS JUMP ALL OVER WHEN DRIVING, WHEN BACKING UP OR JUST ROLLING WITHOUT PRESSURE ON THE GAS PEDAL, THE TRUCK JUMPS & DROPS IN SPE…
Read full complaint
THE TACH SHOWS THE ENGINE IS BOUNCING ALL OVER THE PLACE WHICH IS ESPECIALLY EVIDENT WHEN IDLING, BUT ALSO NOTICIBLE WHILE IN MOTION. I BELIEVE MY TRUCK SHOULD HAVE THE FUEL PUMP REPLACED. THE ENGINE RPMS JUMP ALL OVER WHEN DRIVING, WHEN BACKING UP OR JUST ROLLING WITHOUT PRESSURE ON THE GAS PEDAL, THE TRUCK JUMPS & DROPS IN SPEED. THIS HAS BEEN HAPPENING FOR SOME TIME NOW. WE HAVE TRIED ADDING DETERGENTS & USING BETTER QUALITY GAS BUT IT DOESN'T SEEM TO HELP.
NHTSA ODI #11415141
7,400 miles · Mar 24, 2021
Fuel/propulsion System
THE LEAK DETECTION PUMP SUB-ASSEMBLY, CHARCOAL CANISTER (PART # 90910-AF006) LOCATED ABOVE THE REAR AXLE WILL START "PUMPING" VERY LOUDLY EVEN AFTER THE VEHICLE HAS NOT BEEN DRIVEN IN EXCESS OF 8 HOURS. CONTINUES FOR APPROX 10 MINUTES, THEN SHUTS OFF. I WENT TO MY DEALERSHIP AND ASKED WHY THIS IS HAPPENING AND I WAS TOLD THAT "I…
Read full complaint
THE LEAK DETECTION PUMP SUB-ASSEMBLY, CHARCOAL CANISTER (PART # 90910-AF006) LOCATED ABOVE THE REAR AXLE WILL START "PUMPING" VERY LOUDLY EVEN AFTER THE VEHICLE HAS NOT BEEN DRIVEN IN EXCESS OF 8 HOURS. CONTINUES FOR APPROX 10 MINUTES, THEN SHUTS OFF. I WENT TO MY DEALERSHIP AND ASKED WHY THIS IS HAPPENING AND I WAS TOLD THAT "IT SEEMS UNUSUAL" AND THEN ASKED ME IF I PUMP GAS "BEYOND THE NORMAL CLICK TO STOP" - I SAID "NO", AND THAT I HADN'T GASSED UP IN OVER A WEEK. SO HE SAID TO JUST KEEP "AN EYE ON IT". DIFFICULT TO DETERMINE JUST HOW OFTEN THIS IS HAPPENING SINCE CLEARLY I'M NOT GOING TO BE IN THE GARAGE AT THE TIME THIS MAY BE OCCURRING. HAVING SAID THAT, A WEEK LATER THE SAME THING HAPPENED. I'M AFRAID THAT THERE'S SOME SORT OF ELECTRICAL ISSUE AT PLAY HERE, BUT I GET THE FEELING THAT THE DEALERSHIP WON'T DO ANYTHING BECAUSE OF THE SPORADIC NATURE OF THIS.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018 Toyota Camry and Highlander vehicles, 2017 Toyota Sienna and Tacoma vehicles and 2017 Lexus RX350 vehicles. During the manufacturing process, the oil galley in the rotor for the brake booster vacuum pump assembly may have been improperly machined possibly resulting in a sudden loss of brake assist.
Consequence & remedy
Consequence: A sudden loss of braking assist can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the brake booster vacuum pump, free of charge. The recall began on May 9, 2018. Owners may contact Toyota customer service at 1-888-270-9371, or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0K/JLD.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles equipped with a six-cylinder engine. The affected vehicles have a crank position sensor that may malfunction, potentially resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the crank position sensor with an improved design, free of charge. The recall began July 26, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0H.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles. Oil may leak from the area where the rear differential carrier is assembled to rear axle housing.
Consequence & remedy
Consequence: If the vehicle is operated with an insufficient amount of oil in the rear differential, the differential may seize and cause a loss of control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the rear differential for oil leakage. Based on the inspection, dealers will either tightening the fastening nuts or replace the fastening nuts and gasket. If the rear differential components are damaged, the rear differential carrier assembly will be replaced. The repairs will be performed free of charge. The recall June 19, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
2017 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration