2005 Toyota Tacoma

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. A MECHANIC FOUND LARGE HOLES, APPROXIMATELY FIVE INCHES IN DIAMETER, IN THE FRAME THAT HELD THE VEHICLE TOGETHER. THE DEALER CONFIRMED THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS INFORMED THAT MANY VEHICLES WERE REPAIRED WITH THE SIMILAR FAILURE. THE DEALER REFUSED TO REPAIR THE VEHICLE BECAUSE THE SERVICE BULLETIN EXPIRED ON 3/31/2016. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 109,450.

I TOOK MY VEHICLE IN FOR THE TOYOTA'S RECALL FOR THE SPIRAL CABLE. THE FAILURE LIGHT WAS NOT ON. A FEW MONTHS AFTER I GOT THE VEHICLE BACK THE FAILURE LIGHT CAN ON. TOYOTA SAID THE SPIRAL CABLE HAD FAILED AND WANTED $700 PLUS TO REPLACE IT. I AM GUESSING THEY DID NOT FIX THE VIBRATION THAT WAS CAUSING THE PROBLEM SO THE SYSTEM FAILED AGAIN. TOYOTA SHOULD HAVE FIXED THE VIBRATION AND LEFT THE SPIRAL CABLE ALONE. THE ORIGINAL CABLE WAS NOT CAUSING A PROBLEM. THEY HAVE REFUSED.

THERE HAS BEEN "RECALL' ON THESE VEHICLES REGARDING EXCESSIVE FRAME RUSTING. THIS CAR WAS "INSPECTED" AND FOUND NOT TO HAVE A DEFECT. A FEW WEEKS LATER THE BRAKES FAILED DUE TO BRAKE LINE RUST THOUGH. THE BRAKE LINE (FRONT BRAKES) WITH THE PROBLEM WAS MOUNTED ON THE FRAME. THE BRAKES FAILED WHEN I WAS EXITING A PARKING LOT AND DESCENDING A SHORT HILL TO THE MAIN STREET. I WAS UNABLE TO STOP THE CAR BEFORE IT ENTERED THE STREET BUT FORTUNATELY THERE WAS NO TRAFFIC AT THE TIME.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TAKEN TO THE DEALER TO BE SERVICED FOR NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION), THE TECHNICIAN STATED THAT THE FRAME OF THE VEHICLE WAS RUSTED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 225,000. THE VIN WAS NOT AVAILABLE.

RUSTED TOW HITCH! AS I WAIT FOR A REPLACEMENT FRAME, DUE TO A RECENT RECALL, I INQUIRED ABOUT THE HEAVILY RUSTED, FACTORY INSTALLED, TOW HITCH. I BOUGHT THE TRUCK TO HAUL A 3,000+ LBS BOAT AND SEEING HOW THE RUST COULD JEOPARDIZE NORMAL OPERATIONS, AND PERHAPS CAUSE AN ACCIDENT, WORRIES ME A LOT. I WAS TOLD THE HITCH IS NOT COVERED YET IF I BOUGHT ONE IT COULD BE INSTALLED, FREE OF CHARGE, WHILE SWAPPING THE FRAME. I FEEL AS THE HITCH RUST IS DUE TO THE SAME REASON AS THE FRAME AND SO IT SHOULD BE EXCHANGED AS WELL. THE SERVICE MANAGER WALKED ME TO THE PART DEPT. AND THE HITCH (W/O WIRES) COST $411. EVEN THE MANAGER ASKED IF IT WAS GOLD PLATTED. IF THERE IS NO FIX BY TOYOTA, I WOULD BE WILLING TO PAY HALF OF THE PRICE BUT NOT ALL. TOYOTA: PLEASE LOOK INTO THIS!

I TOO EXPERIENCED THE STIFFNESS WHILE STEERING. I ALMOST SPENT LARGE DOLLARS BUT DECIDE TO DO SOME RESEARCH ON THE INTERNET. I LEARNED THAT THE CAUSE OF IT WAS A RUSTED JOINT. AFTER SOME HEAVY SPRAYING WITH LUBRICANTS, I REGAINED NORMAL OPERATIONS. BUT ONLY UNTIL NEXT WINTER..UGH! RECOMMEND TOYOTA TAKES NOTE OF THIS AND DECIDE ON A SOLUTION FOR THOSE WHO ARE NOT MECHANICALLY INCLINED.

I EXPERIENCED ROUGH (STIFF, BINDING) STEERING IN BOTH DIRECTIONS AND WITHIN TWO WEEKS IT WAS PROGRESSIVELY GETTING WORSE. I THOUGHT I HAD A STEERING FLUID ISSUE, BUT THE DEALERSHIP IMMEDIATELY KNEW OF THIS PROBLEM AND CONFIRMED IT BY TURNING THE STEERING WHEEL. THEY KNEW RIGHT AWAY THAT IT WAS CAUSED BY A RUSTED U-JOINT ON THE BOTTOM OF THE INTERMEDIATE STEERING SHAFT (P/N 4520304020). IN ADDITION TO THE STIFF STEERING GOING INTO A TURN, THE STEERING WOULD NOT RETURN TO STRAIGHT AND I UNEXPECTEDLY NEARLY WENT INTO THE CURB. I BELIEVE THAT THIS IS A VERY UNSAFE CONDITION AND MUST BE BROUGHT TO THE ATTENTION OF ALL 2005 TACOMA OWNERS. I HAVE NEVER BEEN ADVISED OF ANY NEED TO PERFORM ANY SPECIAL SERVICING OF THIS PART AT ANY MILEAGE INTERVAL. IT APPEARS TO BE A BAD DESIGN THAT ALLOWS SALTY WATER FROM WINTER ROADS TO GET INTO THE U-JOINT WHICH THEN RUSTS.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS CORROSION AROUND THE ATTACHMENT AREA OF THE LEAF SPRINGS. THE TECHNICIAN DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE SUBFRAME WAS PREVIOUSLY SPRAYED WITH AN ANTI-CORROSION AGENT UNDER AN EXTENDED WARRANTY CAMPAIGN BY THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 76,000.