I HAVE 2005 TOYOTA TACOMA DOUBLE CAB 4X4, VEHICLE HAS A VIBRATION IN THE FRONT END AS IF THE FRONT TIRES ARE OUT OF BALANCE, THE TIRES HAVE BEEN BALANCED TWO TIMES IN THE LAST FEW MONTHS WHICH DOESN'T SEEM TO BE THE ISSUE. THE PROBLEMS SEEMS TO OCCUR AT SPEEDS OF 55 TO 65 MPH. IT COMES AND GOES AND GET TO POINT SOMETIMES IF FEE…
Read full complaint
I HAVE 2005 TOYOTA TACOMA DOUBLE CAB 4X4, VEHICLE HAS A VIBRATION IN THE FRONT END AS IF THE FRONT TIRES ARE OUT OF BALANCE, THE TIRES HAVE BEEN BALANCED TWO TIMES IN THE LAST FEW MONTHS WHICH DOESN'T SEEM TO BE THE ISSUE. THE PROBLEMS SEEMS TO OCCUR AT SPEEDS OF 55 TO 65 MPH. IT COMES AND GOES AND GET TO POINT SOMETIMES IF FEELS VERY UNSAFE TO HANDLE AT HIGHER SPEEDS. I HAVE TOLD THE DEALER TWICE ABOUT IT AND THEY SAY THERE'S NOTHING WRONG, YEAH RIGHT. *JB
NHTSA ODI #10162375
Mileage unknown · Mar 30, 2006
Suspension
POTENTIAL SAFETY HAZARD 29 MAR 06 05/06 TACOMA SUSPENSION DESIGN-DESIGN FLAW AND POTENTIAL SAFETY HAZARD. THIS IS NOT A QUESTION BUT A DESCRIPTION OF WHAT I AND OTHER PREVIOUS AND CURRENT TACOMA OR TRUCK OWNERS CONSIDER A DESIGN FLAW AND POTENTIAL SAFETY HAZARD. I'M HIGHLY DISAPPOINTED WITH THE FRONT END METAL SUSPENSI…
Read full complaint
POTENTIAL SAFETY HAZARD 29 MAR 06 05/06 TACOMA SUSPENSION DESIGN-DESIGN FLAW AND POTENTIAL SAFETY HAZARD. THIS IS NOT A QUESTION BUT A DESCRIPTION OF WHAT I AND OTHER PREVIOUS AND CURRENT TACOMA OR TRUCK OWNERS CONSIDER A DESIGN FLAW AND POTENTIAL SAFETY HAZARD. I'M HIGHLY DISAPPOINTED WITH THE FRONT END METAL SUSPENSION KNUCKLE THAT SITS A 1/2 INCH AWAY FROM THE MIDDLE OF THE TIRE. THIS IS ON THE 05 TACOMA CREW CAB 4X4 SHORTBED W/TRD, TOW PKG (OC)OPTIONS. -THIS CAUSES ISSUE THIS COULD CAUSE FLEXING OF THE TIRE DURING NORMAL ON-ROAD AND OFF-ROAD BUMPS CAUSING THE TIRE TO FLEX AND POSSIBLY RUB AGAINST THE SUSPENSION KNUCKLE. THIS SITUATION IS COMPOUNDED IF A TIRE RUNS A LITTLE LOW ON AIR PRESSURE AND COULD CAUSE A PREMATURE CUT TIRE OR BLOWOUT. ANOTHER UNRELATED ITEM--THE NEW 05/06 TACOMA REAR SUSPENSION BOTTOMS OUT TO EASY. DURING A RECENT HUNTING TRIP OCT 05 IN COLORADO. I HAD MY HUNTING GEAR DISTRIBUTED EVENLY IN THE CREW CAB AND THE SHORTBED (APPX 100PDS IN THE BACK SEAT, ONLY MYSELF 220PD IN DRIVER SEAT, AND APPX 400 PDS IN THE TRUCK BED. THE TRUCK BED HAD APPX 275 PDS BETWEEN THE WHEEL WELL AND TAILGATE AND OTHER 100-150 MAX IN FRONT OF BED EVENLY DESTROYED. THE TRUCK BOTTOMED OUT QUITE EASILY ON FAIRLY MINOR RUTS ON DIRT ROADS AND ON HIGHWAY DITCHES THAT WERE ONLY MINOR SLOPED AND SHOULD NOT HAVE CAUSE THE TRUCK TO BOTTOM OUT. THE TRUCK WAS NOT CLOSE TO THE 50% WEIGHT LIMIT AND THE REAR OF THE TRUCK STANDING STILL WAS NOT SAGGING MUCH AT ALL FROM THE WEIGHT. I WAS REALLY SHOCKED THAT IT SOUNDED LIKE THE TRUCK BOTTOMED OUT ON MINOR SLOW SPEED RUTS AND DURING HIGHWAY ROAD HUMPS OR DIPS. THIS NEVER HAPPENED WITH MY 95 OR 98 TACOMA UNLESS I HAD 75% PLUS OF THE BED CARRY LIMIT MET. I THINK YOU NEED TO BEEF UP OR RETEST/REDESIGN THE SPRINGS AND/OR SHOCKS TO MEET THE NEW TRUCKS WEIGHT AND LOAD CARRY CAPABILITIES BETTER. BILLY ARMOUR. *NM
NHTSA ODI #10154173
3,200 miles · Jan 13, 2006
Suspension
DT*: THE CONTACT STATED THERE IS A VIBRATION IN THE FRONT END OF THE VEHICLE AT SPEEDS OF 25 TO 35 MPH. THE FRONT TIRES HAVE BEEN REPLACED ONCE TRYING TO REMEDY THE PROBLEM. THE INDEPENDENT REPAIR SHOP PERSONNEL DETERMINED THE VIBRATION WAS DUE TO DEFECT IN THE FRONT SUSPENSION . THE MANUFACTURER HAS BEEN CONTACTED. *NM
NHTSA ODI #10147741
3,900 miles · Dec 25, 2005
Suspension
OVER NORMAL USE OF THE VEHICLE, IT HAS SUSTAINED SEVERAL PAINT CHIPS. THE PAINT HAS BEEN CHIPPED ON THE FRONT SIDE OF THE BED, FROM DEBRIS BEING THROWN UP BY THE FRONT TIRES, AND ON THE ROCKER PANELS. TOYOTA OBVIOUSLY THOUGHT OF THE ISSUE BY PLACING A THICKER COAT ALONG THE BOTTOM OF THE VEHICLE. IT DID NOT WORK. THE REAR SPRING…
Read full complaint
OVER NORMAL USE OF THE VEHICLE, IT HAS SUSTAINED SEVERAL PAINT CHIPS. THE PAINT HAS BEEN CHIPPED ON THE FRONT SIDE OF THE BED, FROM DEBRIS BEING THROWN UP BY THE FRONT TIRES, AND ON THE ROCKER PANELS. TOYOTA OBVIOUSLY THOUGHT OF THE ISSUE BY PLACING A THICKER COAT ALONG THE BOTTOM OF THE VEHICLE. IT DID NOT WORK. THE REAR SPRINGS ARE ALSO SQUEAKING ALREADY. USUALLY NOT AN ISSUE AS THE BUSHINGS WEAR OUT, BUT A LITTLE CONCERNED AFTER ONLY 4600 MILES HAVE BEEN PUT ON THE VEHICLE. *NM
NHTSA ODI #10146054
3,400 miles · Nov 6, 2005
Suspension
JUST BOUGHT 2005 TACOMA PRERUNNER DOUBLE CAB 4X2 TRD OFF ROAD VEHICLE AFTER DRIVING IT FOR A COUPLE OF DAYS WHEN DRIVING ON THE HIGHWAY AND REACH SPEED BETWEEN 60 TO 72 MPH THE VEHICLES SWAYS BACK AND FORTH LIKE A PATCH OF WIND IS PUSHING THE VEHICLE OR WHEN PASSING A SEMI TRUCK THE VEHICLE WILL SWAY BACK AND FORTH. BROUGHT BAC…
Read full complaint
JUST BOUGHT 2005 TACOMA PRERUNNER DOUBLE CAB 4X2 TRD OFF ROAD VEHICLE AFTER DRIVING IT FOR A COUPLE OF DAYS WHEN DRIVING ON THE HIGHWAY AND REACH SPEED BETWEEN 60 TO 72 MPH THE VEHICLES SWAYS BACK AND FORTH LIKE A PATCH OF WIND IS PUSHING THE VEHICLE OR WHEN PASSING A SEMI TRUCK THE VEHICLE WILL SWAY BACK AND FORTH. BROUGHT BACK TO DEALER MECHANIC SAID THAT IS A COMMON PROBLEM NOW WITH THIS VEHICLE AND THERE IS NO FIX FOR IT. THIS IS A SERIOUS PROBLEM WHICH CAN CAUSE AN ACCIDENT AT HIGH SPEEDS. ITS LIKE THE WIND IS BLOWING THE VEHICLE FROM SIDE TO SIDE. DON'T KNOW IF TOYOTA IS AWARE OF THE PROBLEM BUT I WOULD APPRECIATE IF THIS COULD BE INVESTIGATED AND REPORTED TO TOYOTA FOR A RECALL AND FIX THIS SERIOUS PROBLEM. I HAVE BEEN SEARCHING FOR A FIX TO THIS PROBLEM WITH NO SUCCESS AS OF YET. *NM
NHTSA ODI #10141849
16,000 miles · Nov 5, 2005
Suspension
BACK IN JUNE 2005 I OBSERVED A SIGNIFICANT "RUBBING" NOISE COMING FROM THE FRONT END OF MY 2005 TOYOTA TACOMA. UPON TAKING THE VEHICLE TO THE DEALERSHIP FOR WARRANTY REPAIR I WAS INFORMED THAT THE LEFT FRONT WHEEL BEARING WAS BAD. ON OCTOBER 24TH 2005 I RETURNED TO THE DEALER EXPERIENCING A SIMILAR "RUBBING" NOISE AND WAS TOLD…
Read full complaint
BACK IN JUNE 2005 I OBSERVED A SIGNIFICANT "RUBBING" NOISE COMING FROM THE FRONT END OF MY 2005 TOYOTA TACOMA. UPON TAKING THE VEHICLE TO THE DEALERSHIP FOR WARRANTY REPAIR I WAS INFORMED THAT THE LEFT FRONT WHEEL BEARING WAS BAD. ON OCTOBER 24TH 2005 I RETURNED TO THE DEALER EXPERIENCING A SIMILAR "RUBBING" NOISE AND WAS TOLD ON THIS OCCASION THAT BOTH THE LEFT AND RIGHT FRONT BEARINGS HAD FAILED. THIS VEHICLE ONLY HAS 20 THOUSAND MILES ON IT. I WAS INFORMED THAT THEY MUST BE POORLY MANUFACTURED BEARINGS. I'M CONCERNED THAT THIS MAY BE AN ONGOING PROBLEM AS WELL AS A SAFETY ISSUE. *JB
NHTSA ODI #10141832
3,567 miles · Jun 16, 2005
StructureSuspension
MY 2005 TOYOTA TACOMA PICKUP HAS SEVERE PAINT CHIPPING PROBLEMS ON THE ROCKER PANELS, LOWER DOORS, AND FRONT OF THE BEDSIDES. TOYOTA IS DENYING RESPONSIBILITY. THEY WANT TO DO A PAINT REPAIR WHICH WILL DEPRECIATE THE VALUE OF MY TRUCK INSTEAD OF GIVING ME A NEW TRUCK WHICH IS THE ONLY WAY TO PROPERLY CORRECT THE PROBLEM. UNLES…
Read full complaint
MY 2005 TOYOTA TACOMA PICKUP HAS SEVERE PAINT CHIPPING PROBLEMS ON THE ROCKER PANELS, LOWER DOORS, AND FRONT OF THE BEDSIDES. TOYOTA IS DENYING RESPONSIBILITY. THEY WANT TO DO A PAINT REPAIR WHICH WILL DEPRECIATE THE VALUE OF MY TRUCK INSTEAD OF GIVING ME A NEW TRUCK WHICH IS THE ONLY WAY TO PROPERLY CORRECT THE PROBLEM. UNLESS THEY WERE TO STRIP MY TRUCK DOWN TO BARE METAL AND REPAINT FROM SCRATCH, THERE IS NO OTHER WAY TO DO IT PROPERLY.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
Consequence & remedy
Consequence: IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
Remedy: DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration