2005 Toyota Tacoma

2005 TACOMA WITH SEVERE RUST PERFORATIONS TO FRAME. NOTIFED VEHICLE UNSAFE TO DRIVE. DEALER WILL NOT WARRANTY OR ASSIST. 8 YR OLD VEHICLE UNDRIVABLE. I TOOK MY 2005 TACOMA IN TO SEVRCO AUTO WINDWARD IN KANEOHE, HI ON 25 APRIL 2013 TO HAVE THE VEHICLE INSPECTED FOR SEVERE RUST PERFORATIONS ON THE FRAME. WHEN I DROPPED THE VEHICLE OFF THE ATTENDANT NOTIFIED ME THAT TOYOTA HAD SEEN A NUMBER OF THESE FRAME ISSUES AND THAT THEY HAD WARRANTIED 2 FRAMES THAT HE KNEW OFF--AT A COST OF APPROXIMATELY $12,000.00 PER FRAME. ON APRIL 29TH, I WAS TOLD THAT MY VEHICLE WAS UNSAFE TO DRIVE AND THAT I WOULD NEED TO SIGN A WAIVER TO RETRIEVE MY VEHICLE. DEALER HAD INSPECTED THE VEHICLE AND SENT PHOTOS TO TOYOTA TO SEE IF WARRANTY WORK WOULD BE COVERED. ON MAY 10TH, I WAS CONTACTED BY DEALER AND THEY NOTIFIED ME THAT MY VEHICLE WAS NOT COVERED UNDER WARRANTY AND THAT THEY WOULD DO NOTHING FOR ME. I SPENT OVER $30,000.00 ON A TOYOTA BECAUSE THEY HAD A REPUTATION FOR RELIABILITY AND CUSTOMER SERVICE. NOW 8 YEARS LATER, I HAVE A TRUCK THAT IS UNSAFE TO DRIVE, AND NO RECOURSE FROM THE DEALER. *TR

EXCESSIVE RUST BEGAN APPEARING ON THE FRAME OF THE VEHICLE AT 50,000 MILES. REVIEWED RUST WITH TOYOTA DEALERSHIP (4 TIMES OVER THE LAST 3 YEARS) AND THIS VEHICLE IS NOT INCLUDED IN ANY RECALLS FOR A RUSTY FRAMES. MY CONCRETE DRIVEWAY IS NOW STAINED WITH THE RUST COMING OFF OF THE VEHICLE. FRAME AND BUMPER IS NOW RUSTY AND GETTING WEAKER AS THE RUST CONTINUES. VEHICLE NOW HAS 90,000 MILES AND FRAME IS COVERED IN RUST. VERY CONCERNED ABOUT THE INTEGRITY OF THE FRAME. ADDITIONALLY, I NEEDED TO REPLACE THE STEERING KNUCKLE ON THE VEHICLE -- DUE TO EXCESSIVE WEAR - DUE TO EXTREME RUSTING. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE AT THE DEALER FOR UNRELATED REPAIRS, THE TECHNICIAN NOTICED RUST THROUGHOUT THE ENTIRE FRAME. THE CONTACT WAS UNAWARE OF THE NECESSARY REPAIRS TO CORRECT THE FAILURE. THERE WAS A MANUFACTURER'S RECALL FOR CORROSION OF THE FRAME HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,960. UPDATED 4/1/13 *CN THE CONSUMER STATED HE HAS SINCE TRADED THE VEHICLE.

DURING A ROUTINE OIL CHANGE I NOTICED A LARGE RUST HOLE IN THE PASSANGER SIDE FRAME RAIL. THE HOLE IS ROUGHLY 10-12 INCHES LONG ON THE INSIDE OF THE RAIL ROUGHLY UNDER THE PASSANGER SIDE FLOOR BOARD. I HAVE NOTICED ALOT OF SURFACE RUST OVER THE PAST COUPLE OF YEARS AND HAVE TRIED TO SEAL THE AREA..PAINT OR UNDER COAT... NOTHING SEEMS TO STOP THE RUST. I TOOK THE TRUCK TO THE DEALER WHERE YES THEY DO AKNOWLAGE THE HOLE BUT SAID SINCE THE TRUCK WAS OUT OF WARRANTY THEY WERE NOT PREPARED TO DO ANY THING ABOUT IT,,,SEE YA HAVE A NICE DAY. I UNDERSTAND THIS HAS BEEN AND STILL IS A MOJOR PROBLEM FOR TOYOTA. I CONTACTED TOYOTA AND LOGGED IN A COMPLAINT AND HAVE YET TO HEAR BACK. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT HE NOTICED A HOLE IN THE FRAME OF THE VEHICLE DUE TO RUST. THE VEHICLE WAS TAKEN TO A DEALER, WHO CONFIRMED THERE WAS A HOLE IN THE FRAME OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 98,000.

TO WHO IT MAY CONCERN: WOULD YOU BE ABLE TO RESEARCH AND COVER A 2005 TOYOTA TACOMA PROBLEM PLAGUING TOYOTA CUSTOMER. THE ISSUES IS A PROBLEM WITH THE DESIGN OF THE FRAME. THE FRAMES ARE FAILING AT THE ENGINE MOTOR MOUNT(VERY VERY DANGEROUS) AND CAUSING THE CARS TO BE ALMOST BE IN-REPAIRABLE(TOYOTA ADVISE ME IT WOULD BE 10,000 FIX). TOYOTA IS OFFERING NO ASSISTANCE AND THERE ARE TONS OF CUSTOMER FEEDBACK ONLINE TO SHOW THERE IS A PROBLEM WITH THEIR FRAMES. FOR MY TRUCK I HEARD A NOISE COMING FROM THE ENGINE ON 12/24/2012 AND TOOK INTO A DEALER ON 12/26/2012. THEY SAID IT WAS THE FAN HITTING THE FAN SHROAD THEY SAID THEY FIXED IT. I STARTED HEARING THE NOISE AGAIN AND HAD TO TAKE IT IN ON 1/5/2013...THEY FIRST SAID IT WAS MY MOTOR MOUNTS AND WOULD NEED TO ORDER THE PART..WHEN THEY WERE GOING TO INSTALL THE PART THEY NOTICE A CRACK IN THE FRAME WHERE IT CONNECTS TO THE MOTOR MOUNT. THEY SAID THERE WAS NO OTHER SIGNS IF DAMAGE ANY WHERE AND DID NOT KNOW HOW THAT HAPPENED...MEANING THE FRAME FAILED FROM THE TORQUE OF THE ENGINE.. THEY ADVISE I WOULD NEED TO GET NEW FRAME ($10,000)...I CALLED TOYOTA AND ADVISE THEY WOULD NOT ASSIST. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE SPARE TIRE FELL AND DETACHED FROM THE VEHICLE. THE SPARE TIRE WAS LOCATED UNDER THE VEHICLE AND THE CONTACT STATED THAT THE ENTIRE CROSS MEMBER ON THE REAR OF THE VEHICLE BECAME RUSTED. THE CONTACT STATED THAT HALF OF THE REAR CROSS MEMBER ALSO FRACTURED AND DETACHED FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE CROSS MEMBER THAT WAS LOCATED IN THE CENTER OF THE VEHICLE WAS ALSO COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 145,000.