hello good afternoon my name is [XXX] I have a Toyota Tacoma 2005 could you help me with some information it has a chassis with holes and rotten. Toyota was changing all chassis that had this defect in 2018 to 2020 at no cost, the first owner didn't know about it and I wasn't even warned. I would like to know if I am entitled …
Read full complaint
hello good afternoon my name is [XXX] I have a Toyota Tacoma 2005 could you help me with some information it has a chassis with holes and rotten. Toyota was changing all chassis that had this defect in 2018 to 2020 at no cost, the first owner didn't know about it and I wasn't even warned. I would like to know if I am entitled to a free chassis exchange? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11509346
Mileage unknown · Feb 23, 2023
StructureUnknown Or Other
Hi, I have a 2005 Toyota Tacoma, the chassis is rusty and has holes in it. I went to complain at Toyota, they said the car didn't have a Recall but neither the first owner nor I had news that I would have to change the car's frame. I would like help to resolve this. all parts under the car are very rusty
NHTSA ODI #11508816
Mileage unknown · Sep 15, 2022
Structure
My 2005 Toyota Tacoma had a recall due to potential frame rusting. I brought my Truck to my local Toyota Dealership for the frame inspection as stated in the recall notice I received. The frame did not need to be replaced and at a later date the frame was sealed per Toyota's remedy. In March of 2022 I had an issue with my tru…
Read full complaint
My 2005 Toyota Tacoma had a recall due to potential frame rusting. I brought my Truck to my local Toyota Dealership for the frame inspection as stated in the recall notice I received. The frame did not need to be replaced and at a later date the frame was sealed per Toyota's remedy. In March of 2022 I had an issue with my truck that required the gas tank to be removed. As it turned out there was major rust to the frame that was located behind the gas tank that was never sealed during the original remedy to the frame rusting issue. I contacted Toyota about the issue and was told that the extended warranty for the Issue had expired. I was told to contact the local dealership. In conversation with the dealership I was told there was nothing they can do. I feel that if this issue has happened to my truck, there must be other trucks on the road with the same issue that the owners have no Idea what is happening to their frames that may cause a safety issue should the frame completely fail. My truck is available for inspection. Neither the dealer or Toyota inspected the Issue. I feel Toyota should have had the hindsight to have the dealers remove the gas tank and seal the frame behind the tank.
NHTSA ODI #11484712
170,000 miles · Mar 7, 2022
Structure
The contact owns a 2005 Toyota Tacoma. The contact stated that while his vehicle was parked, he noticed that the subframe was extremely rusted. The contact noticed a 10-inch crack on the inside driver’s side rear of the vehicle. The vehicle was taken to the dealer dealer and the contact was informed that the subframe needed to b…
Read full complaint
The contact owns a 2005 Toyota Tacoma. The contact stated that while his vehicle was parked, he noticed that the subframe was extremely rusted. The contact noticed a 10-inch crack on the inside driver’s side rear of the vehicle. The vehicle was taken to the dealer dealer and the contact was informed that the subframe needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000. Consumer stated rust is the worst near the catalytic converters. It is also bad just in front of the rear tires. It’s a manufacturer flaw where they designed the double wall to where water could get in but not get out and the frame rots from the inside out. This truck was garage kept.
NHTSA ODI #11455547
Mileage unknown · Nov 14, 2021
EngineStructureUnknown Or Other
The frame of my truck failed at the motor mount. The motor mount has sunk into the frame shifting the motor and effecting performance and other parts. This can be confirmed by anyone. I never received recall information, I can’t find evidence of one issued for this year or my state.
NHTSA ODI #11440418
255,000 miles · Oct 4, 2021
Structure
The contact owns a 2005 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed punctures and corrosion on the main subframe. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated that an unknown recall repair was performed …
Read full complaint
The contact owns a 2005 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed punctures and corrosion on the main subframe. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated that an unknown recall repair was performed to the subframe in August 2014. The failure mileage was approximately 255,000.
NHTSA ODI #11435378
131,205 miles · Apr 19, 2021
Structure
THE VEHICLE WAS IN THE SHOP FOR SERVICE,THE TEC INFORMED ME IT WOULD NOT PASS NYS IINSPECTION DUE TO RUST HOLES IN THE FRAME.
NHTSA ODI #11412935
131,205 miles · Apr 16, 2021
Structure
FRAME HAS RUST HOLES IN IT AND WILL NOT PASS NEXT NYS INSPECTION.
NHTSA ODI #11408481
132,127 miles · Dec 25, 2020
Structure
TRUCK WAS TAKEN IN FOR COOLANT LEAK. TECHNICIAN FOUND THE FRAME TO BE RUSTED THROUGH AND WAS ADVISED TRUCK WAS NO LONGER SAFE TO OPERATE. TRUCK WAS STATIONARY IN DEALERS REPAIR BAY.
NHTSA ODI #11384942
138,000 miles · Nov 20, 2020
Structure
FRAME RUSTED SEVERELY. HAVE BEEN ADVISED IT IS UNSAFE TO DRIVE.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
Consequence & remedy
Consequence: IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
Remedy: DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration