TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. AFTER PUMPING TEN GALLONS OF FUEL IN THE VEHICLE AND DRIVING HOME, THE CONTACT NOTICED THAT THE FRONT STRAP HOLDING THE FUEL TANK FRACTURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000. UPDATED 010/…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. AFTER PUMPING TEN GALLONS OF FUEL IN THE VEHICLE AND DRIVING HOME, THE CONTACT NOTICED THAT THE FRONT STRAP HOLDING THE FUEL TANK FRACTURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000. UPDATED 010/04/16*LJ *TR
NHTSA ODI #10898331
85,000 miles · May 6, 2014
Fuel System, GasolineStructure
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER REFUELING, ONE OF THE FUEL TANK STRAPS FRACTURED AS A RESULT OF CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MIL…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER REFUELING, ONE OF THE FUEL TANK STRAPS FRACTURED AS A RESULT OF CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 85,000. UPDATED 06/17/14*LJ THE CONSUMER STATED ONE OF THE TWO STRAPS THAT SECURED THE GAS TANK FAILED UNDER THE WEIGHT OF THE TANK. THE TANK WAS TILTED AS A RESULT. THE STRAP FAILED AS A RESULT OF CORROSION. UPDATED 06/24/14
NHTSA ODI #10586827
132,000 miles · Feb 21, 2014
Fuel System, GasolineStructure
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH AND MAKING A LEFT TURN, AN ABNORMAL NOISE WAS HEARD FROM UNDER THE BODY OF THE VEHICLE. THE CONTACT LATER DISCOVERED THAT THE METAL STRAPS USED TO SECURE THE FUEL TANK TO THE VEHICLE HAD RUSTED AND FRACTURED, CAUSING THE RIGHT FR…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH AND MAKING A LEFT TURN, AN ABNORMAL NOISE WAS HEARD FROM UNDER THE BODY OF THE VEHICLE. THE CONTACT LATER DISCOVERED THAT THE METAL STRAPS USED TO SECURE THE FUEL TANK TO THE VEHICLE HAD RUSTED AND FRACTURED, CAUSING THE RIGHT FRONT SECTION OF THE FUEL TANK TO HANG FROM THE VEHICLE. THE CONTACT ALSO INDICATED THAT THE FRACTURED METAL STRAP WOULD MAKE CONTACT WITH THE DRIVE SHAFT WHENEVER THE CONTACT WAS MAKING A LEFT TURN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000. ..UPDATED 04-22-14 *BF THE CONSUMER STATED THE DEALER WAS CHARGING HIM $1900 TO FIX THE PROBLEM. TWO MORE STRAPS BROKE, WHEN THE DEALER PUT THE VEHICLE ON THE RACK, WHICH CAUSED THE TANK TO FALL PULLING OUT THE GAS LINES AND WIRING, AS WELL AS CRACKING THE TANK. UPDATED 04/23/14.
NHTSA ODI #10565302
114,690 miles · Aug 16, 2010
Air BagsFuel System, GasolineVehicle Speed ControlCrash
2ND TIME A GAS PEDAL STUCK ON MY 2005 TOYOTA TACOMA TRUCK LEADING TO A 2ND COLLISION WITH PROPERTY DAMAGE TO MY TRUCK & THE CAR IN FRONT OF ME. COMING UP TO A RED LIGHT WITH PLENTY OF ROOM TO STOP ON A FLAT RD. THERE WHERE SKID MARKS FROM MY TRUCK AND I HAD BOTH FEET ON THE BRAKE AND THE ENGINE INCREASED INSPEED. THE DEALER STIL…
Read full complaint
2ND TIME A GAS PEDAL STUCK ON MY 2005 TOYOTA TACOMA TRUCK LEADING TO A 2ND COLLISION WITH PROPERTY DAMAGE TO MY TRUCK & THE CAR IN FRONT OF ME. COMING UP TO A RED LIGHT WITH PLENTY OF ROOM TO STOP ON A FLAT RD. THERE WHERE SKID MARKS FROM MY TRUCK AND I HAD BOTH FEET ON THE BRAKE AND THE ENGINE INCREASED INSPEED. THE DEALER STILL DOES NOT HAVE THE PARTS TO REPAIR THIS PROBLEM EVEN AFTER MY FIRST ACCIDENT IN JUNE OF LAST YEAR AND AGAIN IN JULY OF THIS YEAR. TOYOTA SAID THEY WOULD TURN IT OVER TO THERE LEGAL DEPT. AND THE TRUCK WAS TO BE INSPECTED BY A ENGINEERING FIRM FROM THE WEST. THE INSPECTION FIRM WAS IN A HURRY TO INSPECT THE TRUCK AND CALLED IN JULY NOW THEY WON'T RETURN MY CALLS. THIS FIRM WAS HIRED BY TOYOTA. ALSO DURING THE REPAIR IT WAS FOUND THAT THE AIR BAG HAD SHORTED OUT AND DID NOT DEPLOY. IF YOU HAVE ONE OF TOYOTA'S TRUCKS ON THE RECALL LIST BE VERY CAREFUL AND DON'T EXPECT ANY HELP FROM THE DEALER OR TOYOTA FIXING THE PROBLEM. AS I SAID IT IS THE 2ND TIME FOR BOTH ITEMS TO FAIL. *TR
NHTSA ODI #10349678
600,000 miles · Feb 12, 2010
Fuel System, GasolineVehicle Speed Control
I RECEIVED A RECALL NOTIFICATION FROM TOYOTA IN OCTOBER OF 2009 FOR ACCELERATOR PEDALS STICKING TO CARPET. THE LETTER FROM TOYOTA STATED THEY WOULD CONTACT ME ON WHAT TO DO NEXT TO GET IT FIXED. ITS FEBRUARY 12, 2010 AND I HAVE HEARD NOTHING FROM THEM ABOUT WHAT TO DO ON THIS ISSUE. *TR
NHTSA ODI #10308968
7,500 miles · Apr 25, 2007
Fuel System, GasolinePower Train
TL*THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT SMELLED ASPHYXIATE GAS FUMES WHEN COLD STARTING THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE OR DUPLICATE THE FAILURE. THE CURRENT MILEAGE IS 8,000, AND THE FAILURE MILEAGE IS UNKNOWN. THERE WERE NO WARNING INDICATORS. *AK THE CONSUMER PROVIDED A COPY OF REPAIR INVO…
Read full complaint
TL*THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT SMELLED ASPHYXIATE GAS FUMES WHEN COLD STARTING THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE OR DUPLICATE THE FAILURE. THE CURRENT MILEAGE IS 8,000, AND THE FAILURE MILEAGE IS UNKNOWN. THERE WERE NO WARNING INDICATORS. *AK THE CONSUMER PROVIDED A COPY OF REPAIR INVOICE. THE DEALER STATED CREAK SOUND CLUTCH PEDAL WHEN DEPRESSED AND DIFFICULTY PUTTING INTO 4WD, BUT FACTORY NEVER ABLE TO DUPLICATE THE PROBLEM. UPDATED 07/06/07 *TR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
Consequence & remedy
Consequence: IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
Remedy: DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration