Structure. Review the 228 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports4 fire reports25 injury reports

Service Brakes, Hydraulic complaints

12 reports

Clear category filter

Mileage unknown · Sep 25, 2001

EquipmentPower TrainSeat Belts

CONSUMER COULD HEAR A GRINDING NOISE WHEN MAKING A SLOW RIGHT TURN OR PULLING INTO A PARKING SPACE, DEALER FOUND CONTAMINATED BRAKE PADS AND REPLACED THEM, HOEWVER NOISE CONTINUED, CONSUMER ALSO NOTICED THAT VEHICLE WOULD NOT COME TO A COMPLETE STOP, DEALER FOUND THAT ABS SENSOR WAS INSTALLED INCORRECTLY AND MADE REPAIRS. *SLC

NHTSA ODI #563269

Mileage unknown · Jul 20, 2001

Parking BrakeService Brakes, Hydraulic

Read full complaint

WHILE DESCENDING A MODERATELY STEEP DIRT ROAD WE EXPERIENCED A TOTAL FAILURE OF THE HYDRAULIC AND EMERGENCY BRAKING SYSTEMS. VEHICLE WAS COASTED TO A STOP ON A FLAT AREA OF ROAD. AFTER APPROXIMATELY 45 MINUTES BRAKE SYSTEM SLOWLY RETURNED TO NORMAL OPERATION. LOCAL DEALER INSPECTION REVEALED NO APPARENT CAUSE FOR THE MALFUNCTION AND NO SUGGESTION AS TO WHAT POSSIBLY COULD HAVE CAUSED BOTH BRAKE SYSTEMS TO FAIL. NO EVIDENCE OF BRAKE OVERHEATING OR FATIGUE, NO FLUID LEAKS OR STORED COMPUTER FAULT CODES. DEALER SUGGESTION, "DRIVE IT TILL IT FAILS AGAIN AND BRING IT BACK".*AK

NHTSA ODI #748811

Official recalls

12V542000 · Tires:temporary/emergency Spare Tire

Nov 23, 2012

Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.

Consequence & remedy

Consequence: Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.

Remedy: Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

05V225000 · Suspension:front:control Arm:lower Ball Joint

May 17, 2005

ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

Consequence & remedy

Consequence: THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

03V189000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

May 19, 2003

ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.

Consequence & remedy

Consequence: THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.

Remedy: DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

01V186000 · Tires:sidewall

Jun 7, 2001

VEHICLE DESCRIPTION: 4X2 TRUCKS EQUIPPED WITH TU4 WHITE LETTER TIRE UPGRADE OPTION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. TIRE DAMAGE MAY HAVE OCCURRED DUE TO IMPROPER INSTALLATION, WHICH COULD CAUSE THE TIRE TO DEFLATE OR A BULGE APPEARING IN THE SIDEWALL OF THE TIRE.

Consequence & remedy

Consequence: AN IMPROPERLY INFLATED TIRE COULD RESULT IN VEHICLE HANDLING PROBLEMS OR A BLOW OUT OF AN IMPROPERLY INSTALLED TIRE.

Remedy: DEALERS WILL CHECK ALL FOUR TIRES, REBALANCE AND, IF NECESSARY, REPLACE ANY DAMAGED TIRE. OWNER NOTIFICATION BEGAN JULY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.