IllustrationWITH SECOND CENTER SEAT INSTALLED (8-PASSENGER VAN), THE RECLINER COULD NEVER AUTOMATICALLY COME BACK UP WHEN PULL THE LEVER. DEALER INSPECTED IT AND DIDN'T FIND ANY ISSUE. HOWEVER, IT IS NOT NORMAL TO PULL THE LEVER AND SEAT BACK UP AT THE SAME TIME, ESPECIALLY WHEN SITTING ON THE CHAIR.
2016 Toyota Sienna
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 2016 Toyota Sienna are lower than the model-year median of 183.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sienna years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
725–50K
550–75K
175–100K
1100–150K
0150K+
38 reports with mileage · 37 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports4 injury reports
What owners actually said
75 reportsPASSING A CONSTRUCTION ZONE ON HIGHWAY (AT SPEED ABOUT 40MPH) , SEVERAL SMALL GRAVELS HIT THE WINDSHIELD AND MADE A FEW CHIPS. SOMETHING LIKE THIS HAPPEND TO MY PREVIOUS CAR TOO, BUT NEVER MADE ANY DAMAGE AT ALL. SO I SUSPECT THE WINDSHIELD ON 2016 SIENNA IS NOT STRONG ENOUGH AND WORRY ABOUT ITS SAFETY.
RIGHT SIDE PASSENGER DOOR, OPENED BY ITSELF WHILE DRIVING. MY JIDS WERE SEATED ON THE BACK WITH GRANDMA. DOOR ALSO, CLOSES BY ITSELF HURTING THE PASSENGER WHO IS TRYING TO GET INTO. IT HURT SEVERAL TIMES MY 8YR OLD DAUGHTER, MY 11 YR OLD BOY AND GRANDMA. EVEN CLOSES WHEN YOU ARE PUTTING STUFF IN THE PASSENGER SIDE.
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER (CAVENDER TOYOTA 5730 NW LOOP 410 SA…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER (CAVENDER TOYOTA 5730 NW LOOP 410 SAN ANTONIO, TX, 78238) CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TOYOTA SIENNA FAULTY POWER SLIDING DOORS. THE VEHICLE WAS PARKED. WHEN WE TRIED TO OPEN THE DOOR, THE CABLE SNAPPED. THEN WE WON'T BE ABLE TO CLOSE IT. WE HAD TO CUT THE REMAINING CABLE BEHIND THE SLIDING WHEEL TO MANUALLY CLOSE THE DOOR.
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PART NOT AVAILABLE.
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE); HOWEVER, THE REMEDY WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HA…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE); HOWEVER, THE REMEDY WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA EQUIPPED WITH FIRESTONE FR710 TIRES, SIZE 205/65R16. WHILE THE VEHICLE WAS PARKED, THE CONTACT HEARD AN EXPLOSION. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE FRONT DRIVER SIDE TIRE EXPLODED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. …
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA EQUIPPED WITH FIRESTONE FR710 TIRES, SIZE 205/65R16. WHILE THE VEHICLE WAS PARKED, THE CONTACT HEARD AN EXPLOSION. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE FRONT DRIVER SIDE TIRE EXPLODED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 3,750.
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACT AND CONFIRMED THAT THE PART…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACT AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (LATCHES/LOCKS/LINKAGES). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AN…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V858000 (LATCHES/LOCKS/LINKAGES). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND INFORMED THE CONTACT NOT TO USE THE FEATURE FOR THE POWER DOORS. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Official recalls
525V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
19V553000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 25, 2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.
Consequence & remedy
Consequence: The contact may cause failure of the rear brake hoses, resulting in a loss of vehicle control and reduced braking ability, increasing the risk of a crash.
Remedy: Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.
19V410000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jun 4, 2019
Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.
Consequence & remedy
Consequence: The reduction in the braking system pressure may cause a loss of braking power in the rear braking system, increasing the risk of crash.
Remedy: Braun has notified owners, and dealers will install an adaptor to correct the issue, free of charge. The recall began June 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.
16V858000 · Structure:body:door
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
16V197000 · Seat Belts:front
Apr 7, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota Sienna vehicles manufactured February 15, 2016, to February 19, 2016. In the affected vehicles, incorrect front seat belt height adjusters may have been installed. During a crash, this incorrect height adjuster may contact the B-pillar and tear or separate.
Consequence & remedy
Consequence: Failure and detachment of seat belt height adjuster would result in the occupant not being properly restrained in a crash, increasing their risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the front seat belt height adjusters, free of charge. The recall began on April 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0H.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.