NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
30 reportsClear category filter100,000 miles · May 30, 2017
Power TrainStructure
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 30 MPH, A LOUD NOISE WAS HEARD UNDERNEATH THE FRONT END OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TOWED TO SONOCO AUTO SHOP, LEXINGTON ARK, MD, WHERE IT WAS DIAGNOSED THAT THE FRONT RIGHT DRIVE SHAFT WAS FRACTURED. ALSO, THE FRONT DRIVER SIDE DRIVE SHAF…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 30 MPH, A LOUD NOISE WAS HEARD UNDERNEATH THE FRONT END OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TOWED TO SONOCO AUTO SHOP, LEXINGTON ARK, MD, WHERE IT WAS DIAGNOSED THAT THE FRONT RIGHT DRIVE SHAFT WAS FRACTURED. ALSO, THE FRONT DRIVER SIDE DRIVE SHAFT WAS FAULTY. THE TECHNICIAN RECOMMENDED THAT BOTH PARTS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REPAIRED. ALSO, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V858000 (STRUCTURE), 14V273000 (TIRES), AND 11V560000 (EQUIPMENT). THE FAILURE MILEAGE WAS 100,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10992208
78,000 miles · Jul 8, 2016
Power Train
I'M OWNER OF TOYOTA SIENNA 2011 5 YEARS 2-ND OWNER 79K MILES AND EXPERIENCE WHIRRING NOISE IN REAR DIFFERENTIAL AFTER VISITING TOYOTA DEALERS WITHOUT ANY SUCCESS ACCEPT PRICE TAG FOR REPLACEMENT REAR DIFFERENTIAL COUPLER. AFTER THAT DO SOME RESEARCH AND FIND THE OTHER OWNERS EXPERIENCE THAT SAME ISSUE FIND THAT TSB #TSB-0…
Read full complaint
I'M OWNER OF TOYOTA SIENNA 2011 5 YEARS 2-ND OWNER 79K MILES AND EXPERIENCE WHIRRING NOISE IN REAR DIFFERENTIAL AFTER VISITING TOYOTA DEALERS WITHOUT ANY SUCCESS ACCEPT PRICE TAG FOR REPLACEMENT REAR DIFFERENTIAL COUPLER. AFTER THAT DO SOME RESEARCH AND FIND THE OTHER OWNERS EXPERIENCE THAT SAME ISSUE FIND THAT TSB #TSB-0080-13 NHTSA ID #10052631 WITH MODEL RAV4 USE THIS SAME DIFFERENTIAL COUPLER HAVE EXTRA EXTENDED WARRANTY BECAUSE OF THAT ISSUE. HOW SAFETY RIGHT NOW IS CAR TO DRIVE I DON'T KNOW IN MY CASE WITH 3 KIDS ABOARD I WILL REPLACE THAT DIFFERENTIAL COUPLER ON MY COST RIGHT NOW, AND DO SOME INVESTIGATION LATER. PLEASE SEE UPLOAD FILE WITH SOME RESEARCH I DO THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10883703
15,600 miles · Nov 16, 2015
Power TrainService BrakesVehicle Speed ControlCrash
I PULLED INTO A RELATIVE'S GRAVEL DRIVEWAY WHICH HAS A VERY LARGE PARKING AREA TO THE SIDE. I PULLED UP TO ABOUT TWO FEET FROM THEIR GRASSY AREA, GOT INTO POSITION TO BACK UP INTO A PARKING SPACE, STOPPED, AND PUT MY 2011 SIENNA INTO REVERSE, AND AS SOON AS I GENTLY TOUCHED THE EXCELERATOR TO BEGIN BACKING UP THE VAN SPED FORWAR…
Read full complaint
I PULLED INTO A RELATIVE'S GRAVEL DRIVEWAY WHICH HAS A VERY LARGE PARKING AREA TO THE SIDE. I PULLED UP TO ABOUT TWO FEET FROM THEIR GRASSY AREA, GOT INTO POSITION TO BACK UP INTO A PARKING SPACE, STOPPED, AND PUT MY 2011 SIENNA INTO REVERSE, AND AS SOON AS I GENTLY TOUCHED THE EXCELERATOR TO BEGIN BACKING UP THE VAN SPED FORWARD AT A HIGH RATE OF SPEED CRASHING INTO AND OVER AN 8 INCH RAILROAD TIE THAT HAD A STEELBEAM ON TOP THAT SEPARATED THE DRIVEWAY FROM THEIR YARD. I HAD TO SLAM BOTH FEET ONTO THE BRAKE TO GET IT TO STOP WHICH IT FINALLY DID. I THOUGHT I HAD NOT PUT IT IN REVERSE BUT I LOOKED AT THE GEARSHIFT AND IT WAS INDEED IN REVERSE. I JIGGLED THE GEARSHIFT TO MAKE SURE IT WAS SECURED IN THE SLOT AND IT WAS. I THEN PUT IT IN PARK AND SAT THERE FOR A MINUTE OR TWO TRYING TO GAIN COMPOSURE TRYING TO FIGURE OUT WHAT JUST HAPPENED, I WAS IN SHOCK AS NOTHING LIKE THIS HAS EVER HAPPENED TO ME BEFORE. AFTER THAT MINUTE OR TWO I DECIDED I COULDN'T LET THE VEHICLE SIT THERE AND NEEDED TO MOVE IT. SCARED, BUT I PUT IT IN REVERSE AGAIN, READY TO POUNCE ON THE BRAKES WITH BOTH FEET AND BARELY TOUCHING THE EXCELERATOR I STARTED MOVING IN REVERSE. IT WAS WORKING FINE THEN. I THEN GOT OUT TO CHECK FOR DAMAGE AND THE BUMPER ON THE DRIVER'S SIDE WAS DAMAGED FROM THE IMPACT. THE AIRBAG DID NOT DEPLOY, I WAS NOT HURT HOWEVER HAD ANY OF MY RELATIVES BEEN IN THAT AREA AT THAT MOMENT IT COULD'VE RESULTED IN AN INJURY OR FATALITY. I REPORTED WHAT HAPPENED TO THE LOCAL DEALERSHIP WHERE I BOUGHT IT AND THEN TO TOYOTA USA AS INSTRUCTED IN THE HANDBOOK. NOW I'M REPORTING IT HERE. AM AWAITING CONTACT SUPPOSEDLY WITHIN THE NEXT DAY OR SO TO SEE WHAT TOYOTA INTENDS TO DO WITH THE SIENNA. I WILL NOT DRIVE AGAIN IT UNTIL THE REASON FOR THIS DEFECT IS FOUND AND FIXED AND DAMAGES REPAIRED. THE OUTCOME WILL DECIDE WHETHER I WILL EVER BE A TOYOTA CUSTOMER AGAIN.
NHTSA ODI #10790549
24,000 miles · Feb 22, 2015
Power Train
HELLO, I OWN A 2011 SIENNA LE V6. IN COLD WEATHER, IT HAS A PROBLEM WHEN BREAKING WHERE THE VEHICLE LURCHES FORWARD AS IT COMES TO A STOP (A SIGNIFICANT INCREASE IN RPM IS SEEN JUST AS THE VEHICLE IS ABOUT TO STOP). SO MUCH SO THAT IT SEEMS AS THOUGH IT'S GIVING ITSELF GAS (INCREASED RPM) AND DRIVING ITSELF, CREATING A HAZARD. I…
Read full complaint
HELLO, I OWN A 2011 SIENNA LE V6. IN COLD WEATHER, IT HAS A PROBLEM WHEN BREAKING WHERE THE VEHICLE LURCHES FORWARD AS IT COMES TO A STOP (A SIGNIFICANT INCREASE IN RPM IS SEEN JUST AS THE VEHICLE IS ABOUT TO STOP). SO MUCH SO THAT IT SEEMS AS THOUGH IT'S GIVING ITSELF GAS (INCREASED RPM) AND DRIVING ITSELF, CREATING A HAZARD. I CAN LITERALLY TAKE MY FOOT OFF THE BRAKE PEDAL AND THE VAN WILL INCREASE IT'S SPEED TO ABOUT 35MPH WITH NO INPUT FROM ME IN REGARDS TO THE GAS PEDAL. AFTER WARMING UP, THE PROBLEM DOES TEND TO FADE AWAY. BUT THE WARMUP PERIOD, ESPECIALLY ON COLD NORTHEAST DAYS, COULD TAKE AS LONG AS 20 MINS. AND 8 MILES OF CITY DRIVING TO OCCUR (AND THIS IS AFTER A 5 MIN. PARKED IDLE WARMUP PERIOD), AND EVEN THEN, THE VAN STILL EXHIBITS THIS REVVING ISSUE SOMEWHAT, JUST NOT AS SIGNIFICANT AS WHEN IT'S IN THE WARMUP STAGE. ON MY FIRST COMPLAINT LAST WINTER, THE DEALER CHANGED OUT THE THERMOSTAT AND CONSIDERED THE PROBLEM FIXED. HOWEVER, THE VAN CONTINUES TO SHOW THE SAME PROBLEM THIS WINTER. AS YOU CAN SEE ON THIS INTERNET THREAD, MANY OTHER OWNERS HAVE THE SAME ISSUE. HTTP://WWW.SIENNACHAT.COM/FORUM/193-PROBLEMS-MAINTENANCE-REPAIR/158410-ENGINE-REVVING-UP-JUST-BEFORE-STOP.HTML THIS ISSUE IS NOT JUST ANNOYING, I BELIEVE IT IS A SAFETY ISSUE, PARTICULARLY ON SLIPPERY SURFACES SUCH AS SNOW AND ICE WHICH ARE LIKELY TO OCCUR IN THE COLDER WEATHER THAT PRECIPITATES THIS ISSUE. I BELIEVE EITHER THE ENGINE OR TRANSMISSION PROGRAMMING NEEDS TO BE MODIFIED TO ADDRESS THIS ISSUE AS SOON AS POSSIBLE. *TR
NHTSA ODI #10689798
40,000 miles · Dec 7, 2014
EnginePower TrainService Brakes
HELLO, I OWN A 2011 SIENNA LE V6. IN COLD WEATHER, IT HAS A PROBLEM WHEN BRAKING WHERE THE VEHICLE LURCHES FORWARD AS IT COMES TO A STOP. THE DEALER DROVE THE CAR AND NOTED NO ISSUES. HOWEVER, AS YOU CAN SEE ON THIS INTERNET THREAD, MANY OTHER OWNERS HAVE THE SAME ISSUE. HTTP://WWW.SIENNACHAT.COM/FORUM/193-PROBLEMS-MAINTENANC…
Read full complaint
HELLO, I OWN A 2011 SIENNA LE V6. IN COLD WEATHER, IT HAS A PROBLEM WHEN BRAKING WHERE THE VEHICLE LURCHES FORWARD AS IT COMES TO A STOP. THE DEALER DROVE THE CAR AND NOTED NO ISSUES. HOWEVER, AS YOU CAN SEE ON THIS INTERNET THREAD, MANY OTHER OWNERS HAVE THE SAME ISSUE. HTTP://WWW.SIENNACHAT.COM/FORUM/193-PROBLEMS-MAINTENANCE-REPAIR/158410-ENGINE-REVVING-UP-JUST-BEFORE-STOP.HTML THIS ISSUE IS NOT JUST ANNOYING, I BELIEVE IT IS A SAFETY ISSUE, PARTICULARLY ON SLIPPERY SURFACES SUCH AS SNOW AND ICE WHICH ARE LIKELY TO OCCUR IN THE COLDER WEATHER THAT PRECIPITATES THIS ISSUE. I BELIEVE EITHER THE ENGINE OR TRANSMISSION PROGRAMMING NEEDS TO BE MODIFIED TO ADDRESS THIS ISSUE AS SOON AS POSSIBLE. THIS OCCURS WHEN THE ENGINE IS AT HIGH SPEED IDLE AFTER A COLD STOP, WHICH CAN LAST FOR MANY MILES AFTER YOU START DRIVING. *TR
NHTSA ODI #10662639
58,527 miles · Aug 23, 2014
Electrical SystemPower TrainService Brakes
I WAS PARKING THE CAR AND NEEDED TO MOVE THE VEHICLE BACKWARD IN A PARKING LOT WITH A SLIGHT SLOPE. WHEN I ATTEMPTED TO MOVE THE SHIFT LEVER TO REVERSE THE LEVER LOCKED UP AND THE VEHICLE STARTED TO ROLL BACKWARD. I APPLIED THE BRAKES TO NO AVAIL AND THE ENGINE DIED. THE STEERING WAS LOCKED. THE IGNITION SWITCH ALSO LOCKED. …
Read full complaint
I WAS PARKING THE CAR AND NEEDED TO MOVE THE VEHICLE BACKWARD IN A PARKING LOT WITH A SLIGHT SLOPE. WHEN I ATTEMPTED TO MOVE THE SHIFT LEVER TO REVERSE THE LEVER LOCKED UP AND THE VEHICLE STARTED TO ROLL BACKWARD. I APPLIED THE BRAKES TO NO AVAIL AND THE ENGINE DIED. THE STEERING WAS LOCKED. THE IGNITION SWITCH ALSO LOCKED. THE VEHICLE STOPPED . I CALLED THE TOYOTA DEALER AND THE SERVICE MANAGER SAID TO APPLY THE BRAKES VIGOROUSLY, AT THE SAME TIME PUMP THE ACCELERATOR AND TURN THE IGNITION. I DID AND THE FUNCTIONS ALL STARTED WORKING. NO DAMAGE, NO INJURIES. THIS OCCURRED IN FREDERICKS BURG, TX THIS APPEARS TO BE THE SAME INCIDENT IN COMPLAINT # 10585286, DATED 3-17-2014. *TR
NHTSA ODI #10627701
16,000 miles · Jun 6, 2012
Power Train
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND DECELERATED TO 25 MPH BEFORE STALLING WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE VEHICLE WOULD ACCELERATE OVER 5 MPH. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS TEST DRIVEN. THE DEALER WA…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND DECELERATED TO 25 MPH BEFORE STALLING WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE VEHICLE WOULD ACCELERATE OVER 5 MPH. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS TEST DRIVEN. THE DEALER WAS ABLE TO RECREATE THE FAILURE BUT THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 16,000.
NHTSA ODI #10460806
14,000 miles · May 12, 2012
Power Train
VEHICLE WOULD EXPECTEDLY SLOW DOWN WHEN YOU ACCELERATE. THE LOSS OF POWER WOULD LAST BETWEEN 2 TO 7 SECONDS. I HAVE ALREADY TAKEN THE CAR TO THE DEALER SINCE THE 15K-MILE SERVICE. THE DEALER COULD NOT FIND ANYTHING. NONETHELESS, THE ISSUE IS STILL OCCURRING ON A WEEKLY BASIS. THIS IS A VERY SERIOUS HAZARD. AFFECTED VEHICLE C…
Read full complaint
VEHICLE WOULD EXPECTEDLY SLOW DOWN WHEN YOU ACCELERATE. THE LOSS OF POWER WOULD LAST BETWEEN 2 TO 7 SECONDS. I HAVE ALREADY TAKEN THE CAR TO THE DEALER SINCE THE 15K-MILE SERVICE. THE DEALER COULD NOT FIND ANYTHING. NONETHELESS, THE ISSUE IS STILL OCCURRING ON A WEEKLY BASIS. THIS IS A VERY SERIOUS HAZARD. AFFECTED VEHICLE COULD GET REAR ENDED AS IT ACCELERATE FROM STOP LIGHTS WHEN IT SUDDENLY SLOWS DOWN. WHAT'S WORSE? IMAGINE YOUR FAMILY IN THE CAR WHEN YOU WANT TO MAKE A LEFT TURN, YOU PRESS THE GAS PEDAL TO ACCELERATE, BUT IT SLOWS DOWN BEFORE YOU CAN CLEAR THE ON COMING TRAFFIC. I HOPE TOYOTA IS LISTENING TO THIS!!! THIS DEFECT COULD HAVE VERY DIRE RESULTS. I HAVE FOUND SIMILAR COMPLAINTS IN VARIOUS FORUMS ONLINE. I AM CERTAIN MORE PEOPLE ARE EXPERIENCING THIS AND DON'T KNOW WHERE TO REPORT IT. NHTSA, PLEASE REQUEST SIMILAR COMPLAIN DATA FROM TOYOTA DEALERS ABOUT THIS VERY DANGEROUS DEFECT. *TR
NHTSA ODI #10458177
300 miles · May 27, 2011
Power TrainCrash
THE CAR ACCELERATES VERY RAPIDLY IN REVERSE AFTER A COLD START. A MORNING A FEW DAYS AFTER BUYING THE CAR, I STARTED IT UP, SHIFTED INTO REVERSE, AND SLOWLY RELEASED THE BRAKE PEDAL. THE CAR BEGAN ACCELERATE BACKWARDS SO RAPIDLY THAT I THOUGHT I MUST INADVERTENTLY PUT MY FOOT ON THE ACCELERATOR. I PULLED MY FOOT AWAY FROM THE …
Read full complaint
THE CAR ACCELERATES VERY RAPIDLY IN REVERSE AFTER A COLD START. A MORNING A FEW DAYS AFTER BUYING THE CAR, I STARTED IT UP, SHIFTED INTO REVERSE, AND SLOWLY RELEASED THE BRAKE PEDAL. THE CAR BEGAN ACCELERATE BACKWARDS SO RAPIDLY THAT I THOUGHT I MUST INADVERTENTLY PUT MY FOOT ON THE ACCELERATOR. I PULLED MY FOOT AWAY FROM THE PEDALS BUT THE CAR CONTINUED TO ACCELERATE. I SHIFTED INTO PARK, BUT BEFORE THERE WAS ANY CHANGE IN SPEED THE CAR CRASHED INTO MY NEIGHBOR'S CAR ACROSS THE STREET, CAUSING OVER $5,000 IN DAMAGE. IF THERE HAD BEEN SOMEONE STANDING ACROSS THE STREET, IT WOULD LIKELY HAVE BEEN A FATALITY. I CONTACTED TOYOTA AND THEY SENT OUT A CORPORATE REPRESENTATIVE TO EXAMINE THE CAR. HE ACKNOWLEDGED THERE WAS RAPID ACCELERATION IN REVERSE, AND STATED THAT WAS "NORMAL" OPERATION FOR THE CAR AFTER A COLD START, AND THAT IT WOULD BE EVEN FASTER IN COLD WEATHER (WE LIVE IN SOUTHERN CALIFORNIA). HE STATED THEY HAD INCREASED THE CAR IDLE SPEED AFTER COLD STARTS FOR POLLUTION CONTROL PURPOSES, AND THIS WAS THE RESULT. I CAREFULLY REVIEWED THE OWNER'S MANUAL AND INSIDE OF THE CABIN FOR ANY WARNING ABOUT RAPID ACCELERATION IN REVERSE AFTER A COLD START, AND THERE WAS NONE. I HAVE ALWAYS BEEN A CAREFUL DRIVER WHO HAS MAINTAINED A GOOD DRIVER DISCOUNT, AND NOTHING REMOTELY LIKE THIS HAS EVER HAPPENED TO ME BEFORE. AT THE VERY LEAST, BECAUSE THE COMPANY IS AWARE OF THIS ISSUE THEY SHOULD PROMINENTLY PROVIDE WARNINGS TO NEW CAR BUYERS AND OWNERS. I AM CONCERNED THAT THIS IS A DESIGN DEFECT WILL RESULT IN INJURY AND DEATH IF NOT ADDRESSED PROMPTLY. *TR
NHTSA ODI #10402983
300 miles · Jan 6, 2011
Power Train
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED THAT THE VEHICLE WOULD SWITCH TO THIRD GEAR WITHOUT WARNING INTERMITTENTLY, MAKE A LOUD NOISE, AND THREE ALERTS WOULD ILLUMINATE ON THE INSTRUMENT PANEL; THESE LIGHTS WERE A SKIDDING SIGNAL, EXCLAMATION MARK, AND A SIGNAL THAT ADVISES THE …
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED THAT THE VEHICLE WOULD SWITCH TO THIRD GEAR WITHOUT WARNING INTERMITTENTLY, MAKE A LOUD NOISE, AND THREE ALERTS WOULD ILLUMINATE ON THE INSTRUMENT PANEL; THESE LIGHTS WERE A SKIDDING SIGNAL, EXCLAMATION MARK, AND A SIGNAL THAT ADVISES THE CONTACT TO NOTIFY THE DEALER. WHEN ATTEMPTING TO DRIVE BEYOND 55 MPH, THE RPM METER MOVED TO THE RED ZONE AND MADE A LOUD NOISE. THE DEALER MADE TWO ATTEMPTS TO DIAGNOSE THE FAILURE. THE CONTACT WAS UNABLE TO SAY WHAT THE DEALER DID WHEN THE VEHICLE WAS TAKEN IN; HOWEVER THE PROBLEM OCCURRED THE NEXT DAY AFTER THE VEHICLE WAS RETURNED TO THE CONTACT FROM THE DEALER. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 2,400. THE FAILURE MILEAGE WAS APPROXIMATELY 300.
NHTSA ODI #10375015
Official recalls
14Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence & remedy
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Consequence & remedy
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence & remedy
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration