NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
8 reportsClear category filterMileage unknown · Oct 23, 2025
Fuel/propulsion SystemPower TrainService Brakes
Catalizador caUsando bajas emisiones, consecuencia encendido de codigos de luz de advertencia de tablero como luz indicadora de falla (Check Engine). LUZ DE ADVERTENCIA ABS. LUZ INDICADORA DE DERRAPE VSC-TRAC Y LUZ DE ADVERTENCIA DE PRESION DE NEUMATICOS. AL VIAJAR POR CARRETERA SIMPLEMENTE SE APAGO Y SIN PODER TENER CONTROL DE…
Read full complaint
Catalizador caUsando bajas emisiones, consecuencia encendido de codigos de luz de advertencia de tablero como luz indicadora de falla (Check Engine). LUZ DE ADVERTENCIA ABS. LUZ INDICADORA DE DERRAPE VSC-TRAC Y LUZ DE ADVERTENCIA DE PRESION DE NEUMATICOS. AL VIAJAR POR CARRETERA SIMPLEMENTE SE APAGO Y SIN PODER TENER CONTROL DE LA MISMA DICHA FALLA CAUSO QUE YA NO ENCENDIERA AL TENER QUE SOLICITAR GRUA PARA EL ARRARSTRE DE LA UNIDAD HASTA LA AGENCIA DE TOYOTA EN CORDOBA VERACRUZ. SEGURO SOLO INTERVINO CON EL ARRASTRE DE LA UNIDAD. PERO LA SIENNA A LLEVADO HASTA EL DIA DE HOY Y FECHA PRESENTE TODOS LOS SERVICIOS DE AGENCIA POR LA CUAL SE LLEVO DE INMEDIATO, PERO CON LA NOVEDAD ES QUE NI LA MISMA AGENCIA LE A PODIDO QUITAR LA FALLA. NO TIENEN NI LA MENOR IDEA DE LA CAUSA. SU SOLUCION SEGUEN ELLOS ERAN LOS INYECTORES PERO LA CAMIONETA VOLIVIO A HACER LA MISMA FALLA Y LA AGENCIA NO DA GARANTIA DE SU MANO DE OBRA. SOLO AUMENTA EL GASTO EN REFACCIONES SIN SOLUCIONAR LA FALLA.
NHTSA ODI #11695158
Mileage unknown · Feb 2, 2022
Fuel/propulsion SystemUnknown Or Other
The VSC and tract light stay on all the time. The Ford dealer I purchased the Van from said they had it fixed. I took it back and i was told to buy a new gas cap which I did from a Toyota dealer in my area. The light came on again. I took it back and was told it had an exhaust leak and it won't hurt the van. But I could bring it…
Read full complaint
The VSC and tract light stay on all the time. The Ford dealer I purchased the Van from said they had it fixed. I took it back and i was told to buy a new gas cap which I did from a Toyota dealer in my area. The light came on again. I took it back and was told it had an exhaust leak and it won't hurt the van. But I could bring it back for starting at $ 200.00 and have a leak test done on the Van, but it would take hours. Since then I've had cleaner run thru the system but the lights stay on all the time. Is this a safety hazard because its an exhaust leak? Can you please assist in the repair information before I spend hundreds of dollars chasing the problem. Thank You so much..... [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11450041
Mileage unknown · Jan 26, 2022
Fuel/propulsion SystemStructureUnknown Or Other
Safety issue: can't open gas door, can't open sliding door Gas door cover on the driver's side will not completely latch (faulty hinge issue? ) which prevents the sliding door from opening. Sliding door has issues in moving back and forth. Apparently there was a recall for this issue and I was never notified. When I researched t…
Read full complaint
Safety issue: can't open gas door, can't open sliding door Gas door cover on the driver's side will not completely latch (faulty hinge issue? ) which prevents the sliding door from opening. Sliding door has issues in moving back and forth. Apparently there was a recall for this issue and I was never notified. When I researched the issue, I found that there was a recall but because my recall is just out of the 10 year time frame, Toyota states they won't pay for the repair of the faulty mechanism and that I have to pay for it out of pocket. Considering there has been a pandemic for the since March 2020, it's hard to believe that they wouldn't honor the repair when I called about it in December. I made a phone complaint to Toyota at the end of December 2021 and no one has returned my call.
NHTSA ODI #11449037
110,000 miles · Dec 26, 2020
EngineFuel/propulsion SystemPower Train
I WAS DRIVING FROM TORONTO TO VIRGINIA ON 23 DEC 2020 AND REFILLED GAS IN SPRINGFIELD NY WALMART GAS STATION TO REFILL THE GAS. WHEN I ENTERED BEDFORD PA TURNPIKE, THE CAR SOUNDED WITH DIFFERENT SOUNDS FROM ENGINE ON THE RAMP WHEN ENTERING THE 70/76 FREEWAY. WHEN ENTERED TO VIRGINIA FROM MARYLAND BORDER AFTER POTOMAC RIVER CROS…
Read full complaint
I WAS DRIVING FROM TORONTO TO VIRGINIA ON 23 DEC 2020 AND REFILLED GAS IN SPRINGFIELD NY WALMART GAS STATION TO REFILL THE GAS. WHEN I ENTERED BEDFORD PA TURNPIKE, THE CAR SOUNDED WITH DIFFERENT SOUNDS FROM ENGINE ON THE RAMP WHEN ENTERING THE 70/76 FREEWAY. WHEN ENTERED TO VIRGINIA FROM MARYLAND BORDER AFTER POTOMAC RIVER CROSSING ON HIGHWAY 15 , THE CAR SUDDENLY STOPPED WHILE DRIVING AT 30 MPH AND PULLED THE CAR TO THE SIDE OF THE ROAD SLOWLY AND WHEN I RESTARTED THE CAR, IT STARTED NORMAL AND DROVE TILL CHANTILLY VIRGINIA WITHOUT ANY STOPPING. BUT THE ENGINE GAVE ME DIFFERENT NOISES.
NHTSA ODI #11384962
70,000 miles · Dec 17, 2016
Fuel/propulsion SystemUnknown Or Other
MY CAR IS REVVING UNCONTROLLABLY AND LURCHING FORWARD WHEN BRAKING. THE ENGINE DOES NOT DECREASE ITS REVOLUTIONS IN LONE WITH BRAKING. ITS EITHER A TRANSMISSION DROPPING TO A LOWER GEAR AND LURCHING FORWARD IR THE ACCELERATOR PEDAL US STICKING. IT HAPPENS ALL OF THE TIME AND IS UNSAFE COMING TO STOPS NEAR CROAS TRAFFIC.
NHTSA ODI #10935954
80,000 miles · Apr 7, 2016
Fuel/propulsion System
COMPLAINT: TOYOTA SIENNA 2011 SE ON 2/3/2016 I TOOK MY 2011 SIENNA TO THE LOCAL TOYOTA DEALERSHIP BECAUSE THE INFORMATION DISPLAY SCREEN INDICATED VSC SYSTEM WARNING AND THE ENGINE LIGHT, TRAC SYSTEM LIGHT, AND WARNING LIGHTS WERE ON. AFTER DIAGNOSTICS THE SERVICE ADVISOR EXPLAINED THAT FUEL EMISSION SWITCH VALVE WAS STUCK I…
Read full complaint
COMPLAINT: TOYOTA SIENNA 2011 SE ON 2/3/2016 I TOOK MY 2011 SIENNA TO THE LOCAL TOYOTA DEALERSHIP BECAUSE THE INFORMATION DISPLAY SCREEN INDICATED VSC SYSTEM WARNING AND THE ENGINE LIGHT, TRAC SYSTEM LIGHT, AND WARNING LIGHTS WERE ON. AFTER DIAGNOSTICS THE SERVICE ADVISOR EXPLAINED THAT FUEL EMISSION SWITCH VALVE WAS STUCK IN THE OFF POSITION. THE TECHNICIAN REPORT IDENTIFIED THE PART AS P2440 EVAPORATIVE EMISSION PRESSURE SWITCH VALVE. THE SWITCH REGULATES THE AMOUNT OF GASOLINE PUMPED INTO THE TANK THROUGH THE INTAKE AND OUTTAKE OF AIR. VACUUM HOSES CONNECT THE VALVE TO A 'CHARCOAL CANISTER' WHICH COLLECTS GAS FUMES FROM THE TANK AND ROUTES THEM TO THE ENGINE FOR COMBUSTION. UNFORTUNATELY, TOYOTA SELLS THESE VARIOUS COMPONENTS IN EMISSION SYSTEM AS ONE UNIT. THE PART WAS $537.92 AND $148.88 FOR LABOR. THE SUGGESTED CAUSE WAS OVERFILLING THE GAS TANK. WE HAVE NEVER HAD A PROBLEM FILLING UP TANKS (STOPPING BEFORE THE POINT OF OVERFLOW) WITH MANY PREVIOUSLY OWNED TOYOTA TRUCKS AND SEDANS. THE CORE OF MY GRIEVANCE IS THE FACT THAT THE OWNER'S MANUAL DOES NOT SPECIFICALLY CAUTION THE OWNER THAT THIS PRACTICE CAN DAMAGE OR CAUSE A MALFUNCTION OF THE EMISSION SYSTEM. THE MANUAL ONLY CAUTIONS THE PERSON PUMPING FUEL 'DO NOT SPILL FUEL DURING REFUELING.'(P.150 IN REFUELING SECTION). IF THIS WAS THE REAL CAUSE FOR THE NEEDED EMISSION PART REPLACEMENT I HOPE THAT TOYOTA WILL WRITE A CLEAR WARNING ABOUT THE CONSEQUENCES OF "FILLING UP" IN THEIR MANUAL OR CONSIDER REDESIGNING THE EMISSION SYSTEM. PERHAPS THIS COMPLAINT WILL PREVENT ANOTHER TOYOTA CUSTOMER THE COST AND DISSATISFACTION OF THIS SAME EXPERIENCE.
NHTSA ODI #10854153
90,000 miles · Feb 2, 2015
Fuel/propulsion System
THE WELD AT THE TOP OF THE HINGE ON THE FUEL FILLER DOOR HAS BROKEN, SO THE DOOR WILL NOT CLOSE. THIS PREVENTS OPENING THE SLIDING DOOR ON THE DRIVER'S SIDE. I HAVE CHILDREN AND WOULD NEED THE ABILITY TO EVACUATE PASSENGERS QUICKLY AND EASILY IN THE EVENT OF AN EMERGENCY. ONE OF MY PASSENGERS IS RESTRAINED IN A CAR SEAT THAT …
Read full complaint
THE WELD AT THE TOP OF THE HINGE ON THE FUEL FILLER DOOR HAS BROKEN, SO THE DOOR WILL NOT CLOSE. THIS PREVENTS OPENING THE SLIDING DOOR ON THE DRIVER'S SIDE. I HAVE CHILDREN AND WOULD NEED THE ABILITY TO EVACUATE PASSENGERS QUICKLY AND EASILY IN THE EVENT OF AN EMERGENCY. ONE OF MY PASSENGERS IS RESTRAINED IN A CAR SEAT THAT I NEED TO ACTIVATE IN ORDER TO REMOVE THE CHILD FROM THE CAR. THE DOOR CANNOT BE OPENED MORE THAN A FEW INCHES WITH THE BROKEN FUEL FILLER DOOR AS AN OBSTRUCTION, SO IT CREATES A MAJOR SAFETY ISSUE. *TR
NHTSA ODI #10680720
43,600 miles · Jul 8, 2014
Fuel/propulsion System
I STOPPED FOR GAS AND WAS UNABLE TO OPEN THE FUEL FILLER DOOR. BECAUSE OF THE FUEL FILLER DOOR FAILURE, I WAS NOT ABLE TO OPEN THE DRIVER SIDE PASSENGER DOOR. I DROVE THE VEHICLE HOME AND UPON FURTHER INVESTIGATION, I DISCOVERED THE TOP FUEL FILLER DOOR HINGE WAS BROKEN FREE. THE BROKEN HINGE ALLOWED THE PASSENGER DOOR ACTIVATIO…
Read full complaint
I STOPPED FOR GAS AND WAS UNABLE TO OPEN THE FUEL FILLER DOOR. BECAUSE OF THE FUEL FILLER DOOR FAILURE, I WAS NOT ABLE TO OPEN THE DRIVER SIDE PASSENGER DOOR. I DROVE THE VEHICLE HOME AND UPON FURTHER INVESTIGATION, I DISCOVERED THE TOP FUEL FILLER DOOR HINGE WAS BROKEN FREE. THE BROKEN HINGE ALLOWED THE PASSENGER DOOR ACTIVATION SWITCH LOCATED BEHIND THE FUEL FILLER DOOR TO POP OUT WHICH DE-ACTIVATED THE PASSENGER DOOR OPERATION. IN THE EVENT OF AN ACCIDENT, THE DRIVER SIDE PASSENGER DOOR WOULD NOT BE ABLE TO BE OPENED. *JS
NHTSA ODI #10608948
Official recalls
14Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence & remedy
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Consequence & remedy
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence & remedy
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration