NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
6 reportsClear category filter56,000 miles · Apr 19, 2014
Engine And Engine CoolingStructure
THE AIR CONDITIONER HOUSING IS LEAKING WATER ONTO SAFETY-CRITICAL PARTS. THIS HOUSING IS MADE OF PLASTIC PARTS THAT ARE GLUED TOGETHER. WATER IS CONDENSED DURING THE COOLING CYCLE, AND IT THEN COLLECTS AT THE BOTTOM AND EXITS THE VEHICLE THROUGH A RUBBER HOSE. THE GLUE HOLDING THE HOUSING TOGETHER HAS FAILED. WATER IS LE…
Read full complaint
THE AIR CONDITIONER HOUSING IS LEAKING WATER ONTO SAFETY-CRITICAL PARTS. THIS HOUSING IS MADE OF PLASTIC PARTS THAT ARE GLUED TOGETHER. WATER IS CONDENSED DURING THE COOLING CYCLE, AND IT THEN COLLECTS AT THE BOTTOM AND EXITS THE VEHICLE THROUGH A RUBBER HOSE. THE GLUE HOLDING THE HOUSING TOGETHER HAS FAILED. WATER IS LEAKING FROM THE HOUSING AND RUNNING ONTO THE COMPUTER MODULE THAT DEPLOYS THE AIRBAGS. I HAVE BEEN ADVISED BY THE DEALER THAT IT IS NOT SAFE TO DRIVE THE VEHICLE WITH A WET MODULE BECAUSE THE AIRBAGS CAN DEPLOY WHILE MOVING, OR THAT THEY MIGHT NOT DEPLOY IN THE EVENT OF A COLLISION. AN IDENTICAL PROBLEM AFFECTS TOYOTA MODELS CAMRY, AVALON, AND VENZA. THIS RECALL CAN BE FOUND AT: WWW.TOYOTANEWS.PRESSROOM.TOYOTA.COM THE RECALL INFO IS: RELEASES/TOYOTA/RECALL+CAMRY+AVALON+VENZAOCT17 THIS WILL TURN INTO A SERIOUS SAFETY ISSUE AS THESE VEHICLES GET OLDER WATER CAN LEAK ONTO THE DEPLOYMENT MODULE WITHOUT BEING SEEN. IN MY PARTICULAR CASE, THE WATER HAD APPARENTLY BEEN LEAKING FOR SOME TIME - PERHAPS A YEAR OR TWO - AND WAS DETECTED PURELY BY CHANCE. THERE WAS SIGNIFICANT RUST ON THE FLOORBOARD OF THE VEHICLE. I HAVE DISCUSSED THE ISSUE WITH TOYOTA, AND THEY REFUSE TO DO ANYTHING ABOUT IT. THE CIRCUMSTANCES OF THE RECALL ON CAMRY, AVALON, AND VENZA APPEAR TO BE IDENTICAL TO THE CIRCUMSTANCES I HAVE EXPERIENCED, YET THERE IS NO RECALL ON THE SIENNA. THIS APPEARS TO BE AN UNSAFE CONDITION. I WOULD APPRECIATE IT IF YOU WILL TAKE A LOOK. *TR
NHTSA ODI #10583658
6,100 miles · Jun 4, 2012
Engine And Engine CoolingFire
THE VEHICLE CAUGHT ON FIRE AFTER DRIVEN FOR APPROXIMATELY 5 MILES AND PARKED FOR SEVERAL MINUTES. IT ONLY HAD ABOUT 6,100 MILES AND PURCHASED NEW 9 MONTHS AGO. THE FIRE CAUSED TOTAL LOSS TO THE VEHICLE AND EVERYTHING INSIDE INCLUDING THE CHILD SEATS AND STROLLER WAS PERMANENTLY DAMAGED BY HEAT AND SMOKE. ACCORDING TO THE INCID…
Read full complaint
THE VEHICLE CAUGHT ON FIRE AFTER DRIVEN FOR APPROXIMATELY 5 MILES AND PARKED FOR SEVERAL MINUTES. IT ONLY HAD ABOUT 6,100 MILES AND PURCHASED NEW 9 MONTHS AGO. THE FIRE CAUSED TOTAL LOSS TO THE VEHICLE AND EVERYTHING INSIDE INCLUDING THE CHILD SEATS AND STROLLER WAS PERMANENTLY DAMAGED BY HEAT AND SMOKE. ACCORDING TO THE INCIDENT REPORT FROM FIRE DEPARTMENT, IT APPEARS THAT THE FIRE IGNITED AT THE UPPER LEFT CORNER (PASSENGER SIDE) OF THE ENGINE BAY. NO EVIDENCE OR INDICATION OF INCENDIARY FIRE WAS FOUND. *TR
NHTSA ODI #10460526
24,000 miles · Jan 16, 2012
Electrical SystemEngine And Engine CoolingExterior Lighting
THE VEHICLE ENGINE STALLS. THIS OCCURS INTERMITTENTLY ESPECIALLY WHEN MAKING TURNS. I HAD TO PRESS THE GAS PEDAL ALL THE WAY DOWN TO ACCELERATE. THE VEHICLE BRAKE LIGHTS DO NOT COME OFF FOR ABOUT 10 MINUTES WHEN THE ENGINE AND LIGHTS HAVE BEEN SWITCHED OFF. IT IS POSSIBLE TO START THE CAR WITH THE PUSH BUTTON WITHOUT PRESSING DO…
Read full complaint
THE VEHICLE ENGINE STALLS. THIS OCCURS INTERMITTENTLY ESPECIALLY WHEN MAKING TURNS. I HAD TO PRESS THE GAS PEDAL ALL THE WAY DOWN TO ACCELERATE. THE VEHICLE BRAKE LIGHTS DO NOT COME OFF FOR ABOUT 10 MINUTES WHEN THE ENGINE AND LIGHTS HAVE BEEN SWITCHED OFF. IT IS POSSIBLE TO START THE CAR WITH THE PUSH BUTTON WITHOUT PRESSING DOWN ON THE GAS PEDAL SOMETIMES. *TR
NHTSA ODI #10443902
7,500 miles · Jan 12, 2011
Engine And Engine CoolingExterior Lighting
5 MONTH OLD TOYOTA SIENNA 2011 STALLED AFTER THE LIGHTS INSIDE THE DASHBOARD (CONTROL PANEL) STARTED BLINKING AND THEN WOULD NOT START AGAIN. IT WAS TOWED TO THE DEALER ON 12/22/2010. DEALER INITIALLY (ON 12/27/2010) SAID IT IS DUE TO WATER DAMAGE AND ENGINE HAS TO BE REPLACED. DEALER WAS NOT ABLE TO FIND ANY EVIDENCE OF SIENN…
Read full complaint
5 MONTH OLD TOYOTA SIENNA 2011 STALLED AFTER THE LIGHTS INSIDE THE DASHBOARD (CONTROL PANEL) STARTED BLINKING AND THEN WOULD NOT START AGAIN. IT WAS TOWED TO THE DEALER ON 12/22/2010. DEALER INITIALLY (ON 12/27/2010) SAID IT IS DUE TO WATER DAMAGE AND ENGINE HAS TO BE REPLACED. DEALER WAS NOT ABLE TO FIND ANY EVIDENCE OF SIENNA BEING SUBMERGED IN WATER (AS IT DID NOT GO INTO ANY BIG PUDDLE OR DEEP WATERS). I OPENED A CASE WITH TOYOTA ON 12/28/2010. I WAS IN TOUCH WITH TOYOTA DEALER BUT CASE MANAGER AT TOYOTA INFORMED THAT THEY WERE UNABLE TO REACH/SPEAK TO THE DEALER FOR 2 DAYS EVEN THOUGH THEY ARE BOTH IN CALIFORNIA. SHE INFORMED ME THAT THEIR POLICY IS TO CONCUR WITH DEALER WITHOUT EVEN LOOKING AT THE REPORT OR TALKING TO THEM AND THEY WOULD NEITHER INVESTIGATE NOR INSPECT. MY INSURANCE COMPANY (AAA) PERFORMED VISUAL INSPECTION AND FOUND TOO MANY METAL PIECES INSIDE THE ENGINE. INSURANCE COMPANY ALSO FOLLOWED UP WITH DEALER AND INFORMED THERE ARE OTHER CASES WHERE THEY HAD SEEN SIMILAR ISSUE WITH TOYOTA SIENNA 2011 AND THIS DOES NOT SEEM TO BE A WATER DAMAGE. THERE HAS BEEN NEITHER AN EXPLANATION NOR A FOLLOW-UP FROM TOYOTA AS TO WHAT THE CAUSE WAS. DEALER REPORTED BACK ON 01/04/2011 AND INFORMED ME THAT IT MIGHT BE A MECHANICAL FAILURE AND TOYOTA WILL FIX IT. I AM NOW CONCERNED ABOUT THE SAFETY OF MY FAMILY AND ANYONE WHO DRIVES SIENNA. WHAT IF STALLS IN THE MIDDLE OF FREEWAY ? WHAT IF THIS HAPPENS AGAIN ? WORRIED AND TENSED OWNER OF TOYOTA SIENNA 2011.
NHTSA ODI #10377303
510 miles · Dec 28, 2010
Electrical SystemEngine And Engine Cooling
VAN JUST WON'T START. IT CRANKS OVER BUT WON'T START, AFTER TENS MINUTES IT STARTED UP FINE. VAN HAS ONLY 510 MILES. AT 5500 MILES VEHICLE AGAIN CRANKED BUT WOULD NOT START. AFTER IT STARTED, IT RAN ROUGH AND DIED AT TIMES, TOOK IT TO DEALER BUT THEY CAN NOT FIND PROBLEMS. VEHICLE RUNS FINE, AT ABOUT 5700 VEHICLE RUNS ROUGH AND…
Read full complaint
VAN JUST WON'T START. IT CRANKS OVER BUT WON'T START, AFTER TENS MINUTES IT STARTED UP FINE. VAN HAS ONLY 510 MILES. AT 5500 MILES VEHICLE AGAIN CRANKED BUT WOULD NOT START. AFTER IT STARTED, IT RAN ROUGH AND DIED AT TIMES, TOOK IT TO DEALER BUT THEY CAN NOT FIND PROBLEMS. VEHICLE RUNS FINE, AT ABOUT 5700 VEHICLE RUNS ROUGH AND DIES AT STOP LIGHTS, TOOK BACK TO DEALER THIS TIME THEY SAY IT WAS A BAD COMPUTER, TOYOTA TOOK CARE OF IT, A FEW THOUSANDS MILES LATER SAME PROBLEMS RUN ROUGH AT TIMES AND WON'T START, TOOK TO DEALER, CAN NOT FINE PROBLEMS, VEHICLE RAN FINE, NOW AT 10500 MILES SAME PROBLEMS AGAIN RAN ROUGH AND DIE AT STOP LIGHT, BUT RAN FINE JUST A FEW MINUTES LATER, DROVE HOME NEXT DAY ,IT WON'T START. TOW TO DEALER THEY SAY IT HAS SOME MOISTURE IN THE COMPUTER.
NHTSA ODI #10373123
225 miles · Jun 26, 2010
Engine And Engine CoolingFire
2011 TOYOTA SIENNA VAN WITH 220 MILES ON IT CAUGHT FIRE IN MY DRIVEWAY 2 MINUTES AFTER PARKING IT THERE. NO WARNING LIGHTS OR ANYTHING. VEHICLE IS A TOTAL LOSS, NO RESPONSE FROM TOYOTA FOR OVER TWO WEEKS, OWNED THE BRAND NEW VAN FOR LESS THAN A WEEK. A CAUSE AND EFFECT INVESTIGATOR HIRED BY MY INS CO FOUND THE PROBLEM TO BE …
Read full complaint
2011 TOYOTA SIENNA VAN WITH 220 MILES ON IT CAUGHT FIRE IN MY DRIVEWAY 2 MINUTES AFTER PARKING IT THERE. NO WARNING LIGHTS OR ANYTHING. VEHICLE IS A TOTAL LOSS, NO RESPONSE FROM TOYOTA FOR OVER TWO WEEKS, OWNED THE BRAND NEW VAN FOR LESS THAN A WEEK. A CAUSE AND EFFECT INVESTIGATOR HIRED BY MY INS CO FOUND THE PROBLEM TO BE A FAULTY FAN WIRE THAT SHORTED OUT. EXTENSIVE DAMAGE TO MY HOUSE AND LANDSCAPING AS WELL. BURNED OUT VAN STILL SITTING IN MY DRIVEWAY CAUSING DANGER WITH BROKEN GLASS AND SOOT TO MY CHILDREN AND PETS. UNABLE TO GET ANY RESPONSE WHAT SO EVER FROM TOYOTA. THE DEALERSHIP HAS BEEN EXTREMELY HELPFUL. *TR
NHTSA ODI #10340222
Official recalls
14Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence & remedy
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Consequence & remedy
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence & remedy
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration