2025 Toyota Sienna Hybrid

The contact owns a 2025 Toyota Sienna Hybrid equipped with Firestone Tires, Tire Line: FT 140, Tire Size: 235/65/R17, DOT Number: 1WT87FT01. The contact stated that there was a screw in the tire. The contact stated that while driving 70 MPH there was a sound of an object in the tire. The message that the air pressure was low was immediately displayed. The tire pressure indicated 25 PSI. The driver was able to take the off-ramp but was unable to locate the spare tire. A good Samaritan attempted to assist. The driver was able to locate the Fix-A-Flat and a compressor, but the tire failed to hold air. The contact stated that the hole in passenger’s side rear tire was too big to be sealed. The contact was unaware that the vehicle did not have a spare tire. The contact was on the side of the road for two hours. The tire was changed and plugged by her husband after two hours of being stranded. The contact had enough fuel to run the air conditioner. The tires were previously rotated. The contact stated that the situation could have been worse, and not having a spare tire puts the drivers in a dangerous situation. The failure mileage was approximately 11,474.

While driving my 2025 Toyota Sienna XLE with Sure Grip Push‑Rock electronic hand controls, the acceleration suddenly stops working without warning. When this happens, the hand control will not accelerate at all — only the brake still works — leaving me coasting in traffic with no way to speed up. This has happened multiple times at different speeds and creates an immediate danger because I can only slow down or stop, not accelerate out of the situation. At the same time these acceleration failures occur, the vehicle shows a “SRS Airbag System Malfunction” warning. Toyota’s internal records show the airbag system had faults before I bought the vehicle. The airbag warning and the acceleration failure often appear together, which makes me believe there is an electrical or wiring problem affecting multiple systems. I also discovered that Toyota documented underbody impact damage from a pothole months before I purchased the vehicle. This damage was not disclosed to me, and CARFAX does not show any record of this damage, even though Toyota’s own service history confirms it. The CARFAX report I received states “No accidents or damage reported to CARFAX”. I have owned multiple BraunAbility‑converted vehicles, and all of them have had electrical issues. BraunAbility cuts out the bottom of the vehicle for the lowered‑floor conversion and splices in their own wiring harness, which I believe is causing repeated electrical problems across different vehicles, including this one. Because the acceleration fails, the airbag system shows active faults, and the wiring appears to interfere with the vehicle’s safety systems, I am reporting this as a serious safety hazard.

The contact owns a 2025 Toyota Sienna Hybrid. The contact received notification of NHTSA Campaign Number: 25V668000 (Seats); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the recall repairs were denied due to the 2nd row seats being converted for wheelchair accessibility. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2025 Toyota Sienna Hybrid. The contact stated that while attempting to carry seven people inside the vehicle, the contact was unable to carry all the passengers because the middle row seats were improperly welded. The contact received notification of NHTSA Campaign Number: 25V668000 (Seats); however, the part to do the recall repair was not yet available. The contact associated the failure with the recall. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,600.

The contact owns a 2025 Toyota Sienna Hybrid. The contact received notification of NHTSA Campaign Number: 25V668000 (Seats); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

We purchased a used 2025 Toyota Sienna a few weeks ago. The other day, my husband put his phone and wallet into the center console compartment and closed the lid. When we went to retrieve those items, the lid only opened partially. We were finally able to remove the wallet but the phone had slid down into the compartment where the door to that console opening slides into when you open and close it. The lid would not open all of the way and blocked our access to that space when you opened it. The only way to remove the phone was to take it to our local dealership where they spent hours removing seats and pieces of the console to remove the phone from the inaccessible area and then put everything back together. This cost us roughly four hours of work time and $311.99 out of our own pocket. Apparently this is a known issue with this vehicle and is a design flaw where items of the right size (including iPhones) can slide into that compartment while the lid is closed and then are inaccessible.