Fuel/propulsion System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports0 fire reports2 injury reports

Fuel System, Gasoline complaints

3 reports

Clear category filter

100 miles · May 4, 2023

Fuel System, Gasoline

The contact owns a 2019 Toyota Rav4. The contact stated that while attempting to refuel the vehicle, the pump handle would click off inadvertently, preventing the refueling the vehicle. The contact took the vehicle to the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer…

Read full complaint

NHTSA ODI #11520465

Mileage unknown · Mar 21, 2023

Fuel System, Gasoline

Read full complaint

The contact owns a 2019 Toyota Rav4 Hybrid. The contact stated that upon approaching the vehicle, there was fuel leaking onto the floor under the fuel filler neck. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the fuel tank and fuel sending unit needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was then taken to Toyota Chula Vista (650 Main St, Chula Vista, CA 91911), South Coast Toyota (1966 Harbor Blvd, Costa Mesa, CA 92627) and Culver City Toyota (9077 Washington Blvd, Culver City, CA 90232), where the mechanics diagnosed and determined that the failure could not be duplicated. The vehicle was not repaired. The manufacturer was made aware of the failure, and the contact sought legal advice. The failure mileage was unknown.

NHTSA ODI #11513091

4,400 miles · Apr 14, 2020

Fuel System, Gasoline

Read full complaint

VEHICLE'S FUEL TANK IS LISTED BY TOYOTA COMPANY AS 14.5 GALLON CAPACITY AND, IN REALITY, THIS TANK'S SHAPE ONLY ALLOWS IT TO FILL TO APPROXIMATELY 9 GALLONS. ADDITIONALLY, THE FUEL GAUGES "MILES TO EMPTY" DOES NOT APPEAR TO READ THE AMOUNT CORRECTLY. I HAVE ALMOST RUN OUT OF FUEL ON THE HIGHWAY AS A RESULT OF THE VEHICLE'S IMPROPER READING. THE ACTUAL GAS IN THE TANK WAS MUCH LOWER THAN THE VEHICLE ITSELF TOLD ME. THE RANGE IS ADVERTISED BY THE MANUFACTURER AT APPROXIMATELY 500 MILES WHEN IN REALITY IT APPEARS TO BE UNDER 300 MILES DEPENDING ON DRIVING CONDITIONS. THIS HAS PLACED ME AND MY FAMILY IN A DANGEROUS SITUATION AS WE CANNOT ACCURATELY ESTIMATE HOW MUCH FUEL IS IN THE VEHICLE BEFORE IT IS COMPLETELY EMPTY. I HAVE SEEN THIS PROBLEM IS ACTUALLY WIDESPREAD AND OTHER OWNERS ACROSS THE COUNTRY ARE ALSO DEALING WITH THE ISSUE. TOYOTA IS ALSO STILL SELLING THE VEHICLE'S 2020 MODEL WHICH APPARENTLY HAS THE SAME PROBLEM, AND IS NOT WARNING POTENTIAL BUYERS OF THE DANGEROUS DEFECT. *TR

NHTSA ODI #11321108

Official recalls

20V286000 · Suspension:front:control Arm:lower Arm

May 20, 2020

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.

Consequence & remedy

Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.

20V064000 · Engine And Engine Cooling

Feb 6, 2020

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.

Consequence & remedy

Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.

19V544000 · Electronic Stability Control (esc); Service Brakes

Jul 24, 2019

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Lexus LS500, LC500, ES300h, UX250h, LS500h, Toyota Prius, RAV4 HV, 2019-2020 Toyota Prius Prime, and 2020 Corolla HV vehicles. The brake booster pump may fail causing a deactivation of the Vehicle Stability Control system and a loss of braking assist. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."

Consequence & remedy

Consequence: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect and, if necessary, replace the brake booster pump, free of charge. The recall began September 20, 2019. Toyota owners may contact Toyota customer service at 1-888-270-9371 and Lexus owners may contact Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are K1L/K0L. Lexus' numbers for this recall are K2F/KLF.

Additional source detail variants (2)

Service Brakes

Consequence: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect and, if necessary, replace the brake booster pump, free of charge. The recall began September 20, 2019. Toyota owners may contact Toyota customer service at 1-888-270-9371 and Lexus owners may contact Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are K1L/K0L. Lexus' numbers for this recall are K2F/KLF.

Electronic Stability Control (esc)

Consequence: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.