The contact owns a 2015 Toyota Prius. The contact stated that while driving at 45 MPH, the brake warning lights illuminated. The brakes were inoperable and entered manual mode. The contact stated that the brake warning lights were red and yellow. The vehicle was taken to Brake Masters, where it was diagnosed with brake actuator …
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated that while driving at 45 MPH, the brake warning lights illuminated. The brakes were inoperable and entered manual mode. The contact stated that the brake warning lights were red and yellow. The vehicle was taken to Brake Masters, where it was diagnosed with brake actuator failure. The local dealer was contacted but did not provide assistance. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 121,000.
NHTSA ODI #11743224
114,000 miles · Feb 6, 2026
Service Brakes, Hydraulic
The contact owns a 2015 Toyota Prius. The contact stated that while driving at an undisclosed speed, the ABS and the traction control warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a leak in the brake fluid hose. The contact was unsure what repair was performed, but the …
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated that while driving at an undisclosed speed, the ABS and the traction control warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a leak in the brake fluid hose. The contact was unsure what repair was performed, but the vehicle was repaired. The contact stated that the failure reoccurred with an abnormal sound. The vehicle was taken back to the independent mechanic, and the contact was informed that the vehicle needed to be taken to the dealer for a complete diagnostic test. The vehicle was taken to the dealer, where it was diagnosed with brake booster failure. The contact was informed that the brake booster needed to be replaced. The vehicle was not repaired. The contact was notified of Customer Support Campaign: ZJB; however, the contact was informed that the repair was not covered under the Customer Support Program because of the 10-year 100,000-mile limitation. The manufacturer was made aware of the failure, and a case was filed. In addition, the contact stated that the Customer Support Program: ZJB, was mailed out to customers 10 years ago. The contact stated that the information was never received. The failure mileage was approximately 114,000.
NHTSA ODI #11716168
94,100 miles · Nov 3, 2025
Service Brakes, Hydraulic
The contact owns a 2015 Toyota Prius. The contact stated that while driving approximately 15-20 MPH, the ABS, brakes, and the traction control warning lights, and the malfunction indicator light were illuminated. Additionally, the vehicle hesitated to respond while depressing the brake pedal, causing the braking distance to be e…
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated that while driving approximately 15-20 MPH, the ABS, brakes, and the traction control warning lights, and the malfunction indicator light were illuminated. Additionally, the vehicle hesitated to respond while depressing the brake pedal, causing the braking distance to be extended. The vehicle was taken to the dealer, where it was diagnosed with an abnormal leak in the accumulator and a leak in the brake booster pump. The dealer determined that the brake master cylinder and the brake booster pump needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 94,100.
NHTSA ODI #11697182
186,000 miles · Sep 19, 2025
Service Brakes, Hydraulic
The contact owns a 2015 Toyota Prius. The contact stated that while driving at various speeds and depressing the brake pedal, the brake pedal went to the floorboard, and the vehicle hesitated while responding. The traction control, ABS, BRAKES, and cruise control warning lights were illuminated. The vehicle was taken to Gasket M…
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated that while driving at various speeds and depressing the brake pedal, the brake pedal went to the floorboard, and the vehicle hesitated while responding. The traction control, ABS, BRAKES, and cruise control warning lights were illuminated. The vehicle was taken to Gasket Masters Inc, where it was diagnosed and determined that the ABS assembly was leaking fluid into the braking system, and the ABS module had failed, causing the brake pump to fail. The vehicle was not repaired. Additionally, the malfunction warning light was illuminated. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 186,000.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: An unexpected hybrid power system shut down may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2015 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration