The contact owns a 2015 Toyota Prius. The contact stated while driving at various speeds, the brake, check engine, and ABS warning lights illuminated. The "Check Hybrid System - Stop Vehicle in A Safe Place" messages were displayed. The vehicle was taken to an unknown dealer where an unknown repair was completed; however, the fa…
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated while driving at various speeds, the brake, check engine, and ABS warning lights illuminated. The "Check Hybrid System - Stop Vehicle in A Safe Place" messages were displayed. The vehicle was taken to an unknown dealer where an unknown repair was completed; however, the failure recurred while driving. Additionally, the contact stated that while driving 25-45 MPH, the vehicle stalled. The contact was unable to restart the vehicle after several attempts. The vehicle was towed to the dealer who informed the contact that they could not duplicate the failure. The failure persisted. The vehicle was towed to the contact's residence. The contact became aware of NHTSA Campaign Number: 20V369000 (Hybrid Propulsion System). The manufacturer was notified of the failure and informed the contact that they could not assist. The vehicle was not diagnosed or repaired. The failure mileage was approximately 29,407.
NHTSA ODI #11468417
110,000 miles · Jul 13, 2021
Electrical SystemHybrid Propulsion System
The contact owns a 2015 Toyota Prius. The contact stated while attempting to start the vehicle, there were several unknown warning lights illuminated. Additionally, the Hybrid System failure message was displayed on the instrument panel. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it wa…
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated while attempting to start the vehicle, there were several unknown warning lights illuminated. Additionally, the Hybrid System failure message was displayed on the instrument panel. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the inverter to be replaced. The vehicle was not repaired but was pending the repair. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V369000 (Hybrid Propulsion System) however, the Vin was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 110,000.
NHTSA ODI #11424551
45,000 miles · Jun 22, 2021
Hybrid Propulsion System
The contact owns a 2015 Toyota Prius. The contact stated that while driving at 15 MPH, the vehicle began to die as the "check hybrid system, stop the vehicle in a safe place" warning message illuminated on the instrument panel. The contact was able to barely pull off to the side and called the police for assistance. The police w…
Read full complaint
The contact owns a 2015 Toyota Prius. The contact stated that while driving at 15 MPH, the vehicle began to die as the "check hybrid system, stop the vehicle in a safe place" warning message illuminated on the instrument panel. The contact was able to barely pull off to the side and called the police for assistance. The police were able to move the vehicle to the side of the road and a tow truck was called for assistance. A police report was filed. The vehicle was initially towed to a gas station but the contact then had the vehicle towed to a dealer. While there, she discovered NHTSA Campaign Number: 20V369000 (HYBRID PROPULSION SYSTEM), which she linked to her failure; however, her VIN was not included in the recall. The manufacturer was notified of the failure. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was 45,000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: An unexpected hybrid power system shut down may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2015 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration