Electrical SystemElectronic Stability Control (esc)
MY CAR HAS STOPPED RUNNING WITH ALL WARNING LIGHTS AND HYBRID SYSTEM FAILURE WARNING THREE TIMES NOW. FIRST TIME I WAS DRIVING WHEN LIGHTS CAME ON BUT GOT TO PARKING LOT WHERE IT DIED. I WAS ABLE TO RESTART CAR AFTER A COUPLE OF HOURS, STILL ALL WARNING LIGHTS AND HYBRID WARNING SHOWING BUT WAS ABLE TO GET IT TO DEALERSHIP. SEC…
Read full complaint
MY CAR HAS STOPPED RUNNING WITH ALL WARNING LIGHTS AND HYBRID SYSTEM FAILURE WARNING THREE TIMES NOW. FIRST TIME I WAS DRIVING WHEN LIGHTS CAME ON BUT GOT TO PARKING LOT WHERE IT DIED. I WAS ABLE TO RESTART CAR AFTER A COUPLE OF HOURS, STILL ALL WARNING LIGHTS AND HYBRID WARNING SHOWING BUT WAS ABLE TO GET IT TO DEALERSHIP. SECOND TIME I WAS DRIVING ON SMALL ROAD AND WAS ABLE TO GET CAR TO SIDE OF ROAD. AGAIN IT STARTED AFTER A COUPLE HOURS WITH ALL WARNINGS LIT AND I WAS ABLE TO DRIVE TO DEALERSHIP WERE IT ALSO DIED AGAIN BUT THEY STARTED IT LATER BY RESETTING CODES. THIRD TIME IT STOPPED IN DRIVEWAY AND I WAS UNABLE TO START IT. HAD IT TOWED TO DEALERSHIP. FIRST TIME. 12V BATTERY WAS REPLACED AND SOFTWARE UPDATE PERFORMED. SECOND TWO TIMES IRA TOYOTA DEALERSHIP HAS SENT ME BACK OUT ON THE ROAD TO WAIT AND SEE IF IT HAPPENS AGAIN.
NHTSA ODI #11310325
21,000 miles · Jan 2, 2020
Electronic Stability Control (esc)EngineService Brakes
ATTEMPTING TO TRAVEL IN MY 2013 PRIUS FIVE DURING XMAS WAS DRIVING AND APPROACHING A RED AND WHILE TRYING TO STOP PEDAL WENT DIRECTLY TO FLOOR AND SKID LIGHT WENT ON AND BARELY AVOIDED WHAT SHOULD BE AN EASY STOP!! WEATHER CLEAR FELT A DRAG AND NO COASTING ABILITY... CAR HAS 21,000 MILES AND IS IN PERFECT APPEARANCE BUT FAR FROM…
Read full complaint
ATTEMPTING TO TRAVEL IN MY 2013 PRIUS FIVE DURING XMAS WAS DRIVING AND APPROACHING A RED AND WHILE TRYING TO STOP PEDAL WENT DIRECTLY TO FLOOR AND SKID LIGHT WENT ON AND BARELY AVOIDED WHAT SHOULD BE AN EASY STOP!! WEATHER CLEAR FELT A DRAG AND NO COASTING ABILITY... CAR HAS 21,000 MILES AND IS IN PERFECT APPEARANCE BUT FAR FROM IN PEAK CONDITION AS THIS CAR FROM BRAND NEW HAD ISSUES I GOT TIRED WAITING FOR TOYOTA TO FIX. CRUISE CONTROL, BRAKES, BLUETOOTH, ENGINE WRAPPING SOUNDS ON STARTUP, I AM TOLD THE BRAKE ISSUE SINCE NEW IS NOW A 3,000+ REPAIR AND SINCE IT SHOWED NO CODE AT DEALER I WOULD HAVE TO PAY! MERRY XMAS TOYOTA! WHAT IS NHTSA WAITING FOR??? I AM SHOCKED AT BOTH FOR INACTION SO I WILL MAKE SOME CALL TO MY ELECTED OFFICIALS THIS HAS TO BE FIXED. TOYOTA IS BECOMING GM WHO WOULD HAVE FIGURED?? MY OTHER PRIUS ISSUES MATTER LESS WHEN BRAKES DON'T STOP YOU REASONABLY AND THE REPAIR IS OVER 3,000 ON A CAR WITH 21,000 WELL CARED FOR MILES...
NHTSA ODI #11296756
29,380 miles · Apr 17, 2019
Electronic Stability Control (esc)Service Brakes
2013 PRIUS, MILEAGE 29,409. CAR IN MOTION DRIVING ON CITY STREETS. WHILE BREAKING ON UNEVEN ROADS/POTHOLES, THE CAR SKIDS AND FRONT WHEELS LOCK UP AND TRACTION CONTROL/BREAK ASSIST LIGHT APPEARS ON THE DASHBOARD. WHEN THIS OCCURS THE CAR IS DANGEROUSLY SLOW TO BREAK AND TAKES FAR TOO LONG TO STOP. THIS HAPPENS ALMOST DAILY ON MY…
Read full complaint
2013 PRIUS, MILEAGE 29,409. CAR IN MOTION DRIVING ON CITY STREETS. WHILE BREAKING ON UNEVEN ROADS/POTHOLES, THE CAR SKIDS AND FRONT WHEELS LOCK UP AND TRACTION CONTROL/BREAK ASSIST LIGHT APPEARS ON THE DASHBOARD. WHEN THIS OCCURS THE CAR IS DANGEROUSLY SLOW TO BREAK AND TAKES FAR TOO LONG TO STOP. THIS HAPPENS ALMOST DAILY ON MY COMMUTE TO WORK IN BOTH DRY AND WET CONDITIONS. THIS SEEMS TO BE AN ISSUE WITH THE BREAKING/STABILITY SYSTEM.
NHTSA ODI #11197067
58,150 miles · Dec 10, 2018
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System
CAR STALLS OUT AND WON'T ACCELERATE
NHTSA ODI #11160621
100,000 miles · Dec 5, 2018
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
I NOTICED WHEN I WAS DRIVING ON A DRY CLEAR DAY TRACTION CONTROL/BRAKE LIGHT/ABS ILLUMINATED MY BRAKES BECAME EXTREMELY HARD TO PRESS AND COME TO A STOP ALSO MY CRUISE CONTROL WILL NOT ENGAGE. THE LIGHTS ON THE DASH WOULD GO OFF AND THE CAR WOULD DRIVE NORMAL FOR A FEW DAYS. IT REPEATED THIS SCENARIO A FEW TIMES BEFORE THE TRACT…
Read full complaint
I NOTICED WHEN I WAS DRIVING ON A DRY CLEAR DAY TRACTION CONTROL/BRAKE LIGHT/ABS ILLUMINATED MY BRAKES BECAME EXTREMELY HARD TO PRESS AND COME TO A STOP ALSO MY CRUISE CONTROL WILL NOT ENGAGE. THE LIGHTS ON THE DASH WOULD GO OFF AND THE CAR WOULD DRIVE NORMAL FOR A FEW DAYS. IT REPEATED THIS SCENARIO A FEW TIMES BEFORE THE TRACTION CONTROL/BRAKE LIGHT/ABS LIGHTS STAYED ON PERMANENTLY AS WELL AS THE CRUISE CONTROL WILL NOT ENGAGE.
NHTSA ODI #11156466
Mileage unknown · Nov 13, 2018
Electronic Stability Control (esc)
A RECALL WAS ISSUED FOR THE YEARS 2010 THROUGH 2014, PENDING THE DEVELOPMENT AND DISTRIBUTION OF A REMEDY. IT HAS BEEN FOUR YEARS AND I FEEL THAT HAS ALLOWED TOYOTA SUFFICIENT TIME TO ISSUE A REMEDY.
NHTSA ODI #11151191
60,000 miles · Oct 5, 2017
Electronic Stability Control (esc)Service Brakes
WHEN MOVING THEN BRAKING, JUST BEFORE THE CAR STOPS(IN THE LAST FEET OF DEAD STOP) THE BRAKE PEDAL SHAKES AND THE TIRES FEELS LIKE THEY ARE ENGAGING AND DISENGAGING IN BRAKES, ASSOCIATED WITH LOUD RUBBER NOISE RUBBING(LIKE UN-LUBRICATED ACTUATOR). THIS NOISE IS ALSO HEARD 2 MINUTES AFTER SWITCHING THE CAR OFF
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: An unexpected hybrid power system shut down may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2013 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration