NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
71 reportsClear category filter15,000 miles · Mar 10, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2009 TOYOTA PRIUS. WHILE THE CONTACT WAS DRIVING 75 MPH THE VEHICLE SUDDENLY ACCELERATED. IN ORDER TO STOP THE ACCELERATION THE CONTACT HAD TO APPLY THE BRAKES AND SHIFT THE VEHICLE INTO NEUTRAL GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE CAUSE OF THE FAILURE COULD NOT …
Read full complaint
TL*THE CONTACT OWNS A 2009 TOYOTA PRIUS. WHILE THE CONTACT WAS DRIVING 75 MPH THE VEHICLE SUDDENLY ACCELERATED. IN ORDER TO STOP THE ACCELERATION THE CONTACT HAD TO APPLY THE BRAKES AND SHIFT THE VEHICLE INTO NEUTRAL GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 15000 AND THE CURRENT MILEAGE WAS 18000.
NHTSA ODI #10318385
6,300 miles · Mar 10, 2010
Service Brakes, HydraulicVehicle Speed Control
I WAS DRIVING MY 2009 TOYOTA PRIUS, EXITING THE STATEN ISLAND EXPRESSWAY AND AS I APPROACHED THE INTERSECTION THE LIGHT BEGAN TO TURN YELLOW AND I TRIED TO STOP (THE ROAD SURFACE WAS UNEVEN). WHEN I PUT MY FOOT ON THE BRAKE THE CAR LURCHED FORWARD INTO THE INTERSECTION SO I HAD TO GO THOUGH THE RED LIGHT AND I WAS LUCKY THAT T…
Read full complaint
I WAS DRIVING MY 2009 TOYOTA PRIUS, EXITING THE STATEN ISLAND EXPRESSWAY AND AS I APPROACHED THE INTERSECTION THE LIGHT BEGAN TO TURN YELLOW AND I TRIED TO STOP (THE ROAD SURFACE WAS UNEVEN). WHEN I PUT MY FOOT ON THE BRAKE THE CAR LURCHED FORWARD INTO THE INTERSECTION SO I HAD TO GO THOUGH THE RED LIGHT AND I WAS LUCKY THAT THE ONCOMING TRAFFIC HADN'T BEGUN TO MOVE YET. *TR
NHTSA ODI #10318355
8,000 miles · Mar 9, 2010
Fuel System, OtherVehicle Speed Control
MY 2009 TOYOTA PRIUS HAS HAD OCCASIONAL BURSTS OF ENERGY AND JOLTS FORWARD ON IS OWN. LUCKILY I WAS IN "PARK" EACH TIME IT HAPPENED. I WASN'T EVEN PUSHING THE GAS PEDAL. IT WAS A VERY SUDDEN THING, I HAD NO WARNING. IT'S DEFINITELY NOT A FLOOR MAT ISSUE. NOW I'M AFRAID TO DRIVE IT. THE LAST TIME THIS HAPPENED WAS APPROXIMAT…
Read full complaint
MY 2009 TOYOTA PRIUS HAS HAD OCCASIONAL BURSTS OF ENERGY AND JOLTS FORWARD ON IS OWN. LUCKILY I WAS IN "PARK" EACH TIME IT HAPPENED. I WASN'T EVEN PUSHING THE GAS PEDAL. IT WAS A VERY SUDDEN THING, I HAD NO WARNING. IT'S DEFINITELY NOT A FLOOR MAT ISSUE. NOW I'M AFRAID TO DRIVE IT. THE LAST TIME THIS HAPPENED WAS APPROXIMATELY A MONTH AGO, I ASKED IF THERE WAS RECALL FOR MY CAR, AND THE DEALER SAID NO. WHAT'S MAKING ME WORRY NOW IS THE STORY ON THE NEWS ABOUT A "RUNAWAY" PRIUS. I THANK YOU IN ADVANCE FOR ANYTHING YOU CAN DO TO HELP. *TR
NHTSA ODI #10318324
25,000 miles · Mar 5, 2010
Vehicle Speed Control
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED AS SHE WAS DRIVING THERE WAS UNINTENDED ACCELERATION WHICH HAPPEN TWICE. TO STOP THE VEHICLE SHE HAD TO PULL TO THE SIDE OF THE ROAD OR RUN THE VEHICLE INTO THE CURB. THE DEALER WAS CALLED AND STATED SHE CAN BRING THE VEHICLE IN FOR THEM TO TAKE A LOOK BUT THERE IS NO…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED AS SHE WAS DRIVING THERE WAS UNINTENDED ACCELERATION WHICH HAPPEN TWICE. TO STOP THE VEHICLE SHE HAD TO PULL TO THE SIDE OF THE ROAD OR RUN THE VEHICLE INTO THE CURB. THE DEALER WAS CALLED AND STATED SHE CAN BRING THE VEHICLE IN FOR THEM TO TAKE A LOOK BUT THERE IS NO FIX FOR THE FAILURE. THE TOYOTA MANUFACTURER WAS CALLED AND THEY STATED THERE IS NO FIX AND GAVE HER A CLAIM NUMBER. THE FAILURE MILEAGE WAS 25,000.
NHTSA ODI #10317161
9,350 miles · Mar 3, 2010
Vehicle Speed ControlCrash
1. AFTER TURNING OFF CRUISE CONTROL, VEHICLE ACCELERATED ON ITS OWN UP TO 95M.P.H. UNTIL I WAS FINALLY ABLE TO GET IT STOPPED BY PRESSING THE BRAKES TO THE FLOOR. AFTER GETTING THE VEHICLE PULLED OVER TO THE SIDE OF THE INTERSTATE, THERE WAS A LOT OF SMOKE COMING FROM THE FRONT BRAKE PADS. I RESTARTED THE VEHICLE IN AN ATTEMP…
Read full complaint
1. AFTER TURNING OFF CRUISE CONTROL, VEHICLE ACCELERATED ON ITS OWN UP TO 95M.P.H. UNTIL I WAS FINALLY ABLE TO GET IT STOPPED BY PRESSING THE BRAKES TO THE FLOOR. AFTER GETTING THE VEHICLE PULLED OVER TO THE SIDE OF THE INTERSTATE, THERE WAS A LOT OF SMOKE COMING FROM THE FRONT BRAKE PADS. I RESTARTED THE VEHICLE IN AN ATTEMPT TO GET IT OFF THE INTERSTATE FOR FURTHER INSPECTION. AS I EXITED THE HIGHWAY, I TURNED THE VEHICLE ONTO THE OFF RAMP BUT THE VEHICLE DID NOT TURN AND DROVE US DIRECTLY INTO THE GUARD RAIL. I CONTACTED TOYOTA AND THEY HAVE DENIED THERE WAS ANYTHING WRONG WITH THE VEHICLE AND DISMISSED MY COMPLAINT. *TR
NHTSA ODI #10316156
10,000 miles · Feb 25, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2009 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 65 MPH ON A COLD DAY, THE VEHICLE ACCELERATED UP TO 108 MPH. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WAS STUCK. THE VEHICLE WAS PLACED IN NEUTRAL GEAR IN ORDER TO STOP IT FROM ACCELERATING. THE VEHICLE DID NOT CRASH AND THERE WERE NO INJURIES. THE FAI…
Read full complaint
TL*THE CONTACT OWNS A 2009 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 65 MPH ON A COLD DAY, THE VEHICLE ACCELERATED UP TO 108 MPH. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WAS STUCK. THE VEHICLE WAS PLACED IN NEUTRAL GEAR IN ORDER TO STOP IT FROM ACCELERATING. THE VEHICLE DID NOT CRASH AND THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000 MILES AND THE CURRENT MILEAGE WAS 11,000. UPDATED 03/24/10 *BF UPATED 07/07/10.*JB
NHTSA ODI #10314233
9,719 miles · Feb 24, 2010
Service Brakes, HydraulicTiresVehicle Speed Control
MULTIPLE ISSUES WITH 2009 PRIUS. FIRST: LOSS OF AIR PRESSURE IN FRONT LEFT TIRE FROM TIME I PICKED UP THE VEHICLE TO PRESENT. I CONTINUALLY NEED TO PUT AIR IN THE TIRE, USUALLY ON A WEEKLY/BI-WEEKLY BASIS. THE OTHER TIRES ARE FINE. SECOND: FOR THE SAME TIRE, THE TIRE PRESSURE LIGHT WOULD NOT BE TRIGGERED UNTIL ~23 POUNDS, …
Read full complaint
MULTIPLE ISSUES WITH 2009 PRIUS. FIRST: LOSS OF AIR PRESSURE IN FRONT LEFT TIRE FROM TIME I PICKED UP THE VEHICLE TO PRESENT. I CONTINUALLY NEED TO PUT AIR IN THE TIRE, USUALLY ON A WEEKLY/BI-WEEKLY BASIS. THE OTHER TIRES ARE FINE. SECOND: FOR THE SAME TIRE, THE TIRE PRESSURE LIGHT WOULD NOT BE TRIGGERED UNTIL ~23 POUNDS, SHOULD HAVE BEEN TRIGGERED IN SAME TIRE AT 33 LBS. THIRD: VEHICLE WOULD NOT STOP WHEN APPLYING PRESSURE ON BRAKES AT SLOW SPEED. THIS HAS OCCURRED ABOUT 6 TIMES IN A 6 MONTH PERIOD. SIMULTANEOUSLY, THE VSC LIGHT WENT ON AND THE SLID INDICATOR WENT ON. THE TERRAIN WAS ON EITHER ASPHALT OR CONCRETE ROADS, SLIGHTLY DOWNHILL (CONCRETE) AND ONE STREET IS A BIT ROUGH (FILLED IN POT HOLES). ALSO, BOTH AREAS ARE WITHIN A QUARTER MILE OF EACH OTHER AND NEAR THE OCEAN. WITH EACH OCCURRENCE THE VSC WENT INTO EFFECT. ON 11/21/09 IT JOLTED HARD MUCH MORE THAN THE OTHER OCCASIONS; THIS DATE WAS THE INCIDENT ON THE BRIDGE WHEN THE CAR WAS GOING IN A SLIGHT DOWNWARD DIRECTION. I LOST CONTROL OF THE VEHICLE FOR SEVERAL SECONDS AND WAS AFRAID THAT I WOULD HIT THE CAR IN FRONT OF ME; I BEEPED MY HORN TO WARN THE DRIVER IN FRONT OF ME. MY VEHICLE DID STOP IN TIME BUT IT TOOK ALOT LONGER THAN IT SHOULD HAVE TAKEN. ON A LATER OCCASION, I WAS GOING ABOUT 5-10 MPH FASTER ON A NEARBY STREET AND ATTEMPTED TO STOP FOR A STOP SIGN AND IT DID THE SAME THING, HOWEVER THE VSC DID NOT JOLT BACK AS HARD. THE VEHICLE WAS NOT ANGLED DOWN AS MUCH AS THE 11/21/09 INCIDENT. ON 11/21/09 I TOOK THE VEHICLE TO CABE TOYOTA DEALERSHIP AND THEY LOOKED AT THE CAR BUT FOUND NOTHING WRONG WITH IT. I ALSO HAD THE CAR LOOKED AT BY TOYOTA CORP TODAY AND WAS TOLD THAT THE DRIVER FEELS THAT I FELT THE ABS BRAKES ONLY. THIS IS NOT THE CASE. WHEN I STEPPED ON THE BRAKES EACH OCCASION IT WAS AS THOUGH THERE WAS NOTHING THERE AND I HAD NO CONTROL IN STOPPING IT. THIS WAS ESPECIALLY TRUE WHEN THE VSC KICKED IN (THE JERKING). EACH TIME IT LASTED MANY, SEVERAL OR MORE SECONDS. *TR
NHTSA ODI #10313838
6,700 miles · Feb 15, 2010
SteeringTraction Control SystemVehicle Speed Control
IN ADDITION TO THE TRACTION CONTROL, ABS, GAS PEDAL/FLOOR MAT PROBLEMS WITH THE TOYOTA PRIUS THERE IS ALSO A SAFETY ISSUE WITH THE POWER BUTTON. IN AN EMERGENCY SITUATION, LIKE THE DOOR COMING OPEN, THROTTLE GETTING STUCK, ETC. YOU CAN'T POWER OFF THE VEHICLE QUICKLY. YOU MUST HOLD THE POWER BUTTON FOR SOME AMOUNT OF TIME BEFORE…
Read full complaint
IN ADDITION TO THE TRACTION CONTROL, ABS, GAS PEDAL/FLOOR MAT PROBLEMS WITH THE TOYOTA PRIUS THERE IS ALSO A SAFETY ISSUE WITH THE POWER BUTTON. IN AN EMERGENCY SITUATION, LIKE THE DOOR COMING OPEN, THROTTLE GETTING STUCK, ETC. YOU CAN'T POWER OFF THE VEHICLE QUICKLY. YOU MUST HOLD THE POWER BUTTON FOR SOME AMOUNT OF TIME BEFORE THE CAR WILL SHUT OFF. UNLIKE THE TOYOTA CAMRY EXAMPLE WHERE THEY SUGGESTED TURNING OFF THE IGNITION, YOU CAN'T DO THAT ON THE PRIUS. YOU ALSO CAN'T REMOVE THE KEY/FOB TO TURN THE VEHICLE OFF OR POWER IT OFF. THERE IS ALSO AN EXTREME UNDER STEER PROBLEM WITH THE VEHICLE WHICH IS A SAFETY CONCERN. IN WET CONDITIONS IT IS EXACERBATED. IT CAN BE OBSERVED ON CLOVER LEAF OVERPASSES AND GENERAL CORNERING. *TR
NHTSA ODI #10310682
12,500 miles · Feb 15, 2010
Vehicle Speed Control
I KEEP HEARING ABOUT THE MOMENTARY LOSS OF BRAKING ON THE 2010 TOYOTA PRIUS. HOWEVER, I HAVE ENCOUNTERED THE SAME PROBLEM ON MY 2009 PRIUS. WHEN PASSING OVER A SLICK, BUMPY, OR ICY SURFACE, I EXPERIENCE A MOMENTARY LOSS OF BRAKING, AND A WARNING LIGHT THAT LOOKS LIKE A CAR SKIDDING COMES ON FOR LESS THAN A SECOND. THIS GENERA…
Read full complaint
I KEEP HEARING ABOUT THE MOMENTARY LOSS OF BRAKING ON THE 2010 TOYOTA PRIUS. HOWEVER, I HAVE ENCOUNTERED THE SAME PROBLEM ON MY 2009 PRIUS. WHEN PASSING OVER A SLICK, BUMPY, OR ICY SURFACE, I EXPERIENCE A MOMENTARY LOSS OF BRAKING, AND A WARNING LIGHT THAT LOOKS LIKE A CAR SKIDDING COMES ON FOR LESS THAN A SECOND. THIS GENERALLY OCCURS AT SLOW SPEEDS, BUT HAS OCCURRED AT SPEEDS UP TO 25-30 MPH. *TR
NHTSA ODI #10310573
4,000 miles · Feb 12, 2010
Vehicle Speed Control
I HAVE A 2009 PRIUS AND ON AT LEAST 4 OCCASIONS IN CRUISE CONTROL MY CAR HAS ACCELERATED WITHOUT MY DOING SO. ALL OF THE TIMES I WAS ABLE TO BRAKE AND BRING DOWN MY SPEED. WE TRIED TO REPORT THIS TO TOYOTA BUT THEY WERE NOT CONCERNED. WE THEN REPORTED THIS TO THE DEALERSHIP AND THE MECHANIC TOLD MY HUSBAND THAT " THAT SOMETIMES…
Read full complaint
I HAVE A 2009 PRIUS AND ON AT LEAST 4 OCCASIONS IN CRUISE CONTROL MY CAR HAS ACCELERATED WITHOUT MY DOING SO. ALL OF THE TIMES I WAS ABLE TO BRAKE AND BRING DOWN MY SPEED. WE TRIED TO REPORT THIS TO TOYOTA BUT THEY WERE NOT CONCERNED. WE THEN REPORTED THIS TO THE DEALERSHIP AND THE MECHANIC TOLD MY HUSBAND THAT " THAT SOMETIMES HAPPENS". NO REPORT WAS FILED OR ACTION TAKEN. *TR
NHTSA ODI #10308885
Official recalls
6Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Illustration