IllustrationWhen I am coming to a stop or need to put on my brakes my car will accelerate at a jump ahead pace As if to take off instead of slowing down and stopping. Regardless whether I’m turning a corner or I’m continuing straight when I have to Put on the brakes it speeds up instead.
2009 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2009 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1880–25K
4325–50K
4050–75K
4675–100K
52100–150K
33150K+
402 reports with mileage · 100 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
64 crash reports4 fire reports21 injury reports
Vehicle Speed Control complaints
71 reportsI went to park in a parallel space when all of a sudden my ABS, (!), VSC light come on with the loss of brake power and a loud beeping noise. With this sudden loss of brakes in the middle of driving, I could have harmed myself and others in any cars around me because I also lost steering capability. This is a problem that there…
Read full complaint
I went to park in a parallel space when all of a sudden my ABS, (!), VSC light come on with the loss of brake power and a loud beeping noise. With this sudden loss of brakes in the middle of driving, I could have harmed myself and others in any cars around me because I also lost steering capability. This is a problem that there was an extended warranty for, but there should be a recall. My car is a 2009 and was only covered before the pandemic and now it is 2021 and I have no recourse, but to try and fork over $3500.00 for which I don't have. I am a second owner and this is a very common problem amongst Prius owners. I didn't have any other symptoms that I could point out prior to this situation. I have had my hybrid battery, engine, ecu and most recently a stolen catalytic converter replaced. This ABS actuator problem needs to be addressed for another 5 years with a free repair. I would hate to have hit some other car and had my car smash into a wall, another car, pedestrian, pole or any other object based on it's ability not to stop.
MY PRIUS NOW HAS ALL THOSE DASH LIGHTS ON: !, ABS, VCS. I WAS DRIVING YESTERDAY, ON A CITY STREET AND THE LIGHTS CAME ON, AND THE BRAKES SUDDENLY DID NOT WORK-HARD TO PUSH. FOR MONTHS, WHEN I WOULD DRIVE OVER ROUGH TERRAIN, I HAD THE LOSS OF BRAKING, ACCELERATING, AND THE SLICK ROAD ICON WOULD ILLUMINATE. THE IS EXACTLY THE SAME…
Read full complaint
MY PRIUS NOW HAS ALL THOSE DASH LIGHTS ON: !, ABS, VCS. I WAS DRIVING YESTERDAY, ON A CITY STREET AND THE LIGHTS CAME ON, AND THE BRAKES SUDDENLY DID NOT WORK-HARD TO PUSH. FOR MONTHS, WHEN I WOULD DRIVE OVER ROUGH TERRAIN, I HAD THE LOSS OF BRAKING, ACCELERATING, AND THE SLICK ROAD ICON WOULD ILLUMINATE. THE IS EXACTLY THE SAME ABS MODULE PROBLEM AFFECTING 2010 PRIUS, ANDS NEEDS TO BE RECALLED AND REPAIRS COVERED.IF I DIDN'T STAY SO FAR BEHIND OTHER VEHICLES, I WOULD HAVE REAR-ENDED SOMEONE.
CONSUMER WRITES IN REGARDS TO VEHICLE STEERING LOSS, BRAKE LOSS AND ACCELERATION ISSUES, CORPORATION FAILURE TO INFORM CONSUMER OF COUNTERFEIT DRIVE TRAIN ISSUES THAT INJURED CONSUMER. SMD THE CONSUMER STATED TOYOTA FAILED TO WARN THEM ABOUT BEING CONVICTED OF "USING THE INTELLECTUAL PROPERTY OF HYBRID DRIVE INVENTOR WITHOUT…
Read full complaint
CONSUMER WRITES IN REGARDS TO VEHICLE STEERING LOSS, BRAKE LOSS AND ACCELERATION ISSUES, CORPORATION FAILURE TO INFORM CONSUMER OF COUNTERFEIT DRIVE TRAIN ISSUES THAT INJURED CONSUMER. SMD THE CONSUMER STATED TOYOTA FAILED TO WARN THEM ABOUT BEING CONVICTED OF "USING THE INTELLECTUAL PROPERTY OF HYBRID DRIVE INVENTOR WITHOUT HIS PERMISSION." *TR
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. WHILE DRIVING AT 2 MPH AND MAKING A LEFT TURN, THE VEHICLE ACCELERATED INDEPENDENTLY AND THE CONTACT LOST CONTROL OF THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO A GARBAGE TRUCK. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE CONTACT PULLED THE VEHICLE OVER …
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. WHILE DRIVING AT 2 MPH AND MAKING A LEFT TURN, THE VEHICLE ACCELERATED INDEPENDENTLY AND THE CONTACT LOST CONTROL OF THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO A GARBAGE TRUCK. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND DROVE HOME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIRS. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNKNOWN. *TT
DRIVER WENT TO PARK AND THE BRAKES DID NOT RESPOND! IN FACT THE VEHICLE WENT FROM 2-5MPH TO APPROX 30+ & KEPT PICKING UP SPEED AND WENT INTO STOREFRONT. DRIVER WAS ABLE TO WRESTLE VEHICLE INTO REVERSE AND IT WENT EQUALLY FAST BACK INTO A PARKED CAR WHERE IT FINALLY CAME TO A STOP. HUGELY FRIGHTENING AND POTENTIALLY LETHAL.
2009 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO VEHICLE ACCELERATION ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WAS INSPECTED ON MAY 10, 2010. ON FEBRUARY 11, 2010, THE CONSUMERS WIFE WAS APPROACHING A SMALL BUSINESS IN A PARKING LOT. SHE WAS ALMOST AT A DEAD STOP, WHEN THE VEHICLE SUDDENLY WENT A RAPID ACCELERATION MODE…
Read full complaint
2009 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO VEHICLE ACCELERATION ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WAS INSPECTED ON MAY 10, 2010. ON FEBRUARY 11, 2010, THE CONSUMERS WIFE WAS APPROACHING A SMALL BUSINESS IN A PARKING LOT. SHE WAS ALMOST AT A DEAD STOP, WHEN THE VEHICLE SUDDENLY WENT A RAPID ACCELERATION MODE, JUMPED A CURBED AND SIDEWALK, AND HIT A BRICK WALL OF A BUSINESS BUILDING. THERE WAS SEVERE DAMAGE TO THE VEHICLE AS WELL AS TO THE BRICK WALL OF THE BUILDING. THE AIR BAG DID NOT DEPLOY. *JB
TOYOTA PRIUS 2009 HEADLIGHTS WERE ON AND OFF FINALLY THE LEFT SIDE WENT OFF TOTALLY. THE SEAL OUTSIDE THE HEADLIGHT DIDN'T PREVENT OF WATER CAME INTO THE SYSTEM AND DAMAGED IT . ALSO WHILE DRIVING THE CAR ACCELERATED AND DECELERATED BY ITSELF . AND WHILE STOPPING THE CAR JUMP. *TR
A YEAR AGO, UPON TAKING OFF FROM A STOP MY CAR BEGAN TO STALL. I DRIVE TWO BLOCKS IT CONTINUES TO PUTT ALONG AND STALL, THEN AFTER LESS THAN A MILE IT STARTS TO RUN AS NORMAL. I TAKE MY CAR IN TO BE TOLD IT IS OUT OF GAS, WHICH IT DID NOT INDICATE LOW FUEL, IT HAD OVER A QUARTER OF A TANK. I INSIST THEY CONTINUE TO CHECK MY CAR …
Read full complaint
A YEAR AGO, UPON TAKING OFF FROM A STOP MY CAR BEGAN TO STALL. I DRIVE TWO BLOCKS IT CONTINUES TO PUTT ALONG AND STALL, THEN AFTER LESS THAN A MILE IT STARTS TO RUN AS NORMAL. I TAKE MY CAR IN TO BE TOLD IT IS OUT OF GAS, WHICH IT DID NOT INDICATE LOW FUEL, IT HAD OVER A QUARTER OF A TANK. I INSIST THEY CONTINUE TO CHECK MY CAR OVER DAYS OF THEM DRIVING IT, AFTER A WEEK THEY EXPERIENCE SOMETHING SIMILAR AND REPLACE MY JUNCTION BOX. SINCE THEN I'VE REPLACE THE WATER PUMP, TAKEN MY CAR IN FOR A STEERING RECALL. ALSO, THERE ARE INSTANCES WHERE MY CAR UPON TAKE OFF STALLS, BUT NOTHING SEVERE, JUST SOMETHING YOU FEEL WHEN ACCELERATING. RECENTLY, 6/5/14, I EXPERIENCED THE SAME ISSUE, BUT THIS TIME I IMMEDIATELY PUT GAS INTO MY CAR EVEN THOUGH MY INDICATOR PANEL SHOWS I HAVE FUEL. ONLY THIS TIME I START MY CAR AND THE AIR CONDITIONER IS NOT WORKING AND IT CONTINUES TO STALL, AFTER TURNING MY CAR ON AND OFF SEVERAL TIMES AND DRIVING A FEW BLOCKS THE AC CUTS ON AND MY CAR BEGINS TO RUN FINE. I HAVE BEEN TOLD BY TOYOTA THAT BC THERE IS NO INDICATOR LIGHT AND IT'S RUNNING FINE THERE IS NOTHING THEY CAN DO. THERE WAS A RECENT RECALL IN FEBRUARY OF 2014 WITH SIMILAR ISSUES I AM EXPERIENCING BUT MY CAR WAS NOT APART OF THE RECALL. NOT SURE WHAT ELSE I CAN DO. NUMEROUS TOYOTA DEALERSHIPS HAVE BEEN OF NO HELP AND I FEAR THAT MY SAFETY IS AT RISK. *TR
DRIVER INTENTIONALLY ACCELERATED TO AVOID COLLISION, THEN PRIUS UNINTENTIONALLY ACCELERATED AFTER IMPACT WITH THE OTHER VEHICLE, CROSSING THE MEDIAN AND CROSSING THE OPPOSITE DIRECTION STREET LANES THEN UP ON TO THE SIDEWALK AND HIT THE CONCRETE BRIDGE RAIL AND FINALLY STOPPED. HAVE CONTACTED TOYOTA, THEY WANT UP TO A MONTH TO …
Read full complaint
DRIVER INTENTIONALLY ACCELERATED TO AVOID COLLISION, THEN PRIUS UNINTENTIONALLY ACCELERATED AFTER IMPACT WITH THE OTHER VEHICLE, CROSSING THE MEDIAN AND CROSSING THE OPPOSITE DIRECTION STREET LANES THEN UP ON TO THE SIDEWALK AND HIT THE CONCRETE BRIDGE RAIL AND FINALLY STOPPED. HAVE CONTACTED TOYOTA, THEY WANT UP TO A MONTH TO PULL THE CRASH DATA FROM THE CAR. I ASKED IF THEY COULD PULL THE DATA IN A WEEK, THEY SAID UP TO 30 DAYS THE CAR WILL HAVE TO SIT AT THE DEALERSHIP. A MONTH IS UNREASONABLE TO GO WITHOUT A CAR. THEY REFUSED TO SEND THE INVESTIGATOR TO PULL THE DATA AT THE BODY SHOP, SAID IT MUST BE DONE AT THE DEALERSHIP. I GAVE THEM THE NAME & ADDRESS OF THE BODY SHOP. *TR
Official recalls
613V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606