IllustrationTHE REAR HATCH RELEASE ON MY 2009 TOYOTA PRIUS HAS BEGUN TO DECOMPOSE AND TURN INTO A RUBBERY, GOOEY MESS. IT INTERFERES WITH THE USE OF THE HATCH AS THE GOO NOT ONLY GETS ON THE FINGERS BUT APPEARS TO BE BLOCKING THE RELEASE MECHANISM. *TR
2009 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2009 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1880–25K
4325–50K
4050–75K
4675–100K
52100–150K
33150K+
402 reports with mileage · 100 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
64 crash reports4 fire reports21 injury reports
Structure complaints
19 reportsTHE RUBBER COVER TO THE HATCHBACK TRUNK LATCH HAS MELTED. IT IS NOW STICKY AND GOOEY AND LITERALLY IMMOVABLE. THIS PRESENTS A SAFETY HAZARD, BECAUSE SOMETIMES I CAN'T OPEN THE HATCHBACK WHICH CONTAINS THE SPARE TIRE AND OTHER TOOLS. I HAVE NO OTHER WAY TO ACCESS ANYTHING IN THE "TRUNK" WHEN I'M UNABLE TO OPEN THE LATCH. THE TOY…
Read full complaint
THE RUBBER COVER TO THE HATCHBACK TRUNK LATCH HAS MELTED. IT IS NOW STICKY AND GOOEY AND LITERALLY IMMOVABLE. THIS PRESENTS A SAFETY HAZARD, BECAUSE SOMETIMES I CAN'T OPEN THE HATCHBACK WHICH CONTAINS THE SPARE TIRE AND OTHER TOOLS. I HAVE NO OTHER WAY TO ACCESS ANYTHING IN THE "TRUNK" WHEN I'M UNABLE TO OPEN THE LATCH. THE TOYOTA DEALER SAID THIS DEFECTIVE PART IS NOT COVERED BY WARRANTY AND QUOTED AN EXORBITANT PRICE TO REPLACE IT. I FEEL TOYOTA SHOULD REPLACE THIS DEFECTIVE PART AT NO COST TO OWNERS. *TR
I WAS TURNING LEFT INTO THE GAS STATION LOCATED ON US 22 AND E. JOHN ST. A SPEEDING CAR STRUCK ME ON THE PASSENGER SIDE NEAR THE DOOR AND FRONT FENDER. THE SPEEDING CAR CONTINUED SO HARD THAT THE DRIVER'S SIDE LOWER FRAME RAIL WAS RIPPED FROM THE CAR. NO AIR BAGS DEPLOYED. I SUFFERED LEFT KNEE AND LEFT SHOULDER INJURIES NECESS…
Read full complaint
I WAS TURNING LEFT INTO THE GAS STATION LOCATED ON US 22 AND E. JOHN ST. A SPEEDING CAR STRUCK ME ON THE PASSENGER SIDE NEAR THE DOOR AND FRONT FENDER. THE SPEEDING CAR CONTINUED SO HARD THAT THE DRIVER'S SIDE LOWER FRAME RAIL WAS RIPPED FROM THE CAR. NO AIR BAGS DEPLOYED. I SUFFERED LEFT KNEE AND LEFT SHOULDER INJURIES NECESSITATING SEVERAL SURGERIES. THE CAR WAS EQUIPPED WITH DRIVER'S SIDE AND FRONT RIGHT AIR BAGS. ALSO, DR AND FR SIDE AND CURTAIN AIR BAGS. NO AIR BAGS DEPLOYED. THE CAR WAS TOTALED BY THE INSURANCE COMPANY. *TR
MY WIFE AND I WERE DRIVING DOWN A RESIDENTIAL STREET APPROACHING A STOP SIGN. THERE WERE TWO CARS STOPPED AT THE SIGN. SEVERAL HUNDRED FEET FROM THE STOP, I TOOK MY FOOT OFF THE ACCELERATOR. THE CAR DID NOT SLOW DOWN. I STEPPED ON THE BRAKE. THE CAR DID NOT SLOW DOWN. I STOOD ON THE BRAKE AS HARD AS I COULD. THE CAR DID NOT SL…
Read full complaint
MY WIFE AND I WERE DRIVING DOWN A RESIDENTIAL STREET APPROACHING A STOP SIGN. THERE WERE TWO CARS STOPPED AT THE SIGN. SEVERAL HUNDRED FEET FROM THE STOP, I TOOK MY FOOT OFF THE ACCELERATOR. THE CAR DID NOT SLOW DOWN. I STEPPED ON THE BRAKE. THE CAR DID NOT SLOW DOWN. I STOOD ON THE BRAKE AS HARD AS I COULD. THE CAR DID NOT SLOW DOWN. I SAID TO MY UNDERSTANDABLY ALARMED WIFE, WE'RE NOT STOPPING. AND WE DIDN'T UNTIL WE SMASHED INTO THE BACK OF A TAHOE STOPPED AT THE STOP SIGN, DOING MAJOR DAMAGE TO THE PRIUS THAT RENDERED IT UNDRIVEABLE AND PERHAPS TOTALED. MY WIFE HAS A VERY SORE BACK THAT I AM HOPING STARTS TO FEEL BETTER TODAY OR WE WILL HAVE TO SCHEDULE A DOCTOR'S APPOINTMENT. *TR
THE BACK DOOR/HATCH SWITCH RUBBER IS MELTING/VERY STICKY. THE PROBLEM WAS FIRST REPORTED IN THE 2007 PRIUS AND OTHER MODEL TOYOTA MODELS. I EXPECT THAT THIS SWITCH WILL BECOME DEFECTIVE AND IT IS THE ONLY MEANS TO ENTER THE HATCH AREA OF THE PRIUS.THE HATCH AREA IS THE LOCATION OF THE SPARE TIRE, FLARES AND OTHER SAFETY PRODUC…
Read full complaint
THE BACK DOOR/HATCH SWITCH RUBBER IS MELTING/VERY STICKY. THE PROBLEM WAS FIRST REPORTED IN THE 2007 PRIUS AND OTHER MODEL TOYOTA MODELS. I EXPECT THAT THIS SWITCH WILL BECOME DEFECTIVE AND IT IS THE ONLY MEANS TO ENTER THE HATCH AREA OF THE PRIUS.THE HATCH AREA IS THE LOCATION OF THE SPARE TIRE, FLARES AND OTHER SAFETY PRODUCTS CARRIED IN THE AUTOMOBILE. THIS IS A VERY COMMON PROBLEM OF TOYOTA MODELS AND IS DEFINITELY A FACTORY DEFECTIVE PART. *TR
THE RUBBER COVER ON MY TOURING MODEL PRIUS'S HATCH LOCKING ASSEMBLY - THE HIDDEN AREA YOU GRAB TO OPEN THE HATCH - HAS DETERIORATED TO THE POINT THAT IT IS GUMMY LIKE TAR. THERE ARE DOZENS OF ONLINE COMPLAINTS ABOUT THIS HAPPENING TO 2007 AND 2008 MODELS, WHICH LIKE MY PRIUS, WERE MANUFACTURED IN JAPAN. I'VE OWNED SEVERAL HATCHB…
Read full complaint
THE RUBBER COVER ON MY TOURING MODEL PRIUS'S HATCH LOCKING ASSEMBLY - THE HIDDEN AREA YOU GRAB TO OPEN THE HATCH - HAS DETERIORATED TO THE POINT THAT IT IS GUMMY LIKE TAR. THERE ARE DOZENS OF ONLINE COMPLAINTS ABOUT THIS HAPPENING TO 2007 AND 2008 MODELS, WHICH LIKE MY PRIUS, WERE MANUFACTURED IN JAPAN. I'VE OWNED SEVERAL HATCHBACKS AND NEVER SEEN THIS PROBLEM ON MUCH OLDER HATCH LOCKS. FROM ALL OF THE ONLINE COMPLAINTS IT'S CLEAR TO ME THAT TOYOTA IS AWARE OF THIS DEFECT BUT WHEN CONTACTED, THEY FIRST TOLD ME THEY HAD NEVER HEARD OF THIS BEING A PROBLEM, AND NOW TELL ME IT ADVISES CUSTOMERS IT'S "NORMAL WEAR." FROM A SAFETY PERSPECTIVE THE MELTING RUBBER MAKES IT DIFFICULT TO OPEN THE REAR HATCH (A LIFE SAFETY ACCESS POINT), AND THE STICKY BLACK TAR-LIKE MATERIAL FROM THE COVER IS ALSO POTENTIALLY DANGEROUS. I ASK YOUR AGENCY TO TAKE A LOOK AT THESE INSTANCES AND ALSO TO INQUIRE WHY TOYOTA IS NOT RECALLING THESE HANDLES THAT ARE MELTING, WHICH HAS TO BE THE RESULT OF DEFECTIVE RUBBER. I THINK A DOOR HANDLE OR HATCH HANDLE SHOULD BE MADE TO LAST MORE THAN THREE YEARS. *TR
IN AN ATTEMPT TO AVOID ONCOMING CALVES ON A COUNTY DIRT ROAD DRIVER INADVERTANTLY PULLED STEERING WHEEL TO THE RIGHT AND HIT A TREE AT ROAD SIDE. TREE IS TWELVE INCHED FROM ROAD SURFACE. BEFORE SEAT BELT RESTRAINED DRIVER, DRIVER'S FORWARD MOMENTUM BROKE THE STEERING WHEEL. DRIVER WAS NOT INJURED. WENT TO LOCAL HOSPITAL ER. SHE…
Read full complaint
IN AN ATTEMPT TO AVOID ONCOMING CALVES ON A COUNTY DIRT ROAD DRIVER INADVERTANTLY PULLED STEERING WHEEL TO THE RIGHT AND HIT A TREE AT ROAD SIDE. TREE IS TWELVE INCHED FROM ROAD SURFACE. BEFORE SEAT BELT RESTRAINED DRIVER, DRIVER'S FORWARD MOMENTUM BROKE THE STEERING WHEEL. DRIVER WAS NOT INJURED. WENT TO LOCAL HOSPITAL ER. SHERIFF INVESTIGATED. WITH THE EXTENSIVE DAMAGE TO THE FRONT END OF THE VEHICLE THE AIR BAG SHOULD HAVE DEPLOYED. IT DID NOT. PHOTOS TAKEN. YOUR ORGANIZATION IS BEING NOTIFIED AS WE FEEL THE AIR BAG SHOULD HAVE DEPLOYED. WE WILL ALSO CONTACT TOYOTA. THANK YOU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED THAT SQUIRRELS WERE ABLE CHEW THROUGH THE WIRING AND THE FUSE BOX FROM UNDER THE VEHICLE. IN ADDITION, THE SQUIRRELS HAD ALSO CHEWED THROUGH THE PLASTIC RADIATOR COVER AND SUPPORT PANEL FOR THE FAN AND THE ABS WARNING LIGHT WAS ILLUMINATED AS A RESULT OF THE DAMAGES. T…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED THAT SQUIRRELS WERE ABLE CHEW THROUGH THE WIRING AND THE FUSE BOX FROM UNDER THE VEHICLE. IN ADDITION, THE SQUIRRELS HAD ALSO CHEWED THROUGH THE PLASTIC RADIATOR COVER AND SUPPORT PANEL FOR THE FAN AND THE ABS WARNING LIGHT WAS ILLUMINATED AS A RESULT OF THE DAMAGES. THE CONTACT WAS CONCERNED BECAUSE THERE WAS NO COVER FOR THE UNDER THE VEHICLE TO PREVENT THE SQUIRRELS OR RODENTS FROM ENTERING AND DAMAGING THE VEHICLE. THE CONTACT STATED THAT THE FAILURE WAS RECURRING. THE FAILURE MILEAGE WAS 2,091 AND THE CURRENT MILEAGE WAS 2,373.
RUST IN THE BOTTOM FRAME OF PRIUS. *TR
Official recalls
613V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606