IllustrationTHE HEADLIGHTS KEEP BLOWING OUT DUE TO POWER SURGE. LEFT - RIGHT - LEFT - RIGHT - LEFT - RIGHT NOW LEFT AGAIN!!! EVERY COUPLE OF MONTHS SINCE I BOUGHT IT LAST FEB 2017.
2009 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2009 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1880–25K
4325–50K
4050–75K
4675–100K
52100–150K
33150K+
402 reports with mileage · 100 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
64 crash reports4 fire reports21 injury reports
Exterior Lighting complaints
111 reportsHEADLIGHTS GO OUT ALL THE TIME. I'VE REPLACED THE BALLASTS AND THE HEADLIGHTS 5 TIMES IN THE LAST YEAR. 1 MONTH AFTER NEW HEADLIGHTS AND NEW BALLASTS THE HEADLIGHTS ARE BACK OUT AGAIN. THIS HAS BEEN A PROBLEM SINCE I GOT THIS CAR. SOMETIMES I CAN TURN THE LIGHTS ON AND OFF AND IT WILL WORK FOR A BIT.
MY HEADLIGHT PASSENGER SIDE KEEPS GOING OUT AFTER A FEW SECONDS OF TURNING ON. THIS KEEPS ME FROM DRIVING AT NIGHT. MY COMPUTER CONTROLS ON MY DASH BOARD THAT WORKS THE AC. AND DISPLAYS THE INFORMATION ABOUT THE CAR DOES NOT WORK. MY ABS BREAK LIGHT WILL NOT GO OFF. THIS HAS AFFECTED MY BREAKING SYSTEM ON MY CAR. ALL OF THESE I…
Read full complaint
MY HEADLIGHT PASSENGER SIDE KEEPS GOING OUT AFTER A FEW SECONDS OF TURNING ON. THIS KEEPS ME FROM DRIVING AT NIGHT. MY COMPUTER CONTROLS ON MY DASH BOARD THAT WORKS THE AC. AND DISPLAYS THE INFORMATION ABOUT THE CAR DOES NOT WORK. MY ABS BREAK LIGHT WILL NOT GO OFF. THIS HAS AFFECTED MY BREAKING SYSTEM ON MY CAR. ALL OF THESE ITEMS I HAVE MENTIONED ALL OCCURRED WHILE I WAS DRIVING THE CAR.
THERE IS A WARRANTY ENHANCEMENT PROGRAM FOR MY 2009 PRIUS WHICH EXPIRES IN MARCH OF 2018 FOR THE COMBINATION METER KNOWN AS CSP ZTV. I TEXT MANUFACTURER AND THEY SAID ITS WARRANTED. THE FIRST DEALER I TOOK IT TO REFUSED TO REPLACE IT 2 DAYS AGO SAYING IT EXPIRED. I CALLED TOYOTA AND THEY SAID IT DIDN'T AFTER I READ THE DATE IT S…
Read full complaint
THERE IS A WARRANTY ENHANCEMENT PROGRAM FOR MY 2009 PRIUS WHICH EXPIRES IN MARCH OF 2018 FOR THE COMBINATION METER KNOWN AS CSP ZTV. I TEXT MANUFACTURER AND THEY SAID ITS WARRANTED. THE FIRST DEALER I TOOK IT TO REFUSED TO REPLACE IT 2 DAYS AGO SAYING IT EXPIRED. I CALLED TOYOTA AND THEY SAID IT DIDN'T AFTER I READ THE DATE IT STARTED BEING IN SERVICE AND SHE SAID IT IS IN PLACE UNTIL MARCH.THE 2ND DEALER REFUSES TO REPAIR UNLESS THEY CAN DUPLICATE CONDITIONS. I CAN NOT TELL THE WEATHER TO FREEZE I AM NOT GOD BUT THEY ARE PLAYING GOD WITH MY MONEY AND MY LIFE TO SAVE THEIR MONEY AND THEIR JOBS. I WANTED REPAIR DONE BEFORE IT HAPPENS AGAIN BUT THEY ARE REFUSING. I COULD RUN OUT OF GAS AND BE KILLED BECAUSE OF FAULTY METER BECAUSE YOU CAN'T READ DISPLAY OR GET A SPEEDING TICKET. THE DEALER I BOUGHT IT FROM CAN VERIFY THIS IS THE PROBLEM BUT THEY ARE NOT A TOYOTA DEALER. WHAT IF WE HAVE A MILD WINTER AND IT DOESN'T HAPPEN THIS YEAR BUT HAPPENS FALL OF 2019 THEN I HAVE TO PAY FOR IT AND ITS THEIR FAULT NOT MINE THIS IS LAWLESSNESS BECAUSE SOMEONE IS TRYING TO KEEP FROM PAYING FOR THEIR ERROR. THIS IS STEALING. HOW CAN I GET A REMEDY TO THIS? THEY SHOULD HAVE BEEN FORCED TO DO A RECALL INSTEAD OF WHAT THEY ARE DOING IT IS NOT RIGHT TO DO TO CONSUMER. IT IS STATIONARY FOR DISPLAY LIGHTS BUT YOU DON' T KNOW WHEN THEY WILL TURN ON AND RESTARTING CAR DOES NOT RESOLVE PROBLEM. ALSO WHEN YOU CAN'T LEAVE CAR THERE BECAUSE LIGHTS AREN'T ON IF CAR DOESN'T SHUT OFF THIS A DILEMMA AND TOW TRUCKS DON'T CARRY THESE METERS. ALSO WHEN CAR DOESN'T QUIT RUNNING IT IS STATIONARY. THE RECALL IS CSP ZTV.
DURING THE WINTER MONTHS WHEN IT GETS BELOW 30 THE LIGHTS ON THE VEHICLE DASHBOARD GO OUT WHEN THE VEHICLE IS TURNED ON AND REMAIN OFF WHILE DRIVING AND YOU CAN'T SEE HOW FAST YOU ARE DRIVING OR ANY OF THE INSTRUMENT PANEL OR WARNING LIGHTS TO KNOW IF YOU NEED GAS, TIRES ARE LOW, ETC. I TOOK INTO A DEALERSHIP AND THEY SAID THE…
Read full complaint
DURING THE WINTER MONTHS WHEN IT GETS BELOW 30 THE LIGHTS ON THE VEHICLE DASHBOARD GO OUT WHEN THE VEHICLE IS TURNED ON AND REMAIN OFF WHILE DRIVING AND YOU CAN'T SEE HOW FAST YOU ARE DRIVING OR ANY OF THE INSTRUMENT PANEL OR WARNING LIGHTS TO KNOW IF YOU NEED GAS, TIRES ARE LOW, ETC. I TOOK INTO A DEALERSHIP AND THEY SAID THERE HAD BEEN A RECALL ON IT BUT I DO NOT SEE IT LISTED.
WHILE DRIVING, MY HEADLAMPS WILL FLICKER AND THEN GO OUT. SOMETIMES THIS COULD TAKE 5 MINUTES, SOMETIMES THIS COULD TAKE 20. WHEN FLICK THE LIGHTS OFF AND BACK ON, THEY RESET FOR A LITTLE WHILE. THE TOYOTA DEALERSHIP TOLD ME THAT THEY COULD NOT DO ANYTHING, BECAUSE THEY'VE SEEN THIS HAPPEN BEFORE. MY VEHICLE BEGAN DOING THIS AT …
Read full complaint
WHILE DRIVING, MY HEADLAMPS WILL FLICKER AND THEN GO OUT. SOMETIMES THIS COULD TAKE 5 MINUTES, SOMETIMES THIS COULD TAKE 20. WHEN FLICK THE LIGHTS OFF AND BACK ON, THEY RESET FOR A LITTLE WHILE. THE TOYOTA DEALERSHIP TOLD ME THAT THEY COULD NOT DO ANYTHING, BECAUSE THEY'VE SEEN THIS HAPPEN BEFORE. MY VEHICLE BEGAN DOING THIS AT 98,000 MILES AND CONTINUE TO DO THIS AT 130,000 MILES. I'VE READ ON FORUMS THAT OTHER DRIVERS HAVE EXPERIENCED THIS SAME THINGS.
OVER THE COURSE OF MY OWNERSHIP OF THE PAST 3 YEARS, I HAVE REPLACED 3 HEADLIGHTS, DUE TO BROKEN/FAULTY SEALS THAT ALLOW MOISTURE INTO THE HOUSING, AND BURNING OUT THE BALLAST WHICH IN MY OPINION IS A DESIGN FLAW AS THE BALLAST RESTS AT THE BOTTOM OF THE HEADLIGHT ASSEMBLY. I CURRENTLY AM DEALING WITH A RIGHT HEADLIGHT THAT GO…
Read full complaint
OVER THE COURSE OF MY OWNERSHIP OF THE PAST 3 YEARS, I HAVE REPLACED 3 HEADLIGHTS, DUE TO BROKEN/FAULTY SEALS THAT ALLOW MOISTURE INTO THE HOUSING, AND BURNING OUT THE BALLAST WHICH IN MY OPINION IS A DESIGN FLAW AS THE BALLAST RESTS AT THE BOTTOM OF THE HEADLIGHT ASSEMBLY. I CURRENTLY AM DEALING WITH A RIGHT HEADLIGHT THAT GOES OUT AND I NEED TO TURN THE SWITCH OFF AND ON FOR THE LIGHT TO RETURN BRIEFLY. THE HEADLAMP ASSEMBLY IS ABOUT $250 PLUS LABOR COSTS OF INSTALLATION.
LIGHTS FLICKERING GOING OUT
THE 2009 TOYOTA PRIUS IS NOTORIOUS FOR HAVING HEAD LIGHT PROBLEMS. WHAT HAPPENED IS WHEN THE HEADLIGHT ARE TURNED ON THEY WILL AUTOMATICALLY TURN OFF SOMETIMES IT'S THE LEFT ONE SOMETIMES THE RIGHT ONE SOMETIMES BOTH THIS HAPPENS REGARDLESS IF YOU'RE DRIVING ON A HIGHWAY ON A CITY STREET OR NOT IN-MOTION. I HAVE BEEN PULLED…
Read full complaint
THE 2009 TOYOTA PRIUS IS NOTORIOUS FOR HAVING HEAD LIGHT PROBLEMS. WHAT HAPPENED IS WHEN THE HEADLIGHT ARE TURNED ON THEY WILL AUTOMATICALLY TURN OFF SOMETIMES IT'S THE LEFT ONE SOMETIMES THE RIGHT ONE SOMETIMES BOTH THIS HAPPENS REGARDLESS IF YOU'RE DRIVING ON A HIGHWAY ON A CITY STREET OR NOT IN-MOTION. I HAVE BEEN PULLED OVER NUMEROUS TIMES FOR THIS DUE TO THE FACT THAT I HAPPENS ANYTIME THE HEADLIGHTS ARE TURNED ON IT IS DANGEROUS DUE TO THE FACT THAT WHEN YOUR HEADLIGHTS TURN COMPLETELY OFF ON A REGULAR BASIS YOU LOSE VISIBILITY. AND CONSIDERING 90% OF THE TIME WHEN YOUR HEADLIGHTS ARE TURNED ON IT'S NIGHT TIME EVEN WORSE. IN ORDER TO FIX THE PROBLEM WHAT YOU HAVE TO DO IS TURN THE HEADLIGHTS ON AND OFF AND THAT WILL SOMETIMES MAKE THEM TURN ON AGAIN THE THEN BEHOLD THEY WILL AUTOMATICALLY TURN OFF AGAIN LIKE I SAID THIS HAPPENS TO ME AT LEAST 10 TIMES EVERY TIME I DRIVE AT NIGHT. IF YOU LOOK ONLINE YOU WILL FIND COUNTLESS PRIUS OWNERS WHO HAVE THE SAME PROBLEM AS ME YET TOYOTA HAS NOT PUT A RECALL ON THIS. THIS IS EXTREMELY DANGEROUS WHEN YOU ARE DRIVING AT NIGHT.
THE HEADLIGHT JUST GO OFF WHILE DRIVING. ONCE YOU TURN THE LIGHT SWITCH OFF AND THEN ON THEY COME BACK ON FOR A SHORT TIME. THE DEALER IS WANTING $1,400 TO MAKE THE REPAIRS. THIS IS EXTREMELY DANGEROUS WHILE DRIVING AT NIGHT. THERE SHOULD BE A RECALL ON THESE VEHICLES.
Official recalls
613V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606